Technical Service Bulletins

• A/C Compressor
  • Fluid Flushing Requirements (26-003-07)
  • A/C Induced Knock Sound In Engine Compartment (24-004-07)
• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Anti-Lock Brakes
  • Flash: Esp / Traction Control Sensitivity On Tight Curves (05-004-07)
• Anti-Theft Systems
  • No Engine Crank Or No Engine Start Due To Electronic Lockup Of The WCM / SKREEM (08-007-08 REV. A)
  • MOPAR Remote Start System - RKE - Intermittent Operation Or Alarm May Sound (08-018-07)
  • Remote Start System - Diagnostic Chart For Antenna (08-003-07)
  • Powertrain Control Module Initialization (08-030-06 REV.A)
• Automatic Trans
  • Fluid Flushing Requirements (26-004-12)
  • Fluid Flushing Requirements (26-003-07)
  • Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
  • Flash: Torque Converter Shudder With Coordinated Change Or Shift Quality Improvements (21-003-08)
  • Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
  • Flash: 62TE Transmission Harsh Engagement Or Clunk When Shifting Out Of Reverse Or From Drive, Through Reverse Into Park / **DTC P0732** (21-008-07 REV. A)
  • 6 Speed Automatic (62TE/AE) Transmission Fluid Check Cautions (21-010-07)
  • Flash Transmission Default To 2ND/3RD Gear Without Mil Or DTC'S (21-007-07)
  • Flash Torque Converter Shudder / Bump (21-004-07)
• Auxiliary Emission Control Systems
  • Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
• Brakes Control Systems
  • STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
• Clutch
  • Clutch Pedal Squeak (06-006-07)
  • Clutch Pedal Squeak (06-005-07)
  • Clutch Pedal Push Back (06-002-06)
• Collision/Avoidance
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Communication Devices
  • Flash: REW Or REX Radio Software Enhancements (08-026-12)
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
  • U-Connect And Voice Recognition Operation (08-048-06)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
• Cruise Control Systems
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
  • Flash DRIVEABILITY Improvements (18-021-07)
  • Flash: NVH Improvements, DTC'S B10B3 And/Or B10B7, Cruise Control Enhancements (18-014-07)
• Engine Control Systems
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
  • Flash: Engine Over Rev Condition (18-019-10)
  • Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
  • Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
  • Flash DRIVEABILITY Improvements (18-021-07)
  • Flash: NVH Improvements, DTC'S B10B3 And/Or B10B7, Cruise Control Enhancements (18-014-07)
  • Generic Pcm (GPEC) Or TCM (CVT Controller) Replacement Requirements (18-006-07 REV. A)
  • Flash Mil Illumination/Generator Lamp Illumination/Oil Pressure Lamp Illumination/DRIVEABILITY Improvements (18-033-06)
  • Powertrain Control Module Initialization (08-030-06 REV.A)
  • STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
• Entertainment Systems
  • Flash: REW Or REX Radio Software Enhancements (08-026-12)
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
  • Radio Locks Up (08-014-10)
  • Radio Video Disable Update (08-004-10)
  • MYGIG Radio Hard Drive Recovery/Update Disc (08-024-08 REV. A)
  • Flash: Radio - Temperature Display In Cluster Revert To U.S. Units Intermittently (08-032-07)
  • Distorted Sound In Door Speaker, Rear Quarter Speaker Or Rear Shelf Speaker With The Radio On (08-024-07 REV. A)
  • Flash: VES (Over Head Video Screen) Is Not Powering On (08-027-07)
  • Flash: Audio System Mute After Vehicle Is Started (08-005-07)
  • Flash Intermittent Radio Cut Out While Driving (08-053-06)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
  • Lower Door Hinges Make Popping Or Groan When Opened Or Closed (23-018-10)
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Exterior Lamp - Lens Fogging (23-041-06)
• Frames, Subframes & Crossmembers
  • Repair Parts Used For Structural Repairs (31-002-11)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
• Fuel System
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
  • Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
• Gauges & Instrument Panels
  • Flash: Radio - Temperature Display In Cluster Revert To U.S. Units Intermittently (08-032-07)
  • Flash WCM - Clock May Gain Time Periodically (08-013-07)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Exterior Lamp - Lens Fogging (23-041-06)
• HVAC Control Systems
  • Water In HVAC Housing Or Wet Carpet Under HVAC Housing (24-003-10)
  • Only Warm Cabin Air Output From HVAC System (24-003-07)
  • Flash HVAC Whistle Sound (24-008-06)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
• Ignition Switch/Steering Lock
  • No Engine Crank Or No Engine Start Due To Electronic Lockup Of The WCM / SKREEM (08-007-08 REV. A)
• Infotainment
  • Radio Video Disable Update (08-004-10)
• Interior/Exterior Trim
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Water In HVAC Housing Or Wet Carpet Under HVAC Housing (24-003-10)
  • Low Gloss Interior Trim (23-036-07)
  • Scratch Marks On PRNDL Bezel (23-049-06)
  • Yes Essentials(R) Stain, Odor, & Static Resistant Fabric Care (23-021-06 REV.A)
• Lubrication System
  • Fluid Flushing Requirements (26-004-12)
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Fluid Flushing Requirements (26-003-07)
• Manual Steering
  • Fluid Flushing Requirements (26-004-12)
  • Power Steering Honk, Moan Or Grinding Sound On Left Turns (19-001-09)
• Mechanical
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Fluid Flushing Requirements (26-003-07)
  • Flash: Powertrain Growl Sound, Coordinated Change (18-045-07)
• Mechanical - Hydraulic
  • Fluid Flushing Requirements (26-004-12)
  • Fluid Flushing Requirements (26-003-07)
  • Pre Delivery - Front Brake Rotor Corrosion Inspection & Procedure (05-002-09 REV. B)
  • Pre Delivery Brake Inspection Procedure (05-002-08 REV. A)
• Paint & Coatings
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Paint Repair - Etching (23-046-07)
  • Transit Film Removal (23-043-04)
• Parking Brake System
  • Add Parking Brake Adjustment To The 30 Month, 30 K Miles Or 50 KKM Service Interval (26-002-08)
• Rear Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Rear Suspension Rattle Sound (02-002-07)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
  • STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
• Schedule
  • Fluid Flushing Requirements (26-004-12)
• Seats
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Seat Track Creak/Squeak Sound (23-008-08)
  • Yes Essentials(R) Stain, Odor, & Static Resistant Fabric Care (23-021-06 REV.A)
• Starter
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
  • MOPAR Remote Start System - RKE - Intermittent Operation Or Alarm May Sound (08-018-07)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
  • Squeak Sound While Turning Steering Wheel (19-001-07 REV. A)
  • Steering Wheel Click Sound When Turning (19-002-07)
• Steering Control Systems
  • Flash DTC'S C121A / C2205 - Steering Angle Sensor - Not Initialized / Internal (08-010-07)
  • STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
• Steering Gear
  • Squeak Sound While Turning Steering Wheel (19-001-07 REV. A)
• Steering Linkage
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Sun Roof/T-Top/Convertible Top
  • Sunroof Water Leak Into Passenger Compartment (23-005-08)
• Suspension Control Systems
  • Tire Pressure Monitoring System (TPM) Displays Dashes "-" When The Spare Tire Is Used (22-001-06 REV. B)
  • STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
• System
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
  • Flash: Engine Over Rev Condition (18-019-10)
  • Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
  • Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
  • Flash: Mil Illumination With DTC P0139 Or P2270 (18-043-07)
  • Mil Illumination With Evaporative System DTC'S P0440 Or P0457 (25-002-07 REV. A)
  • Flash Mil Illumination With DTC'S P0016, P0017, P000A, Or P000B (18-018-07 REV. A)
  • Flash Mil Illumination With DTC P2004 (18-032-07)
  • Flash Mil Illumination DTC P1004 - Short Runner Valve Performance (18-003-07 REV. A)
  • Flash Mil Illumination With DTC'S P0128 Or P2181 (18-017-07)
• Transmission Control Systems
  • Flash: DECEL Hunting/Bump/Oscillation Feeling And Automatic Transmission Shift Improvements (21-003-09)
  • Flash: 6 Speed Automatic Transmission Shift Improvements (21-001-09)
  • Flash: Transmission Engagement / Performance Improvements (21-015-08 REV. B)
  • Flash: Incorrect Reporting Of DTC P0730 For DTC P0717 (21-014-08)
  • Flash Transmission Default To 2ND/3RD Gear Without Mil Or DTC'S (21-007-07)
  • Generic Pcm (GPEC) Or TCM (CVT Controller) Replacement Requirements (18-006-07 REV. A)
  • Flash Mil Illumination/Generator Lamp Illumination/Oil Pressure Lamp Illumination/DRIVEABILITY Improvements (18-033-06)
  • STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
  • Tire Pressure Monitor - System Information (22-004-06)
  • Tire Pressure Monitoring System (TPM) Displays Dashes "-" When The Spare Tire Is Used (22-001-06 REV. B)
• Window Motors & Regulators
  • Rear Glass Comes Out Of Track (23-042-07)
  • Front Door Glass Rattle Or Flutter Sound (23-040-07)
  • Cracked Windshield (23-047-06)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)