Technical Service Bulletins

• A/C Compressor
  • A/C End Cover/Valve Plate Leak - Revised Rebuild Kit (24-01-89)
  • A/C Diagnosis - H-Valve Diagnosis/Testing (24-07-83)
• Automatic Trans
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • A/T Failure - ATF Cooler Flushing Procedure (21-10-89)
  • AURO Trans High Pullout Effort From Park (21-14-87)
  • Torque Converter Shudder - ATF Type (21-04-85)
  • Torque Converter Replacement Trans Repair Caution (21-11-85)
  • A413/A470 Trans No Manual 1ST Gear - MISADJUST Cable (21-03-84)
  • Transaxle Dipstick Vent Leak - Higher Vent Dipstick (21-04-84)
  • Delayed 1-2 Shift After Driving In R -Throttle Valve (21-05-83)
  • Auto Trans Hard Shift Out Of Park - Park Sprag Rod (21-02-83)
• Auxiliary Emission Control Systems
  • 2.6L Eng Vapor Lock - Electric Fuel Pump System (18-05-86)
  • 2.2L Carb Eng Oil In Air Filter Box - New PCV Valve (14-18-85)
  • 2.2L Carb Eng Cold Sag On ACCEL (18-01-85)
  • Buck/Jerk On DECEL - Vacuum Components Package (14-04-84 REV. A)
  • Intermittent Power Loss - Insulate O2 Wire (08-16-84)
  • LT/Med ACCEL Spark Knock - Vacuum Reducer Package (14-03-84)
  • 2.6L Eng Hard Or No Start After Fuel Fill Up (14-27-84)
  • 2.2L Catalyst Air Injection Tube Buzz/Rattle (11-01-83)
  • Cruise Control Malfunction Diagnosis/Repair (14-20-83)
  • Rough Idle/Off-Idle Hesitation & Surge - New ESA/EFC (14-12-83)
  • ACCEL Sag/Rough Idle On Hot Restart - New ESA/EFC (14-11-83)
• Axle Shafts
  • Driveshaft Key Service Parts Chart (02-08-84)
  • Front Hub/Knuckle Bearing Clunk/Pop - Retainer Plate (02-04-84)
  • Front Hub/Bearing/Seal Revised Replacement (02-01-84)
• Body Interior
  • Audible Message Center Voice/Tone Switch (08-05-83)
• Charging Systems
  • Charging System Diagnosis For All CHRYSLER Vehicles (08-03-86)
• Clutch
  • Clutch Growl At Medium/High Speed - Release Lever (06-02-89 REV. A)
  • Reverse Clash/Clutch Won't Release - Pressure Plate (06-01-86 REV. A)
  • Clutch Hard/Slow/Cable Broken - Check Cable Routing (06-02-85)
• Communication Devices
  • Audible Message Center Control Module Revisions (08-05-83 REV. A)
  • Door Ajar Switch Snap/Sticking/EVA Erratic - R & R (08-02-83)
• Cooling System (Mechanical)
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • EFI Throttle Body Components Service (14-24-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • Exhaust Flex Joint Squeak/Leak - Seal Ring (11-01-84)
  • Alcohol Blend Fuel Cautions (14-36-83)
  • 2.2L Eng Poor Heat/Slow WARMUP - Heater Modification (24-02-83)
• Cruise Control Systems
  • Cruise Control Malfunction Diagnosis/Repair (14-20-83)
• Differentials & Drive Axles
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • Driveshaft Key Service Parts Chart (02-08-84)
• Driveshaft & Universal Joints
  • Driveshaft Key Service Parts Chart (02-08-84)
• Electronic Steering
  • Noisy Front Suspension - Spring Seat/Damper ASSY Kit (02-11-83)
• Electronic Suspension
  • Noisy Front Suspension - Spring Seat/Damper ASSY Kit (02-11-83)
• Engine Control Systems
  • 2.6L Eng Vapor Lock - Electric Fuel Pump System (18-05-86)
  • 2.2L Carb Eng Cold Sag On ACCEL (18-01-85)
  • Intermittent Power Loss - Insulate O2 Wire (08-16-84)
  • Cruise Control Malfunction Diagnosis/Repair (14-20-83)
  • Rough Idle/Off-Idle Hesitation & Surge - New ESA/EFC (14-12-83)
  • Poor Cold Idle - New Cold Fast Idle Adjustment (14-14-83)
  • ACCEL Sag/Rough Idle On Hot Restart - New ESA/EFC (14-11-83)
• Exhaust
  • Exhaust Flex Joint Squeak/Chirp - LOCTITE (11-02-83)
  • 2.2L Catalyst Air Injection Tube Buzz/Rattle (11-01-83)
• Front Suspension
  • Noisy Front Suspension - Spring Seat/Damper ASSY Kit (02-11-83)
• Fuel System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • 2.6L Eng Vapor Lock - Electric Fuel Pump System (18-05-86)
  • Vapor Lock/Fuel Foaming - Electric Fuel Pump System (18-04-86)
  • 2.6L Poor Performance/Fuel Foaming - Repair Kit (18-06-86)
  • 2.6L Eng Propane Idle Check/Set Procedure (14-06-84)
  • Part Throttle Sag/Cold Sag/Warm Surge - Repair Pkg (14-26-84)
  • LT/Med ACCEL Spark Knock - Vacuum Reducer Package (14-03-84)
  • 2.2L Slow Rough Idle After Hot Start Or With A/C On (14-07-84)
  • Poor Cold Idle - New Cold Fast Idle Adjustment (14-14-83)
• Fuses & Circuit Breakers
  • Intermittent Power Loss - Insulate O2 Wire (08-16-84)
  • Door Ajar Switch Snap/Sticking/EVA Erratic - R & R (08-02-83)
• Gauges & Instrument Panels
  • Fails "Co" Emission Inspection - New Logic Module (08-20-82)
  • Audible Message Center Control Module Revisions (08-05-83 REV. A)
  • False Low Fuel Indication - New Travel Comp Module (08-04-83)
• Horns
  • Tilt Column Horn Intermittent - Remove Grease (08-22-84)
• HVAC Control Systems
  • A/C Diagnosis - H-Valve Diagnosis/Testing (24-07-83)
  • 2.2L Eng Poor Heat/Slow WARMUP - Heater Modification (24-02-83)
• Ignition System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • EFI Throttle Body Components Service (14-24-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • New Carb Idle Mixture Screw Concealment Plug R & R (14-05-83)
  • Dieseling After Hot Shutdown - New SOLEKICKER Pkg (14-42-83)
  • 2.2L Eng Poor & Rough Idle - Flow Control Valve Leak (14-16-83)
  • Alcohol Blend Fuel Cautions (14-36-83)
  • Poor DRIVEABILITY Diagnosis/Repair (14-28-83)
  • 2.2L Eng/Auto Trans - Sag - New Choke Housing (14-24-83)
  • Spark Plug Fouling/Failure - Inspection/Cleaning/R & R (14-23-83)
  • Carb Eng Slow/Rough Cold Idle - Reset Hot Fast Idle (14-09-83)
• Infotainment
  • Fails "Co" Emission Inspection - New Logic Module (08-20-82)
• Locking Hubs
  • Noisy Front Suspension - Spring Seat/Damper ASSY Kit (02-11-83)
• Lubrication System
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • New "SG" Quality Engine Oil (10-51-89)
  • EFI Throttle Body Components Service (14-24-85)
  • 2.2L Non Turbo Eng Standard Oil Filter Info (09-16-85)
  • Engine Oil Viscosity Recommendation From CHRYSLER (09-17-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • Oil Pressure Revised Testing Procedure/Specs (09-05-84)
  • Exhaust Flex Joint Squeak/Leak - Seal Ring (11-01-84)
  • Alcohol Blend Fuel Cautions (14-36-83)
• Manual Steering
  • Power Steer Pinion Seal Leak - New Stub Shaft Seals (19-01-83)
• Manual Trans
  • Clash Shifting Into 5TH - New Oiler Tube/End Cover (21-11-84)
  • Manual Trans Hard Shifting - Binding Shift Cable (21-04-83)
• Mechanical
  • New "SG" Quality Engine Oil (10-51-89)
  • Eng W/Jet Valve Miss/Fouled Plugs - REPL Jet Valve (18-17-88)
  • 2.2/2.5L Timing Belt Skips/No Cold Start - Sealing (09-07-86)
  • EFI Throttle Body Components Service (14-24-85)
  • Camshaft Timing Chain Guide Rattle/Breakage - Repair (09-02-85 REV. A)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • 2.6L Eng Start-Up Knock - Add Spacer To TENSIONER (09-09-84)
  • 2.2L Eng New Camshaft Package (09-06-84)
  • 2.6L Eng Oil Fouled Spark Plugs - New Valve Seal (14-29-84)
  • 2.2L Intermediate Shaft Revised R & R (09-04-84)
  • Exhaust Flex Joint Squeak/Leak - Seal Ring (11-01-84)
  • New Carb Idle Mixture Screw Concealment Plug R & R (14-05-83)
  • 2.2L Eng Poor & Rough Idle - Flow Control Valve Leak (14-16-83)
  • Alcohol Blend Fuel Cautions (14-36-83)
  • 2.2L Eng Camshaft/Cylinder Head Oversize Journals (09-06-83)
  • 2.2L Eng/Auto Trans - Sag - New Choke Housing (14-24-83)
  • 2.2L Eng Camshaft Replacement - New Valve Springs (09-07-83)
  • Carb Eng Slow/Rough Cold Idle - Reset Hot Fast Idle (14-09-83)
  • 2.2L Eng Block Heater Installation Procedure (09-01-83)
• Mechanical - Hydraulic
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • Power Brake Booster Vacuum Leak Test Procedure (05-01-83)
• Paint & Coatings
  • Off Color Paint - Color Variance Chart Program (23-02-91)
• Passive Restraints
  • Noisy Front Suspension - Spring Seat/Damper ASSY Kit (02-11-83)
• Rear Suspension
  • Noisy Front Suspension - Spring Seat/Damper ASSY Kit (02-11-83)
• Seats
  • New Rear Seat Shoulder Belt Packages/Installation (23-06-87)
• Starter
  • Charging System Diagnosis For All CHRYSLER Vehicles (08-03-86)
  • EFI Throttle Body Components Service (14-24-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • 2.6L Eng Start-Up Knock - Add Spacer To TENSIONER (09-09-84)
  • Dome Lamp Stuck On/Battery Drain - New Door Switch (08-10-83)
  • Alcohol Blend Fuel Cautions (14-36-83)
• Steering Column
  • Noisy Front Suspension - Spring Seat/Damper ASSY Kit (02-11-83)
• Steering Gear
  • Power Steer Pinion Seal Leak - New Stub Shaft Seals (19-01-83)
• Steering Linkage
  • Front Hub/Knuckle Bearing Clunk/Pop - Retainer Plate (02-04-84)
  • Front Hub/Bearing/Seal Revised Replacement (02-01-84)
  • Noisy Front Suspension - Spring Seat/Damper ASSY Kit (02-11-83)
• System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • 2.6L Eng Vapor Lock - Electric Fuel Pump System (18-05-86)
  • Vapor Lock/Fuel Foaming - Electric Fuel Pump System (18-04-86)
  • 2.6L Poor Performance/Fuel Foaming - Repair Kit (18-06-86)
  • EFI Throttle Body Components Service (14-24-85)
  • 2.2L Carb Eng Oil In Air Filter Box - New PCV Valve (14-18-85)
  • 2.2L Carb Eng Cold Sag On ACCEL (18-01-85)
  • 2.6L Eng Propane Idle Check/Set Procedure (14-06-84)
  • Buck/Jerk On DECEL - Vacuum Components Package (14-04-84 REV. A)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • Intermittent Power Loss - Insulate O2 Wire (08-16-84)
  • Part Throttle Sag/Cold Sag/Warm Surge - Repair Pkg (14-26-84)
  • Exhaust Flex Joint Squeak/Leak - Seal Ring (11-01-84)
  • LT/Med ACCEL Spark Knock - Vacuum Reducer Package (14-03-84)
  • 2.6L Eng Hard Or No Start After Fuel Fill Up (14-27-84)
  • New Carb Idle Mixture Screw Concealment Plug R & R (14-05-83)
  • 2.2L Slow Rough Idle After Hot Start Or With A/C On (14-07-84)
  • Dieseling After Hot Shutdown - New SOLEKICKER Pkg (14-42-83)
  • 2.2L Eng Poor & Rough Idle - Flow Control Valve Leak (14-16-83)
  • 2.2L Catalyst Air Injection Tube Buzz/Rattle (11-01-83)
  • Alcohol Blend Fuel Cautions (14-36-83)
  • Poor DRIVEABILITY Diagnosis/Repair (14-28-83)
  • 2.2L Eng/Auto Trans - Sag - New Choke Housing (14-24-83)
  • Cruise Control Malfunction Diagnosis/Repair (14-20-83)
  • Rough Idle/Off-Idle Hesitation & Surge - New ESA/EFC (14-12-83)
  • Spark Plug Fouling/Failure - Inspection/Cleaning/R & R (14-23-83)
  • Poor Cold Idle - New Cold Fast Idle Adjustment (14-14-83)
  • ACCEL Sag/Rough Idle On Hot Restart - New ESA/EFC (14-11-83)
  • Carb Eng Slow/Rough Cold Idle - Reset Hot Fast Idle (14-09-83)
• Vacuum Pumps/Lines/Tanks/Water Trap
  • 2.6L Eng Start-Up Knock - Add Spacer To TENSIONER (09-09-84)
• Warning Systems
  • Tilt Column Horn Intermittent - Remove Grease (08-22-84)
• Wheel Hubs
  • Front Hub/Knuckle Bearing Clunk/Pop - Retainer Plate (02-04-84)
  • Front Hub/Bearing/Seal Revised Replacement (02-01-84)
• Wheels & Tire System
  • Fwd & RWD Tire Rotation Patterns (22-01-86)
  • Front Hub/Knuckle Bearing Clunk/Pop - Retainer Plate (02-04-84)
  • Front Hub/Bearing/Seal Revised Replacement (02-01-84)
  • Vehicle Wander/Lead - Rotate Tires (22-02-83)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Battery Storage/Diagnosis/Testing/Charging Procedure (08-06-83)
  • Door Ajar Switch Snap/Sticking/EVA Erratic - R & R (08-02-83)