Technical Service Bulletins

• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Flash Power Liftgate May Not Open Or Close The First Time That The Power Liftgate Button Is Depressed (08-045-06)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • MOPAR Accessory Remote Starter Inoperative Due To Hood Switch (08-014-05)
  • Flash: Driver And Passenger Power Door Lock Switches Inoperative And Opening The Liftgate Triggers The Theft Alarm (08-040-04)
  • Erroneous Actuation Of Horns, Headlamps, And Parking Lamps While Vehicle Is Parked (08-005-04)
  • Flash - Panel Dimming Diagnostic Trouble Code (DTC), Intermittent Fluctuation Of Stop Lamp Signal Intensity, Or Front Lamps Flash With RKE Unlock Inoperative (08-035-03)
  • Sentry Key Identification Without Remote Keyless Entry (RKE). (08-032-03)
• Accessory Drive Belts
  • Accessory Drive Belt Squeaking/Chirping Sound (09-003-04 REV. A)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Anti-Theft Systems
  • Powertrain Control Module Initialization (08-030-06 REV.A)
  • Flash: Driver And Passenger Power Door Lock Switches Inoperative And Opening The Liftgate Triggers The Theft Alarm (08-040-04)
  • Sentry Key Identification Without Remote Keyless Entry (RKE). (08-032-03)
• Automatic Trans
  • Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
  • Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
  • Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
  • **COASTDOWN Ticking Sound Between 40 Mph And 0 Mph And/Or Transfer Gear Whine Sound Between 20 Mph And 65 Mph, Either Accelerating Or Decelerating** (21-005-04 REV. A)
  • Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
• Auxiliary Emission Control Systems
  • Engine Stall Immediately Following Fuel Tank Fill-Up (X60 Warranty Extension) (14-001-16 REV. A)
  • Evaporative Systems Service (25-001-04)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Flash: Driver And Passenger Power Door Lock Switches Inoperative And Opening The Liftgate Triggers The Theft Alarm (08-040-04)
  • Erroneous Actuation Of Horns, Headlamps, And Parking Lamps While Vehicle Is Parked (08-005-04)
  • Flash - Panel Dimming Diagnostic Trouble Code (DTC), Intermittent Fluctuation Of Stop Lamp Signal Intensity, Or Front Lamps Flash With RKE Unlock Inoperative (08-035-03)
  • Sentry Key Identification Without Remote Keyless Entry (RKE). (08-032-03)
• Brakes Control Systems
  • Anti-Lock Brake Rear Wheel Speed Sensor Replacement (05-004-04 REV. A)
• Communication Devices
  • Radio Communication Equipment Installation Recommendations (08-024-05)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
• Engine Control Systems
  • Engine Stall Immediately Following Fuel Tank Fill-Up (X60 Warranty Extension) (14-001-16 REV. A)
  • Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
  • Powertrain Control Module Initialization (08-030-06 REV.A)
  • Engine Spark Knock (18-026-06)
  • Flash: Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Powertrain Control Module Initialization (08-015-05)
  • Flash: Idle Fluctuation And Or Mil Illumination Diagnostic Trouble Codes P0300, P0301, P0302, P0303 Or P0304 (18-024-04)
  • Flash: Mil Illumination Diagnostic Trouble Codes (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306 (18-018-04)
  • Flash: Rough Idle When Engine Is At Normal Operating Temperature (18-016-04)
  • New Spark Plug For 2.4L Engine (08-034-03)
  • Trans Solenoid Replacement - Possible DTCS P0755, P07500, PO760, P0765, P0770, P2706 (21-001-04)
  • Flash - DRIVEABILITY Improvements (18-001-04)
• Entertainment Systems
  • Radio Intermittent Audio (08-014-04)
  • Radio Cd Err Message (08-028-03)
  • Compact Disc (Cd) Loading & Ejecting For 6 Disc Radio (Sales Code RBQ) (08-008-03)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
  • Excessive Effort In Opening Or Closing The Sliding Door Manually (23-007-10)
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
  • Passenger Compartment Floor Water Leak (23-010-04 REV. A)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Erroneous Actuation Of Horns, Headlamps, And Parking Lamps While Vehicle Is Parked (08-005-04)
• Frames, Subframes & Crossmembers
  • Repair Parts Used For Structural Repairs (31-002-11)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Creaking/Squawking Sound From Front Strut Area (02-004-05)
  • Rattle/Knocking Sound From The Front Suspension (02-003-05)
  • Muffled Rattle Sound From Front Suspension (02-004-03)
• Fuel System
  • Engine Stall Immediately Following Fuel Tank Fill-Up (X60 Warranty Extension) (14-001-16 REV. A)
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
  • Throttle Body Service (14-002-07)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Erroneous Actuation Of Horns, Headlamps, And Parking Lamps While Vehicle Is Parked (08-005-04)
• Horns
  • Erroneous Actuation Of Horns, Headlamps, And Parking Lamps While Vehicle Is Parked (08-005-04)
• HVAC Control Systems
  • HVAC Drain Water (Ac Condensate) Leaks Under Passenger Side Carpet (24-008-02 REV. A)
  • A/C Cooling Coil Odor (24-013-05)
  • Passenger Compartment Floor Water Leak (23-010-04 REV. A)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
• Ignition Switch/Steering Lock
  • Sentry Key Identification Without Remote Keyless Entry (RKE). (08-032-03)
• Ignition System
  • Flash: Idle Fluctuation And Or Mil Illumination Diagnostic Trouble Codes P0300, P0301, P0302, P0303 Or P0304 (18-024-04)
  • Flash: Mil Illumination Diagnostic Trouble Codes (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306 (18-018-04)
  • New Spark Plug For 2.4L Engine (08-034-03)
• Interior/Exterior Trim
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • HVAC Drain Water (Ac Condensate) Leaks Under Passenger Side Carpet (24-008-02 REV. A)
  • Upper Body Seam Seal Appearance Concern/Water Leak (23-002-05)
  • Passenger Compartment Floor Water Leak (23-010-04 REV. A)
• Interior/Illumination Lights
  • Flash - Panel Dimming Diagnostic Trouble Code (DTC), Intermittent Fluctuation Of Stop Lamp Signal Intensity, Or Front Lamps Flash With RKE Unlock Inoperative (08-035-03)
• Manual Steering
  • Revised Power Steering System Bleeding Procedures (19-008-05 REV. A)
  • Steering Shudder (19-010-01)
  • Power Steering Fluid Contamination (19-010-04)
  • Power Steering Fluid Usage (19-007-01)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Cylinder Head Bolt Re-Torque Procedure (09-001-05)
  • Irregular Engine Snapping Sound (09-007-04)
• Mechanical - Hydraulic
  • Snow/Water Ingestion Into Rear Brake Drum (05-10-99)
• Paint & Coatings
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
• Rear Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Seats
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
• Starter
  • MOPAR Accessory Remote Starter Inoperative Due To Hood Switch (08-014-05)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
  • Steering Shudder (19-010-01)
  • Pop/Tick/Creak Sound In Steering Column (19-005-04 REV. A)
• Steering Linkage
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Sun Roof/T-Top/Convertible Top
  • Upper Body Seam Seal Appearance Concern/Water Leak (23-002-05)
• System
  • Engine Stall Immediately Following Fuel Tank Fill-Up (X60 Warranty Extension) (14-001-16 REV. A)
  • Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
  • Flash: Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Flash: Driver And Passenger Power Door Lock Switches Inoperative And Opening The Liftgate Triggers The Theft Alarm (08-040-04)
  • Flash: Idle Fluctuation And Or Mil Illumination Diagnostic Trouble Codes P0300, P0301, P0302, P0303 Or P0304 (18-024-04)
  • Flash: Mil Illumination Diagnostic Trouble Codes (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306 (18-018-04)
  • Flash: Rough Idle When Engine Is At Normal Operating Temperature (18-016-04)
  • New Spark Plug For 2.4L Engine (08-034-03)
  • Trans Solenoid Replacement - Possible DTCS P0755, P07500, PO760, P0765, P0770, P2706 (21-001-04)
  • Flash - DRIVEABILITY Improvements (18-001-04)
• Transmission Control Systems
  • Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
  • Flash: Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Trans Solenoid Replacement - Possible DTCS P0755, P07500, PO760, P0765, P0770, P2706 (21-001-04)
• Warning Systems
  • Erroneous Actuation Of Horns, Headlamps, And Parking Lamps While Vehicle Is Parked (08-005-04)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
  • Chrome Wheel Care (22-01-99)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)