Engine Controls - System And Engine Component Tests 5.7L

• Introduction
• A & C Chart Reference Table
• Computerized Engine Controls
  • Pcm Power & Ground Check
    • Ground Circuits
    • Power Circuits
• Engine Sensors & Switches
  • Notes
  • A/C On (A/C Request) Switch Test
  • A/C Pressure Sensor
  • A/C Pressure Switch
  • Brake Switch
  • Crankshaft Position Sensor
  • Engine Coolant Temperature (ECT) Sensor
  • Engine Oil Temperature Sensor
  • Fuel Tank Vapor Pressure Sensor
  • Intake Air Temperature (IAT) Sensor
  • Knock Sensor (KS)
  • Manifold Absolute Pressure (Map) Sensor (C-1)
  • Manifold Air Temperature (Mat) Sensor
  • Oxygen Sensor (O2S)
  • Park/Neutral Position (PNP) Switch (C-1)
  • Power Steering Pressure (PSP) Switch
  • Throttle Position (TP) Sensor
  • Vehicle Speed Sensor (Pm Generator Type)
  • Vehicle Speed Sensor (Led Type)
• Motors, Relays & Solenoids
  • Motors
    • Idle Air Control (IAC) Motor
  • Relays
    • A/C Clutch Relay
    • Electric AIR Pump Relay
    • Fuel Pump Relay
  • Solenoids
    • Notes
    • AIR By-Pass Valve Solenoid
    • Canister Purge Solenoid
    • EGR Control Solenoid
• Fuel System
  • Fuel Delivery
    • Notes
    • Fuel Pressure Regulator
    • Fuel Pump Relay (A-5)
    • Fuel Pump Relay By-Pass Procedure
    • Oil Pressure Switch Fuel Pump Back-Up
  • Fuel Control
    • Fuel Injector(s)
    • Injector Balance Test (C-2)
    • Injector Leak Test
    • Oxygen Sensor
• Idle Control System (C-2)
  • Idle Air Control (IAC) Motor
• Ignition System
  • Notes
  • Timing Control Systems
    • Ignition Control (IC) Timing Advance System
    • Knock Sensor (KS) System Without KS Controller (C-5)
    • Knock Sensor (KS) System With KS Controller (C-5)
• Emission Systems & Sub-Systems
  • Air Injection (C-6)
    • AIR Pump (Belt-Driven)
    • Check Valve
    • Electric AIR Pump Relay
  • Exhaust Gas RECIRCULATION (C-7)
    • Notes
    • System Test (Vacuum Operated)
    • EGR Control Solenoid (Normally Closed)
    • EGR Control Solenoid (Normally Open)
    • Negative Backpressure EGR Valve
    • Positive Backpressure EGR Valve
  • Fuel Evaporation Control (C-3)
    • Canister Purge Solenoid (Normally Closed)
    • Fuel Tank Pressure Control Valve
  • Positive Crankcase Ventilation (PCV)
    • Required Service
    • A leaking PCV valve or hose could cause:
    • Checking PCV Valve Function
• Miscellaneous Controls
  • Notes
  • Hot Light Or Coolant Temperature Light
  • Transmission (C-8)
    • Converter Clutch Solenoid
    • Converter Lock-Up Signal At Transmission
    • Converter Lock-Up Signal From PCM
    • 1-4 Upshift System Check (Man. Trans.)
    • 1-4 Upshift System Relay (Man. Trans.)
  • Pcm Controlled Warning Lights (C-16)
    • Warning Light Diagnosis
  • A/C Clutch (C-10)
    • Notes
    • A/C Clutch Relay
  • Electric Cooling Fan (C-12)
    • Notes
    • Cooling Fan System
    • Cooling Fan Relay
    • Cooling Fan Motor
• C-10 & C-12 Diagnostic Tests
  • Notes
  • C-10, A/C Clutch Circuit Diagnosis
    • Description
    • Compressor Clutch Control Circuit Diagnosis
  • C-12, Cooling Fan Circuit Diagnosis
    • Description
    • Electric Cooling Fan Functional Check
    • Cooling Fan Symptom Check No. 1
    • Cooling Fan Symptom Check No. 2
    • Cooling Fan Symptom Chart No. 3
• Component Locations