Torque Specifications
TORQUE SPECIFICATIONS
| Application | Ft Lbs. (N.m) |
|---|---|
| Accelerator Cable Bracket Retaining Nuts & Bolts | 12 (16) |
| Boost Solenoid Bolts | 19 (26) |
| Bypass Valve Actuator Mounting Bolts | 18 (25) |
| Crankshaft Position Sensor Bolt | 22 (30) |
| EGR Valve Inlet Pipe Stud | 37 (50) |
| EGR Valve Inlet Pipe To Exhaust Manifold Bolt | 21 (29) |
| EGR Valve Outlet Pipe To Inlet Pipe Nut | 21 (29) |
| EGR Valve Outlet Pipe To Intake Manifold Bolt | 21 (29) |
| EGR Valve Retaining Nuts | 22 (30) |
| Engine Coolant Temperature Sensor | 15 (20) |
| Exhaust Gas Recirculation Valve Inlet Pipe Bolt | 37 (50) |
| Fuel Tank Retaining Strap Bolts | 31 (42) |
| Heated Oxygen Sensors | 30 (41) |
| In-Line Fuel Filter Outlet Nut | 22 (30) |
| Knock Sensor | 14 (19) |
| Knock Sensor Heat Shield Bolts | 44 (60) |
| MAP Sensor Bracket Bolts | 22 (30) |
| Spark Plug (Initial Installation) | 20 (27) |
| Spark Plug (Reinstallation) | 11 (15) |
| Supercharger Stud/Bolts | 17 (23) |
| INCH Lbs. (N.m) | |
| Air Cleaner Element Cover Wing Screws | 13 (1.5) |
| Air Cleaner Intake Duct Clamp | 18 (2.0) |
| Air Cleaner Top Cover Screws | 27 (3.0) |
| Air Cleaner Upper & Lower Housing Screws | 35 (4.0) |
| Boost Control Solenoid Retaining Nut | 71 (8.0) |
| Booster Bypass Nut | 89 (10.0) |
| Camshaft Position Sensor Retaining Bolt | 89 (10.0) |
| Evaporative Emission Canister Bracket Nuts | 53 (6.0) |
| Evaporative Emission Canister Vent Valve Bolt | 53 (6.0) |
| Fuel Rail Hold Down Bolts | 89 (10.0) |
| Fuel Rail Hold Down Nuts | 89 (10.0 |
| Fuel Sender Access Panel Bolts | 18 (2.0) |
| Fuel Tank Filler Pipe Ground Strap Screw | 80 (9.0) |
| Fuel Tank Filler Pipe Hose Clamp | 31 (3.5) |
| Idle Air Control Valve Attaching Screws | 27 (3.0) |
| Ignition Coil To Ignition Control Module Screws | 40 (4.5) |
| Ignition Control Module 14-Way Connector To Module Bolt | 19 (2.1) |
| Intake Air Duct Clamps | 18 (2.0) |
| Manifold Absolute Pressure Sensor Retaining Screw | 44 (5.0) |
| Mass Air Flow Sensor Attaching Screws | 27 (3.0) |
| Powertrain Control Module Harness Connector To PCM | 71 (8.0) |
| Throttle Body Retaining Nuts | 89 (10.0) |
| Throttle Body Support Bracket Fasteners | 89 (10.0) |
| Throttle Position Sensor Screws | 18 (2.0) |
| Vacuum Block Bolts | 89 (10.0) |
| Wiring Harness Heat Shield Bolt & Nut | 89 (10.0) |