Technical Service Bulletins

• A/C Compressor
  • Fluid Flushing Requirements (26-003-07)
• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Drivers And/Or Passenger Front Power Door Locks And Windows Inoperative U0200 Lost Communication With Passengers Door Module U0199 Lost Communication With Drivers Door Module (08-061-12)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Anti-Lock Brakes
  • Flash: Esp Lamp Flashing While System Is In Full Off Mode Or Esp Pump Howl, Groan Sound After A Turn (05-005-08)
• Anti-Theft Systems
  • Drivers And/Or Passenger Front Power Door Locks And Windows Inoperative U0200 Lost Communication With Passengers Door Module U0199 Lost Communication With Drivers Door Module (08-061-12)
• Automatic Trans
  • Fluid Flushing Requirements (26-004-12)
  • Torque CONVERTOR Shudder On Vehicles With Less Then 4000 Miles (21-022-08)
  • Fluid Flushing Requirements (26-003-07)
  • Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
• Axle Shafts
  • Rear Axle Gear Whine (03-001-12)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
• Collision/Avoidance
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Communication Devices
  • Flash: REW Or REX Radio Software Enhancements (08-026-12)
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
  • Mil Illumination For P0128 - Thermostat Rationality (18-031-11)
• Cruise Control Systems
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Differentials & Drive Axles
  • Rear Axle Gear Whine (03-001-12)
• Engine Control Systems
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
  • Mil Illumination For P0128 - Thermostat Rationality (18-031-11)
  • Mil Illumination Diagnostic Trouble Code P0339 - Crankshaft Position Sensor Intermittent Set (18-040-08)
  • Flash: Rough Idle On Start Up With Ambient Temperatures Below 50° (10°C) (18-023-10)
  • Flash: Engine Runs Rough At Low Rpm Or Mil Illumination For MDS Reactivation And Misfire DTC'S (18-014-10)
  • Flash: Mil Illumination And/Or MDS DRIVEABILITY Improvements And/Or Shift Improvements (18-021-09 REV. A)
  • Flash: Whistle Sound From Engine Compartment/Purge Solenoid (18-036-08 REV. A)
• Entertainment Systems
  • Flash: REW Or REX Radio Software Enhancements (08-026-12)
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
  • Radio Locks Up (08-014-10)
  • Radio Video Disable Update (08-004-10)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
  • Lower Door Hinges Make Popping Or Groan When Opened Or Closed (23-018-10)
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
• Frames, Subframes & Crossmembers
  • Rear Cradle Clunk Noise (13-001-16)
  • Repair Parts Used For Structural Repairs (31-002-11)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
• Fuel System
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
• Gauges & Instrument Panels
  • Electronic Vehicle Information Center (EVIC) Oil Change Indicator System - Dealer Preferences During Prep (08-014-07)
  • Flash: Trip B Functionality Does Not Reset Using The Odometer Knob (08-031-08)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
• Infotainment
  • Radio Video Disable Update (08-004-10)
• Interior/Exterior Trim
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Loose Heritage Badge On Seat Back (23-002-10)
• Lubrication System
  • Fluid Flushing Requirements (26-004-12)
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Fluid Flushing Requirements (26-003-07)
• Manual Steering
  • Fluid Flushing Requirements (26-004-12)
• Mechanical
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Fluid Flushing Requirements (26-003-07)
• Mechanical - Hydraulic
  • Fluid Flushing Requirements (26-004-12)
  • Fluid Flushing Requirements (26-003-07)
  • Pre Delivery - Front Brake Rotor Corrosion Inspection & Procedure (05-002-09 REV. B)
  • Pre Delivery Brake Inspection Procedure (05-002-08 REV. A)
• Paint & Coatings
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Light To Moderate Paint Surface Imperfections On Factory Applied Paint Finish (23-003-12)
• Rear Suspension
  • Rear Cradle Clunk Noise (13-001-16)
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Rear Axle Gear Whine (03-001-12)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Schedule
  • Fluid Flushing Requirements (26-004-12)
• Seats
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Loose Heritage Badge On Seat Back (23-002-10)
• Starter
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
• Steering Linkage
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• System
  • Drivers And/Or Passenger Front Power Door Locks And Windows Inoperative U0200 Lost Communication With Passengers Door Module U0199 Lost Communication With Drivers Door Module (08-061-12)
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
  • Mil Illumination For P0128 - Thermostat Rationality (18-031-11)
  • Mil Illumination Diagnostic Trouble Code P0339 - Crankshaft Position Sensor Intermittent Set (18-040-08)
  • Flash: Rough Idle On Start Up With Ambient Temperatures Below 50° (10°C) (18-023-10)
  • Flash: Engine Runs Rough At Low Rpm Or Mil Illumination For MDS Reactivation And Misfire DTC'S (18-014-10)
  • Flash: Mil Illumination And/Or MDS DRIVEABILITY Improvements And/Or Shift Improvements (18-021-09 REV. A)
  • Flash: Whistle Sound From Engine Compartment/Purge Solenoid (18-036-08 REV. A)
• Transmission Control Systems
  • Flash: Performance DERATE Above 55 Mph Immediately After Start-Up When Accelerating At Wide Open Throttle (18-021-13)
  • Flash: Mil Illumination And/Or MDS DRIVEABILITY Improvements And/Or Shift Improvements (18-021-09 REV. A)
  • Flash: Harsh 4-3 Shift And Shift Quality Improvements (21-005-09)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
• Window Motors & Regulators
  • Drivers And/Or Passenger Front Power Door Locks And Windows Inoperative U0200 Lost Communication With Passengers Door Module U0199 Lost Communication With Drivers Door Module (08-061-12)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)