Technical Service Bulletins

• A/C Compressor
  • A/C System Additives (24-003-03)
  • A/C System Leak Detection (24-009-02)
  • 3.3L/3.8L Eng: A/C Suction And/Or Discharge Line SVC (24-15-96)
• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Service Publication Updates - April, 2000 (26-04-00)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
  • Airbag On-Off Switches (08-37-99)
  • Airbag/Clock Spring Service (08-010-01)
  • Service Publication Updates - December, 2000 (26-012-00)
  • Non-Deployed Airbag Handling Procedures (08-27-00)
• Anti-Lock Brakes
  • Rear Wheel Park Brake Actuator/Lever Service (05-09-99)
• Anti-Theft Systems
  • Remote Keyless Entry (RKE) Programming Procedures (08-007-02)
  • Sliding Door Power Lock Actuator Chatter Sound (23-042-00)
• Automatic Trans
  • Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
  • Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
  • Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
  • Transmission Oil Cooler Line Hose Clamp Service (07-006-01)
  • Automatic Transmission Fluid Usage ATF+4 (Type 9602) (21-16-99)
  • 31TH - Delayed Engagement (21-07-00)
  • Torque Converter Break In INFOMATION/ATF +4 Update (21-18-99)
  • Reusable Automatic Transmission Oil Pan Gasket (21-05-99 REV. A)
• Auxiliary Emission Control Systems
  • Evaporative Systems Service (25-001-04)
  • Flash Programming Failure Recovery (18-32-98)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • EGR Monitor Diagnostic Test Difficult To Complete (18-03-00)
  • 3.0L - PCV Valve Freeze Up (18-02-00)
  • Misdiagnosed Leak Detection Pump System (18-01-00)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Flash Programming Failure Recovery (18-32-98)
• Communication Devices
  • Installation Of Radio Transmitting Equipment (08-31-94)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
  • Service Publication Updates - March, 2000 (26-03-00)
• Cruise Control Systems
  • Rear Wheel Park Brake Actuator/Lever Service (05-09-99)
  • Speed Control Does Not Maintain Speed Climbing Grade (08-27-99)
• Differentials & Drive Axles
  • Service Manual Revisions - January, 2000 (26-01-00)
• Engine Control Systems
  • Flash Programming Failure Recovery (18-32-98)
  • Generic Scan Tool (GST) (18-012-01)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • Service Publication Updates - December, 2000 (26-012-00)
  • Service Publication Updates - October, 2000 (26-010-00)
  • EGR Monitor Diagnostic Test Difficult To Complete (18-03-00)
  • Service Publication Updates - March, 2000 (26-03-00)
  • Service Manual Revisions - January, 2000 (26-01-00)
• Entertainment Systems
  • Intermittent Instrument Panel Speaker Operation/Stat (08-15-00)
  • Recordable Compact Disc Used In Automotive Cd Player (08-11-00)
  • Poor Am Radio Reception - Ground Strap Installation (08-45-99)
• Exhaust
  • Service Publication Updates - March, 2000 (26-03-00)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
  • Strut Tower Corrosion (23-044-02)
  • Roof Panel Wavy Or Has Depressions (23-28-96)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Service Publication Updates - December, 2000 (26-012-00)
  • Rear Wheel Park Brake Actuator/Lever Service (05-09-99)
• Frames, Subframes & Crossmembers
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Strut Tower Corrosion (23-044-02)
  • Roof Panel Wavy Or Has Depressions (23-28-96)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Strut Tower Corrosion (23-044-02)
  • Knock/Squawk Sound From Front Suspension (02-004-01)
  • Service Publication Updates - December, 2000 (26-012-00)
  • Service Publication Updates - May, 2000 (26-05-00)
  • Service Publication Updates - March, 2000 (26-03-00)
  • Knock/Clunk Sound From Front Strut Area (02-03-00)
• Fuel System
  • Service Publication Updates - December, 2000 (26-012-00)
  • Service Publication Updates - October, 2000 (26-010-00)
  • Service Publication Updates - March, 2000 (26-03-00)
  • Accelerator Pedal Vibrates At 2200-2500 Rpm & Above (14-03-99)
• Fuses & Circuit Breakers
  • Wire Splice Repairs (08-06-00)
• Gauges & Instrument Panels
  • Service Publication Updates - April, 2000 (26-04-00)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Service Publication Updates - December, 2000 (26-012-00)
• HVAC Control Systems
  • A/C System Additives (24-003-03)
  • A/C System Leak Detection (24-009-02)
  • Service Publication Updates - December, 2000 (26-012-00)
  • A/C Compressor Lock-Up At Low Mileage (24-15-99)
  • 3.3L/3.8L Eng: A/C Suction And/Or Discharge Line SVC (24-15-96)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Service Publication Updates - March, 2000 (26-03-00)
• Ignition Switch/Steering Lock
  • Ignition Key Will Not Turn &/Or Cannot Be Removed (23-23-00)
  • Ignition Switch Housing Service (19-06-99)
• Interior/Exterior Trim
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Service Publication Updates - April, 2000 (26-04-00)
  • Right Side Sliding Door Trim Rubs Quarter Panel (23-33-99)
• Interior/Illumination Lights
  • Service Publication Updates - May, 2000 (26-05-00)
• Manual Steering
  • Power Steering Fluid Usage (19-007-01)
  • Service Publication Updates - May, 2000 (26-05-00)
  • Service Publication Updates - March, 2000 (26-03-00)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Service Publication Updates - December, 2000 (26-012-00)
  • Service Publication Updates - April, 2000 (26-04-00)
  • Service Manual Revisions - January, 2000 (26-01-00)
• Mechanical - Hydraulic
  • Snow/Water Ingestion Into Rear Brake Drum (05-10-99)
  • Off Pedal Rear Brake Howl/Moan (05-003-01)
  • Service Publication Updates - December, 2000 (26-012-00)
  • Service Manual Revisions - January, 2000 (26-01-00)
  • Rear Wheel Park Brake Actuator/Lever Service (05-09-99)
• Mirrors
  • Outside Rearview Mirror Glass Replacement (23-34-00)
• Paint & Coatings
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
• Passive Restraints
  • Child Seat Tether Anchor Installation (23-35-99 REV.A)
• Rear Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Knock/Clunk Sound From Front Strut Area (02-03-00)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
  • Airbag On-Off Switches (08-37-99)
• Seats
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Child Seat Tether Anchor Installation (23-35-99 REV.A)
• Starter
  • Service Publication Updates - October, 2000 (26-010-00)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
  • Click Rattle Sound In Area Of Steering Wheel (19-09-99)
  • Ignition Switch Housing Service (19-06-99)
• Steering Column Switches
  • Rear Wheel Park Brake Actuator/Lever Service (05-09-99)
• Steering Linkage
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Service Publication Updates - May, 2000 (26-05-00)
• System
  • Flash Programming Failure Recovery (18-32-98)
  • Generic Scan Tool (GST) (18-012-01)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • Service Publication Updates - December, 2000 (26-012-00)
  • Service Publication Updates - October, 2000 (26-010-00)
  • EGR Monitor Diagnostic Test Difficult To Complete (18-03-00)
  • Service Publication Updates - March, 2000 (26-03-00)
  • 3.0L - PCV Valve Freeze Up (18-02-00)
  • Misdiagnosed Leak Detection Pump System (18-01-00)
  • Service Manual Revisions - January, 2000 (26-01-00)
  • Accelerator Pedal Vibrates At 2200-2500 Rpm & Above (14-03-99)
• Transfer Case
  • All Wheel Drive Power Transfer Unit Failure (21-05-00)
  • Service Publication Updates - April, 2000 (26-04-00)
• Transmission Control Systems
  • Flash Programming Failure Recovery (18-32-98)
  • No Response From TCM When Using Generic Scan Tools (18-10-00)
• Vacuum Pumps/Lines/Tanks/Water Trap
  • Rear Wheel Park Brake Actuator/Lever Service (05-09-99)
• Warning Systems
  • Rear Wheel Park Brake Actuator/Lever Service (05-09-99)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
  • Service Publication Updates - May, 2000 (26-05-00)
  • Service Publication Updates - March, 2000 (26-03-00)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
  • All Wheel Drive Power Transfer Unit Failure (21-05-00)
  • Spare Tire Winches - Do Not Swap Spare Tire Sizes (22-01-00)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)
• Wiring Diagrams
  • Service Publication Updates - December, 2000 (26-012-00)
  • Service Publication Updates - May, 2000 (26-05-00)
  • Service Publication Updates - April, 2000 (26-04-00)
  • Service Manual Revisions - February, 2000 (26-02-00)
  • Service Manual Revisions - January, 2000 (26-01-00)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Service Publication Updates - December, 2000 (26-012-00)
  • Service Publication Updates - May, 2000 (26-05-00)
  • Service Publication Updates - April, 2000 (26-04-00)
  • Wire Splice Repairs (08-06-00)
  • Service Manual Revisions - February, 2000 (26-02-00)
  • Service Manual Revisions - January, 2000 (26-01-00)
  • Rear Wheel Park Brake Actuator/Lever Service (05-09-99)