HVAC Torque Specifications
WARNING: This page is about a different car, the 2003 Pontiac Montana, 2003 Oldsmobile Silhouette, and 2003 Chevrolet Venture. However, it is still accessible from the selected car via links, so may be relevant.
HVAC TORQUE SPECIFICATIONS
| Application | Ft. Lbs. (N.m) |
|---|---|
| A/C Refrigerant Filter Flare Nut | 11 (15) |
| Air Baffle Bolts | 15 (20) |
| Auxiliary A/C Line Block Fitting Bolt | 15 (20) |
| Auxiliary Evaporator Inlet Tube-To-Evaporator Inlet Tube | 20 (27) |
| Compressor Mounting Bolts | 37 (50) |
| Discharge Hose-To-Compressor Nut | 12 (16) |
| Discharge Hose-To-Condenser Nut | 12 (16) |
| Evaporator Inlet Tube-To-Condenser Bolt | 12 (16) |
| Evaporator Outlet Tube-To-Thermal Expansion Valve Nut | 12 (16) |
| Suction Hose-To-Auxiliary Evaporator Outlet Tube Nut | 12 (16) |
| Suction Hose-To-Compressor Nut | 12 (16) |
| Suction Hose-To-Evaporator Outlet Tube Bolt | 12 (16) |
| INCH Lbs. (N.m) | |
| A/C Refrigerant Pressure Sensor | 44 (5) |
| Actuator Retaining Screws (All) | 14 (1.6) |
| Actuator Screws (All) | 8 (0.9) |
| Air Distributor Cover Screws | 8 (0.9) |
| Air Inlet Housing Screws | 8 (0.9) |
| Auxiliary A/C Line-To-TXV Bolt | 97 (11) |
| Auxiliary Air Distribution Duct Screws | 89 (10) |
| Auxiliary Blower Motor Housing Screws | 14 (1.6) |
| Auxiliary Blower Motor Screws | 14 (1.6) |
| Auxiliary Blower Switch Retaining Screws | 22 (2.5) |
| Auxiliary Heater Core Mounting Screws | 14 (1.6) |
| Auxiliary Heater Core Pipe Clamp Screw | 14 (1.6) |
| Auxiliary HVAC Module Assembly Mounting Bolt/Nut | 89 (10) |
| Auxiliary HVAC Module Case Screws | 14 (1.6) |
| Auxiliary Thermal Expansion Valve Line Clamp Screw | 14 (1.6) |
| Auxiliary Thermal Expansion Valve-To-Evaporator Core Mounting Bolts | 31 (3.5) |
| Blower Motor Mounting Screws | 16 (1.8) |
| Blower Motor Resistor Mounting Screws | 16 (1.8) |
| Center Air Distribution Duct Retaining Nut | 89 (10) |
| Condenser Mounting Bolts | 53 (6) |
| Condenser Tube Clip Bolt | 22 (2.5) |
| Cruise Control Module Mounting Bracket Bolts | 53 (6) |
| Evaporator Inlet Tube Clamp Nut | 29 (3.3) |
| Evaporator Outlet Tube Bracket Bolt | 48.7 (5.5) |
| Heater Core Cover Screws | 8 (0.9) |
| Heater Core Pipe Retaining Clamp Screw | 8 (0.9) |
| Heater Inlet Pipe Bracket Nut | 62 (7) |
| Heater Outlet Duct Screws | 8 (0.9) |
| Hinge Cover Screws | 22 (2.5) |
| HVAC Control Module Retaining Screws | 22 (2.5) |
| HVAC Module Case Screws | 8 (0.9) |
| HVAC Module Mounting Screws | 8 (0.9) |
| HVAC Module-To-Dash Panel Sound Barrier Nuts | 89 (10) |
| HVAC Mounting Bracket Screws | 16 (1.8) |
| Knee Bolster Screws | 22 (2.5) |
| Mode Actuator Mounting Bracket Screws | 8 (0.9) |
| Receiver Dehydrator Lower Mounting Bolts | 53 (6) |
| Receiver Dehydrator Upper Bracket Bolt | 53 (6) |
| Right Hand Temperature Actuator Mounting Bracket Screws | 8 (0.9) |
| Service Port | 98 (11) |
| Temperature Door Lever Bolt | 8 (0.9) |
| Thermal Expansion Valve-To-Evaporator Core Mounting Bolts | 28 (3.2) |
| Wiper Arm Linkage Nuts | 44 (5) |