Engine Mechanical - Service, Testing And Troubleshooting
- Symptom Troubleshooting Index
- System Inspection
- Connector View
- General Information
- Engine Configuration
- How to Connect the HDS
- How to Set Readiness Codes
- Malfunction Indicator Lamp (MIL) Indication (In relation to Readiness Codes)
- Catalytic Converter Monitor and Readiness Code
- Evaporative Emission (EVAP) Control System Monitor and Readiness Code
- Air Fuel Ratio (A/F) Sensor Monitor and Readiness Code
- Air Fuel Ratio (A/F) Sensor Heater Monitor Readiness Code
- Misfire Monitor and Readiness Code
- Fuel System Monitor and Readiness Code
- Comprehensive Component Monitor and Readiness Code
- EGR Monitor and Readiness Code
- Symptom Troubleshooting Index for Viewer
- After Warming Up, Idle Speed Is Above Specifications Without Load (MIL Works OK, No DTCs Set) (USA/Canada models)
- After Warming Up, Idle Speed Is Below Specifications Without Load (MIL Works OK, No DTCs Set) (USA/Canada models)
- Auto Idle Stop System Does Not Operate (2019, 2020, 2021)
- Auto Idle Stop System Does Not Operate (2022, 2023)
- Auto Idle Stop System Indicator (Green/Amber) Does Not Come On (2019, 2020, 2021)
- Auto Idle Stop System Indicator Does Not Come On:Auto Idle Stop Indicator (Green) Auto Idle Stop System Indicator (Amber) Auto Idle Stop OFF Indicator (White) Auto Idle Stop Suspend Indicator (White) (2022, 2023)
- Cold Fast Idle Too High (MIL Works OK, No DTCs set) (USA/Canada models)
- Cold Fast Idle Too Low (MIL Works OK, No DTCs Set) (USA/Canada models)
- Difficult To Refuel (MIL Works OK, No DTCs Set) (USA/Canada models)
- Engine Is Hard To Start (MIL Works OK, No DTCs Set) (USA/Canada models)
- Engine Stalls (MIL Works OK, No DTCs Set) (USA/Canada models)
- Engine Starts But Stalls Immediately (MIL Works OK, No DTCs Set, Security Indicator Stays On Or Flashes) (USA/Canada models)
- Engine Will Not Start (MIL Works OK, No DTCs Set) (USA/Canada models)
- Engine Will Not Start (MIL Works OK, No DTCs Set, Security Indicator Stays On Or Flashes) (USA/Canada models)
- Engine Will Not Start And HDS Does Not Communicate With The PCM (MIL Comes On And Stays On, No DTCs Set) (USA/Canada Models)
- HDS Does Not Communicate With The PCM Or The Vehicle (USA/Canada models)
- Idle Speed Fluctuates (MIL Works OK, No DTCs Set) (USA/Canada models)
- Idle Stop Time Is Short (2019, 2020, 2021)
- Idle Stop Time Is Short (2022, 2023)
- Low Power (MIL Works OK, No DTCs Set) (USA/Canada models)
- MIL Comes On And Stays On, Or Never Comes On At All, No Dtcs Set (USA/Canada models)
- Starter System Warning Message Stays On (No DTCs Set) (2019, 2020, 2021)
- Starter System Warning Message Stays On (No DTCs set) (2022, 2023)
- Troubleshooting
- Removal and Installation
- APP Sensor Signal Inspection
- Air Cleaner Element Inspection
- Balancer Shaft Inspection
- Block and Piston Inspection
- CKP Pattern Clear/CKP Pattern Learn Procedure
- Cam Chain Inspection
- Cam Chain Removal and Installation
- Camshaft Inspection
- Camshaft Timing Inspection
- Connecting Rod Bearing Adjustment
- Connecting Rod and Crankshaft End Play Inspection
- Crankshaft Inspection
- Crankshaft Main Bearing Adjustment
- Cylinder Bore Honing
- EVAP Canister Purge Valve Inspection
- Engine Compression Inspection
- Engine Oil Jet Inspection
- Engine Removal and Installation
- Engine Support Hanger Installation
- Idle Speed Inspection
- Idle Stop Off Switch Test
- Injector Removal and Installation
- Intake Manifold Removal and Installation
- Jet Pump Test
- PCM Idle Learn Procedure
- PCM Reset
- PCM Update
- PCV Valve Inspection
- Piston, Ring, Pin, and Connecting Rod Inspection
- Rocker Arm and Shaft Inspection
- Three Way Catalytic Converter Inspection
- Throttle Body Carbon Accumulation Check
- Throttle Body Cleaning
- Turbocharger Bypass Control Solenoid Valve Inspection
- Turbocharger Bypass Control Valve Inspection
- VTC Actuator Inspection
- VTC Oil Control Solenoid Valve Test
- VTEC Rocker Arm Test
- Valve Clearance Adjustment
- Valve Inspection
- Valve Seat Reconditioning
- Valve Stem-to-Guide Clearance Inspection
- Component Location Index
- Construction and Function
- Auto Idle Stop System Description (2019, 2020, 2021)
- Auto Idle Stop System Description (2022, 2023)
- Auto Idle Stop System Description - Operation Conditions (2019, 2020, 2021)
- Auto Idle Stop System Description - Operation Conditions (2022, 2023)
- EVAP System Description
- Electronic Throttle Control System Description (2019, 2020, 2021)
- Electronic Throttle Control System Description (2022 2023)
- PCV System Description
- PGM-FI System Description
- PGM-FI System Description - Components
- PGM-FI System Description - On-Board Snapshot
- Turbocharger Control System Description
- VTEC/VTC System Description