Maintenance Schedules - NAFTA

Your vehicle is equipped with an automatic oil change indicator system. The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance. Based on engine operation conditions, the oil change indicator message will illuminate in the instrument cluster. This means that an engine oil and engine oil filter change is required for your vehicle. Operating conditions such as frequent short-trips, trailer tow, extremely hot or cold ambient temperatures will influence when the "Change Oil" or "Oil Change Required" message is displayed. Severe Operating Conditions can cause the change oil message to illuminate as early as 3, 500 miles (5, 600 km) since last reset. Have your vehicle serviced as soon as possible, within the next 500 miles (805 km). TheWrenchWarning Light may appear in the cluster as a service reminder when vehicle maintenance is required, according to the scheduled maintenance mileage. The maintenance schedule intervals are set by the manufacturer. Failure to have them carried out may void your New Vehicle Limited Warranty.

Severe Duty All Models

• In addition, if your vehicle is used under demanding conditions, including:
  • On the track
  • On dusty roads
  • Short, repeated trips (less than 4-5 miles or 7-8 km) at sub-zero temperatures
  • Allowing the engine to idle for extended periods of time
  • Driving for long distances at low speeds
  • Allowing the vehicle to sit for long periods of inactivity
• Under any of the above circumstances, the following checks need to be performed more frequently than indicated in the Maintenance Schedule:
  • Check front and rear disc brake pad condition and wear
  • Check cleanliness of tailgate locks.
  • Check cleanliness and lubrication of chassis and steering linkage
  • Visually inspect condition of: engine, gearbox, transmission, pipes and hoses (exhaust - fuel system - brakes) and rubber elements (gaiters - sleeves - bushes - etc.)
  • Check battery charge and battery fluid level (electrolyte)
  • Visually inspect condition of the auxiliary drive belts
  • Check and, if necessary, change engine oil and replace oil filter
  • Check and, if necessary, replace air cleaner
• Using the vehicle on a track should be regarded as an exception. The vehicle has been designed and manufactured for road use.
• Change Engine Oil at 4, 000 miles (6, 500 km) if the vehicle is operated in a dusty and off road environment. This type of vehicle use is considered Severe Duty.
• If the vehicle is operated in a dusty or dirty environment the engine air filter has to be changed every 6, 500 miles (10, 000 km).

Once A Month Or Before A Long Trip/Periodic Checks

• Every 600 miles (1, 000 km) or before long trips, check and, if necessary, top off the following:
  • Check engine oil level
  • Check brake fluid level
  • Check windshield washer fluid level
  • Check the tire inflation pressures and look for unusual wear or damage
  • Check the fluid levels of the coolant reservoir and brake master cylinder reservoir, and add as needed
  • Check function of all interior and exterior lights
  • Check screen wash/wipe system and positioning/ wear of windscreen
• Every 2, 000 miles (3, 000 km) check and, if necessary, top up: engine oil level

Change Engine Oil Message Reset

• Without pressing the brake pedal, cycle the ignition to the MAR (ON-RUN) position (do not start the engine).
• Press and hold the accelerator pedal.
• Press and release the brake pedal 6 times; with a 1 second pause between each press.
• After the 6th release of the brake pedal, pause 1 second and then release the accelerator pedal.
• OR 
• To reset the "Change Engine Oil" message, a scan tool can be used.

Wrench Warning Light Reset

• To reset the "Wrench Warning" indicator light the use of a scan tool is required.

Mileage or time passed (whichever comes first)	12, 000	24, 000	36, 000	48, 000	60, 000	72, 000	84, 000	96, 000	108, 000	120, 000	132, 000	144, 000	156, 000
Or Months:	12	24	36	48	60	72	84	96	108	120	132	144	156
Or Kilometers:	20, 000	40, 000	60, 000	80, 000	100, 000	120, 000	140, 000	160, 000	180, 000	200, 000	220, 000	240, 000	260, 000
Check battery charge status and possibly recharge #	X	X	X	X	X	X	X	X	X	X	X	X	X
Check tire condition/wear and adjust pressure if required	X	X	X	X	X	X	X	X	X	X	X	X	X
Check lighting system operation (headlights, direction indicators, hazard lights, passenger compartment lights, boot lights, instrument panel warning lights, etc.)	X	X	X	X	X	X	X	X	X	X	X	X	X
Check vehicle fasteners +	X		X		X		X		X		X		X
Check mechanical components fasteners +	X	X	X	X	X	X	X	X	X	X	X	X	X
Check windscreen wiper/washer operation, adjust nozzles	X	X	X	X	X	X	X	X	X	X	X	X	X
Check position/wear of windscreen wiper blade	X	X	X	X	X	X	X	X	X	X	X	X	X
Check cleanliness of hood and deck lid locks, as well as cleanliness and lubrication of associated linkages	X	X	X	X	X	X	X	X	X	X	X	X	X
Visually inspect condition of: exterior bodywork, carbon monocoque, aerodynamic bottom, pipes and hoses (exhaust, fuel supply system, brakes), rubber elements (boots, driveshaft boots, sleeves, bushes, etc.)	X	X	X	X	X	X	X	X	X	X	X	X	X
Check condition and wear of front brake pads and discs, and operation of pad wear indicator	X	X	X	X	X	X	X	X	X	X	X	X	X
Check condition and wear of rear brake pads and discs, and operation of pad wear indicator	X	X	X	X	X	X	X	X	X	X	X	X	X
Check and top off, if required, fluid levels (engine coolant, brake/hydraulic clutch fluid, windscreen washer fluid, battery fluid, etc)	X	X	X	X	X	X	X	X	X	X	X	X	X
Visually inspect the condition of accessory drive belt(s)			X			X			X			X
Check condition of timing belt			X					X					X
Check handbrake lever travel and adjust, if necessary (or every 12 months)	X	X	X	X	X	X	X	X	X	X	X	X	X
Check engine control system operation (via diagnostic tool)	X	X	X	X	X	X	X	X	X	X	X	X	X
Check and, if necessary, top off oil level of twin clutch transmission						X						X
Replace accessory drive belt(s)					X						X
Replace spark plugs *			X			X			X			X
Replace toothed timing drive belt **					X					X
Change engine oil and oil filter ***
Change brake fluid every 24 months *****		X		X		X		X		X		X
Replace air filter cartridge ****	X	X	X	X	X	X	X	X	X	X	X	X	X

(#) Recommend using Midtronics tester to check charge status and, if necessary, recharge battery.

(*) The spark plug change interval is mileage based only, yearly intervals do not apply. The following are essential to ensure correct operation and prevent serious damage to the engine:

• Only use spark plugs of the same make and type which are specially certified for such engines (refer to "Fluids, Lubricants and Genuine Parts" in "Maintaining Your Vehicle" for further information).
• Strictly comply with the spark plug replacement interval given in the maintenance schedule for spark plug replacement.
• Contact your Alfa Romeo Dealer if you have questions.

(**) Regardless of the distance covered, the timing belt must be changed every 4 years for particularly demanding use (cold climates, city driving, long periods of idling) or at least every 5 years.

(***) The actual interval for changing the oil and replacing the engine oil filter depends on the vehicle usage conditions and is signalled by the warning light or message (if present) on the instrument panel or every 12 months.

(****) If the vehicle is operated in a dusty or dirty environment the engine air filter has to be changed every 6, 500 miles (10, 000 km).

(*****) DOT 4 brake fluid must be changed every two years regardless of mileage.

(+) Refer to the following section for fastener tightening specifications and locations and. Refer to MAINTENANCE SCHEDULES, INSPECTION . Refer to MAINTENANCE SCHEDULES, INSPECTION .