FixVault
Home › Chevrolet › 2017 › Spark LS, Automatic CVT Trans › Repair and Diagnosis › Transmission › Automatic Trans › Automatic Transmission - JATCO CVT › Specifications › Fastener Specifications

Fastener Specifications

Single Use Non-Threaded Fasteners/Components

Application
NOTE: All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. 
Automatic Transmission Range Selector Lever Washer
Control Valve Body Cover Gasket
Drain Plug Gasket
Fluid Strainer O-ring
Input Shaft O-Ring Seal
Left Front Wheel Drive Shaft Oil Seal
Output Speed Sensor O-Ring Seal
Primary Input Speed Sensor O-Ring Seal
PNP switch
Right Front Wheel Drive Shaft Oil Seal
Secondary Input Speed Sensor O-Ring Seal
Sub Strainer O-ring
Terminal Assembly O-ring
Torque Converter Fluid Seal
Single Use Threaded Fastener/Component Tightening Specifications

Application Specification
Metric (English)
NOTE: All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. 
Torque Converter Bolt 60 N.m (44 lb ft)
Transmission Mount Bolt
  • First Pass:
 58 N.m (43 lb ft)
  • Final Pass:
 Plus 60 - 75 Degrees
Transmission Mount Bracket Bolt
  • First Pass:
 58 N.m (43 lb ft)
  • Final Pass:
 Plus 60 - 75 Degrees
Transmission Mount Strut Bracket Bolt
  • First Pass:
 100 N.m (74 lb ft)
  • Final Pass:
 Plus 60 - 75 Degrees
Transmission Mount Strut Front Bolt
  • First Pass:
 100 N.m (74 lb ft)
  • Final Pass:
 Plus 60 - 75 Degrees
Transmission Mount Strut Rear Bolt
  • First Pass:
 100 N.m (74 lb ft)
  • Final Pass:
 Plus 60 - 75 Degrees
Reusable Threaded Fastener Tightening Specifications

Application Specification
Metric (English)
NOTE: All fasteners listed in this table can be reused after removal. 
Automatic Transmission Range Selector Lever Nut 17 N.m (13 lb ft)
Control Valve Body Cover Bolt 6 N.m (53 lb in)
Control Valve Body Mounting Bolt 8 N.m (71 lb in)
Drain Plug 34 N.m (25 lb ft)
Fluid Strainer Mounting Bolt 8 N.m (71 lb in)
Manual Plate Mounting Nut 22 N.m (16 lb ft)
Output Speed Sensor Bolt 6 N.m (53 lb in)
Overflow Tube 15 N.m (11 lb ft)
PNP Switch Bolt 6 N.m (53 lb in)
Primary Speed Sensor Bolt 6 N.m (53 lb in)
Secondary Speed Sensor Bolt 6 N.m (53 lb in)
Sub Strainer Bolt 8 N.m (71 lb in)
Transmission Control Module (TCM) Screw 5 N.m (44 lb in)
Transmission Lower Bolt 58 N.m (43 lb ft)
Transmission Mount Frame Side Bracket Bolt 58 N.m (43 lb ft)
Transmission Mount Frame Side Bracket Nut 58 N.m (43 lb ft)
Transmission Range Selector Lever Cable Bracket Bolt 22 N.m (16 lb ft)
Transmission Range Selector Lever Cable Clip Nut 6 N.m (53 lb in)
Transmission Range Selector Lever Cable Grommet Nut 6 N.m (53 lb in)
Transmission Shift Control Bolt 9 N.m (80 lb in)
Transmission Upper Bolt 58 N.m (43 lb ft)
Transmission Upper Nut 58 N.m (43 lb ft)
About FixVault