Technical Service Bulletins

• A/C Compressor
  • A/C End Cover/Valve Plate Leak - Revised Rebuild Kit (24-01-89)
• Accessories Control Systems
  • Replaceable Odometer Chip Elimination (08-15-86)
• Automatic Trans
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • A/T Failure - ATF Cooler Flushing Procedure (21-10-89)
  • AURO Trans High Pullout Effort From Park (21-14-87)
  • A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
  • Torque Converter Shudder - ATF Type (21-04-85)
  • Torque Converter Replacement Trans Repair Caution (21-11-85)
  • 2.2L Turbo - Hard Start/Rough Idle - Clean Injectors (01-63-84)
  • A413/A470 Trans No Manual 1ST Gear - MISADJUST Cable (21-03-84)
  • Hard Start/Gearshift Rattle - Complete Linkage Adj (21-10-84)
  • Torque Converter Grinding - Crankshaft ADAPTOR (09-01-84)
• Auxiliary Emission Control Systems
  • 2.6L Eng Vapor Lock - Electric Fuel Pump System (18-05-86)
  • 2.2L Turbo No/Hard Cold Start - New Logic Module (18-29-86)
  • 2.6L Cold Hesitation/Sag - DRIVEABILITY Package (18-32-86)
  • EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
  • Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
  • 2.6L Warm Sag/ACCEL Surge - New EGR Valve Kit (18-15-85)
  • 2.2L Carb Eng Oil In Air Filter Box - New PCV Valve (14-18-85)
  • EFI Fails Co Emissions In P/N - Replace Logic Module (25-01-85)
  • Off Idle Sag On LT/Med ACCEL - Install Purge Orifice (14-36-84)
  • Intermittent Power Loss - Insulate O2 Wire (08-16-84)
  • 2.6L Eng Hard Or No Start After Fuel Fill Up (14-27-84)
• Axle Shafts
  • Left Driveshaft Damper Weight Revised Torque Specs (02-05-84)
  • Driveshaft Key Service Parts Chart (02-08-84)
  • Front Hub/Bearing/Seal Revised Replacement (02-01-84)
• Body Interior
  • Replaceable Odometer Chip Elimination (08-15-86)
• Charging Systems
  • Charging System Diagnosis For All CHRYSLER Vehicles (08-03-86)
• Clutch
  • Clutch Growl At Medium/High Speed - Release Lever (06-02-89 REV. A)
  • Reverse Clash/Clutch Won't Release - Pressure Plate (06-01-86 REV. A)
  • A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
  • Clutch Hard/Slow/Cable Broken - Check Cable Routing (06-02-85)
• Cooling System (Mechanical)
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • EFI Throttle Body Components Service (14-24-85)
  • Exhaust Flex Joint Squeak/Leak - New Seal Ring (11-01-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • Exhaust Flex Joint Squeak/Leak - Seal Ring (11-01-84)
• Differentials & Drive Axles
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • Left Driveshaft Damper Weight Revised Torque Specs (02-05-84)
  • 2.2L Turbo - Hard Start/Rough Idle - Clean Injectors (01-63-84)
  • Driveshaft Key Service Parts Chart (02-08-84)
• Driveshaft & Universal Joints
  • Left Driveshaft Damper Weight Revised Torque Specs (02-05-84)
  • Driveshaft Key Service Parts Chart (02-08-84)
• Electronic Steering
  • Front SUSP. Noise Low Speed Turns - New Spring Seat (02-02-84)
• Electronic Suspension
  • Front SUSP. Noise Low Speed Turns - New Spring Seat (02-02-84)
• Engine Control Systems
  • 2.6L Eng Vapor Lock - Electric Fuel Pump System (18-05-86)
  • 2.2L Turbo No/Hard Cold Start - New Logic Module (18-29-86)
  • 2.6L Cold Hesitation/Sag - DRIVEABILITY Package (18-32-86)
  • EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
  • Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
  • EFI Fails Co Emissions In P/N - Replace Logic Module (25-01-85)
  • Intermittent Power Loss - Insulate O2 Wire (08-16-84)
  • 2.2L TBI OVERTORQUED Idle Adjustment Screw Repair (14-45-83)
• Exterior Body Panels
  • Sag On Hard Left Turn - Align Filter Or Replace Tank (14-49-84)
• Front Suspension
  • Front SUSP. Noise Low Speed Turns - New Spring Seat (02-02-84)
• Fuel System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • 2.6L Eng Vapor Lock - Electric Fuel Pump System (18-05-86)
  • 2.6L Cold Hesitation/Sag - DRIVEABILITY Package (18-32-86)
  • EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
  • 2.6L Poor Performance/Fuel Foaming - Repair Kit (18-06-86)
  • 2.2L EFI & Turbo Intermittent Erratic Idle Code 24 (18-22-85)
  • Sag On Hard Left Turn - Align Filter Or Replace Tank (14-49-84)
  • Hard Start/Rough Idle/Poor PERF - Injector Cleaner (14-63-84)
  • 740 Carb Part Throttle/Cold Sag - DRIVEABILITY Pkg (14-50-84)
  • Off Idle Sag On LT/Med ACCEL - Install Purge Orifice (14-36-84)
  • Hard Start Below 20 Degrees F - Revised Starting Procedure (14-17-84)
  • Part Throttle Sag/Cold Sag/Warm Surge - Repair Pkg (14-26-84)
  • 2.2L TBI OVERTORQUED Idle Adjustment Screw Repair (14-45-83)
  • Hard Cold Start/Stall - Vacuum Delay Valve Package (14-48-83)
• Fuses & Circuit Breakers
  • Electronic Instrument Cluster New Connectors/Wiring (08-20-84)
  • Intermittent Power Loss - Insulate O2 Wire (08-16-84)
  • 2.6L ELEC Dash/Radio/Voice Alert Erratic - Tie Strap (08-09-84)
• Gauges & Instrument Panels
  • Replaceable Odometer Chip Elimination (08-15-86)
  • Instrument Panel Squeak/Rattle Diagnosis (23-04-85)
  • 2.2L Eng Power Loss Lamp Comes On At Start Up (18-02-85)
  • Distance (Speed) Sensor Erratic - Diagnosis/R & R (08-07-84)
  • Fuel Gauge Wrong - Reroute Fuel Return Hose (14-22-84)
  • Seat Belt Warning System Revised Wiring Diagram (08-12-84)
  • Instrument Cluster/Odometer Memory Chip Service (08-01-84)
  • Voltmeter Readings High - Diagnosis (08-11-84)
• HVAC Control Systems
  • 2.2L Eng No Heat - 4-Port Water Valve Diagnosis (24-01-84)
• Ignition System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • 2.6L Federal Eng Sag/Poor Hot Soak Start - New Carb (18-42-86)
  • 2.6L Cold Hesitation/Sag - DRIVEABILITY Package (18-32-86)
  • 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
  • EFI Throttle Body Components Service (14-24-85)
  • 2.2L Eng Long Crank Time Rough Idle After Hot Soak (14-03-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
• Locking Hubs
  • Front SUSP. Noise Low Speed Turns - New Spring Seat (02-02-84)
• Lubrication System
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • New "SG" Quality Engine Oil (10-51-89)
  • EFI Throttle Body Components Service (14-24-85)
  • 2.2L Non Turbo Eng Standard Oil Filter Info (09-16-85)
  • Engine Oil Viscosity Recommendation From CHRYSLER (09-17-85)
  • Exhaust Flex Joint Squeak/Leak - New Seal Ring (11-01-85)
  • 2.2L Turbo - Hard Start/Rough Idle - Clean Injectors (01-63-84)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • Oil Pressure Revised Testing Procedure/Specs (09-05-84)
  • Exhaust Flex Joint Squeak/Leak - Seal Ring (11-01-84)
• Manual Trans
  • A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
  • Clash Shifting Into 5TH - New Oiler Tube/End Cover (21-11-84)
  • Hard Start/Gearshift Rattle - Complete Linkage Adj (21-10-84)
• Mechanical
  • New "SG" Quality Engine Oil (10-51-89)
  • Eng W/Jet Valve Miss/Fouled Plugs - REPL Jet Valve (18-17-88)
  • 2.2/2.5L Timing Belt Skips/No Cold Start - Sealing (09-07-86)
  • 2.6L Federal Eng Sag/Poor Hot Soak Start - New Carb (18-42-86)
  • 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
  • EFI Throttle Body Components Service (14-24-85)
  • Exhaust Flex Joint Squeak/Leak - New Seal Ring (11-01-85)
  • Camshaft Timing Chain Guide Rattle/Breakage - Repair (09-02-85 REV. A)
  • Fuel Pressure Regulator Click/Tap/Rattle - Damper (14-47-84)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • 2.6L Eng Start-Up Knock - Add Spacer To TENSIONER (09-09-84)
  • 2.2L Eng New Camshaft Package (09-06-84)
  • 2.6L Eng Oil Fouled Spark Plugs - New Valve Seal (14-29-84)
  • 2.2L Intermediate Shaft Revised R & R (09-04-84)
  • 2.2L Turbo New Oil Capacity & Dipstick Tube (09-03-84 REV. A)
  • Exhaust Flex Joint Squeak/Leak - Seal Ring (11-01-84)
  • Fuel Pressure Regulator Noise - Bracket Assembly (14-01-84)
• Mechanical - Hydraulic
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • 2.2L Turbo - Hard Start/Rough Idle - Clean Injectors (01-63-84)
• Paint & Coatings
  • Off Color Paint - Color Variance Chart Program (23-02-91)
• Passive Restraints
  • Front SUSP. Noise Low Speed Turns - New Spring Seat (02-02-84)
• Rear Suspension
  • Front SUSP. Noise Low Speed Turns - New Spring Seat (02-02-84)
• Restraints Control Systems
  • Replaceable Odometer Chip Elimination (08-15-86)
• Seats
  • New Rear Seat Shoulder Belt Packages/Installation (23-06-87)
  • Instrument Panel Squeak/Rattle Diagnosis (23-04-85)
• Starter
  • 2.6L Federal Eng Sag/Poor Hot Soak Start - New Carb (18-42-86)
  • Charging System Diagnosis For All CHRYSLER Vehicles (08-03-86)
  • EFI Throttle Body Components Service (14-24-85)
  • 2.2L Eng Long Crank Time Rough Idle After Hot Soak (14-03-85)
  • Fuel Pressure Regulator Click/Tap/Rattle - Damper (14-47-84)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • 2.6L Eng Start-Up Knock - Add Spacer To TENSIONER (09-09-84)
  • Fuel Pressure Regulator Noise - Bracket Assembly (14-01-84)
• Steering Column
  • Front SUSP. Noise Low Speed Turns - New Spring Seat (02-02-84)
• Steering Linkage
  • Front SUSP. Noise Low Speed Turns - New Spring Seat (02-02-84)
  • Front Hub/Bearing/Seal Revised Replacement (02-01-84)
• Sun Roof/T-Top/Convertible Top
  • Instrument Panel Squeak/Rattle Diagnosis (23-04-85)
• System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • 2.6L Eng Vapor Lock - Electric Fuel Pump System (18-05-86)
  • 2.2L Turbo No/Hard Cold Start - New Logic Module (18-29-86)
  • 2.6L Federal Eng Sag/Poor Hot Soak Start - New Carb (18-42-86)
  • 2.6L Cold Hesitation/Sag - DRIVEABILITY Package (18-32-86)
  • EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
  • 2.6L Poor Performance/Fuel Foaming - Repair Kit (18-06-86)
  • 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
  • Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
  • EFI Throttle Body Components Service (14-24-85)
  • Exhaust Flex Joint Squeak/Leak - New Seal Ring (11-01-85)
  • 2.2L EFI & Turbo Intermittent Erratic Idle Code 24 (18-22-85)
  • 2.6L Warm Sag/ACCEL Surge - New EGR Valve Kit (18-15-85)
  • 2.2L Carb Eng Oil In Air Filter Box - New PCV Valve (14-18-85)
  • EFI Fails Co Emissions In P/N - Replace Logic Module (25-01-85)
  • 2.2L Eng Long Crank Time Rough Idle After Hot Soak (14-03-85)
  • Sag On Hard Left Turn - Align Filter Or Replace Tank (14-49-84)
  • Hard Start/Rough Idle/Poor PERF - Injector Cleaner (14-63-84)
  • 740 Carb Part Throttle/Cold Sag - DRIVEABILITY Pkg (14-50-84)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • Off Idle Sag On LT/Med ACCEL - Install Purge Orifice (14-36-84)
  • Intermittent Power Loss - Insulate O2 Wire (08-16-84)
  • Hard Start Below 20 Degrees F - Revised Starting Procedure (14-17-84)
  • Part Throttle Sag/Cold Sag/Warm Surge - Repair Pkg (14-26-84)
  • Exhaust Flex Joint Squeak/Leak - Seal Ring (11-01-84)
  • 2.6L Eng Hard Or No Start After Fuel Fill Up (14-27-84)
  • 2.2L TBI OVERTORQUED Idle Adjustment Screw Repair (14-45-83)
  • Hard Cold Start/Stall - Vacuum Delay Valve Package (14-48-83)
• Vacuum Pumps/Lines/Tanks/Water Trap
  • 2.6L Eng Start-Up Knock - Add Spacer To TENSIONER (09-09-84)
• Wheel Hubs
  • Front Hub/Bearing/Seal Revised Replacement (02-01-84)
• Wheels & Tire System
  • Tire Thump/Vibration - Flat-Spotting Diagnosis (22-52-89)
  • Fwd & RWD Tire Rotation Patterns (22-01-86)
  • Front Wheel Bearing Free Play Ck/Adjust (02-03-84)
  • Front Hub/Bearing/Seal Revised Replacement (02-01-84)
• Window Motors & Regulators
  • Instrument Panel Squeak/Rattle Diagnosis (23-04-85)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Electronic Instrument Cluster New Connectors/Wiring (08-20-84)