Fastener Specifications
WARNING: This page is about a different car, the 2019 Chevrolet Malibu. However, it is still accessible from the selected car via links, so may be relevant.
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Engine Coolant Thermostat Housing Gasket |
| Engine Coolant Thermostat Housing Seal |
| Engine Oil Cooler Gasket |
| Engine Oil Cooler Housing Seal |
| Engine Oil Cooler Seal |
| Thermostat Bypass Pipe Gasket |
| Turbocharger Coolant Feed Pipe Copper Washer |
| Turbocharger Coolant Feed Pipe Retainer |
| Turbocharger Coolant Return Pipe Copper Washer |
| Water Outlet Seal |
| Water Pump Inlet Pipe Seal |
| Water Pump Seal |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Water Pump Bolt (LTG) | |
|
25 N.m (18 lb ft) |
|
25 N.m (18 lb ft) |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Airbag Front End Discriminating Sensor Duct Bolt (LTG) | 2.5 N.m (22 lb in) |
| Charge Air Cooler to Radiator Bolt | 5.1 N.m (45 lb in) |
| Charge Air Cooler Temperature Sensor to Charge Air Cooler Bolt | 4 N.m (35 lb in) |
| Charge Air Cooler Outlet Bracket Bolt (LFV) | 9 N.m (80 lb in) |
| Charge Air Cooler Inlet and Outlet Pipe/Tube Bolt | 22 N.m (16 lb ft) |
| Engine Coolant Air Bleed Pipe Fastener (LTG) | 9 N.m (80 lb in) |
| Engine Coolant Fan Heat Shield Bolt (LTG) | 1.5 N.m (13 lb in) |
| Engine Coolant Fan Shroud Bolt | 5.1 N.m (45 lb in) |
| Engine Coolant Heater | 50 N.m (37 lb ft) |
| Engine Coolant Thermostat Housing Bolt | 10 N.m (89 lb in) |
| Engine Oil Cooler Bolt (LKN) | 10 N.m (89 lb in) |
| Engine Oil Cooler Housing Bolt (LKN) | 25 N.m (18 lb ft) |
| Engine Oil Cooler Large Bolt (LFV) | 25 N.m (18 lb ft) |
| Engine Oil Cooler Small Bolt (LFV) | 10 N.m (89 lb in) |
| Front Bumper Shutter Bolt (LFV, LKN, LTG) | 2.5 N.m (22 lb in) |
| Ground Nut | 6 N.m (53 lb in) |
| Radiator Air Upper/Lower Deflector Bolt (LFV, LKN, LTG) | 2.5 N.m (22 lb in) |
| Radiator Surge Tank Bolt | 9 N.m (80 lb in) |
| Radiator Upper Bracket Nut | 7 N.m (62 lb in) |
| Radiator Upper Mount Bracket Bolt | 7 N.m (62 lb in) |
| Thermostat Bypass Pipe Bolt (LFV, LTG) | 10 N.m (89 lb in) |
| Turbocharger Coolant Feed Pipe Bolt (LTG) | 10 N.m (89 lb in) |
| Turbocharger Coolant Feed Pipe Hollow Bolt (LFV, LTG) | 35 N.m (310 lb in) |
| Turbocharger Coolant Return Pipe Bolt (LFV, LTG) | 10 N.m (89 lb in) |
| Turbocharger Coolant Return Pipe Hollow Bolt (LFV, LTG) | 35 N.m (310 lb in) |
| Water Outlet Bolt (LFV, LKN) | 10 N.m (89 lb in) |
| Water Outlet Fastener (LTG) | 12 N.m (106 lb in) |
| Water Pump Bolt (LFV) | 25 N.m (18 lb ft) |
| Water Pump Bolt (LKN) | 9 N.m (80 lb in) |
| Water Pump Inlet Pipe Bolt (LKN) | 25 N.m (18 lb ft) |
| Water Pump Pulley Bolt (LKN) | 10 N.m (89 lb in) |