Maintenance Schedules - China
Your vehicle is equipped with an automatic oil change indicator system. The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance. Based on engine operation conditions, the oil change indicator message will illuminate. This means that service is required for your vehicle. Operating conditions such as frequent short-trips, trailer tow, extremely hot or cold ambient temperatures will influence when the "Oil Change Required" message is displayed. Severe Operating Conditions can cause the change oil message to illuminate as early as 3, 500 miles (5, 600 km) since last reset. Have your vehicle serviced as soon as possible, within the next 500 miles (805 km).
Under no circumstances should oil change intervals exceed 10, 000 miles (16, 000 km), twelve months or 350 hours of engine run time, whichever comes first. The 350 hours of engine run or idle time is generally only a concern for fleet customers.
Oil Change Indicator - RESET
- Unless reset, this message will continue to display each time you place the ignition in the ON/RUN position. To turn off the message temporarily, push and release the OK or arrow buttons. To reset the oil change indicator system (after performing the scheduled maintenance), refer to the following procedure:
- Without pushing the brake pedal, push the ENGINE START/STOP button and place the ignition to the ON/RUN position (do not start the engine).
- Fully push the accelerator pedal, slowly, three times within 10 seconds.
- Without pushing the brake pedal, push the ENGINE START/STOP button once to return the ignition to the OFF/LOCK position.NOTE:
If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary, repeat this procedure.
Heavy Duty Use Of The Vehicle
- Change Engine Oil at 4, 000 miles (6, 500 km) if the vehicle is operated in a dusty and off road environment or is operated predominately at idle or only very low engine RPM's. This type of vehicle use is considered Severe Duty.
Once a Month Or Before a Long Trip
- Check engine oil level
- Check windshield washer fluid level
- Check tire inflation pressures and look for unusual wear or damage.
- Check the fluid levels of the coolant reservoir, brake master cylinder and fill as needed.
- Check function of all interior and exterior lights.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
- Change the engine oil filter.
- Rotate the tires. Rotate at the first sign of irregular wear, even if it occurs before the oil indicator system turns on.
- Inspect battery and clean and tighten terminals as required.
- Inspect brake pads, shoes, rotors, drums, hoses and park brake.
- Inspect engine cooling system protection and hoses.
- Inspect exhaust system.
- Inspect engine air cleaner if using in dusty or off-road conditions.
| Mileage: | 7, 500 | 15, 000 | 22, 500 | 30, 000 | 37, 500 | 45, 000 | 52, 500 | 60, 000 | 67, 500 | 75, 000 | 82, 500 | 90, 000 | 97, 500 | 105, 000 | 112, 5000 | 120, 000 | 127, 5000 | 135, 000 | 142, 500 | 150, 000 | ||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| Or Months: | 6 | 12 | 18 | 24 | 30 | 36 | 42 | 48 | 54 | 60 | 66 | 72 | 78 | 84 | 90 | 96 | 102 | 108 | 114 | 120 | ||||
| Or Kilometers: | 12, 000 | 24, 000 | 36, 000 | 48, 000 | 60, 000 | 72, 000 | 84, 000 | 96, 000 | 108, 000 | 120, 000 | 132, 000 | 144, 000 | 156, 000 | 168, 000 | 180, 000 | 192, 000 | 204, 000 | 216, 000 | 228, 000 | 240, 000 | ||||
| Change engine oil and oil filter. | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | ||||
| Rotate tires | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | X | ||||
| Inspect the CV joints. | X | X | X | X | X | X | X | X | X | X | ||||||||||||||
| Inspect front suspension, boot seals, tie rod ends, and replace if necessary. | X | X | X | X | X | X | X | X | X | X | ||||||||||||||
| Inspect the brake linings, parking brake function. | X | X | X | X | X | X | X | X | X | X | ||||||||||||||
| Inspect front accessory drive belt, tensioner, idler pulley, and replace if necessary | X | |||||||||||||||||||||||
| Change brake fluid every 24 months if using DOT 4 brake fluid.(1) | X | X | X | X | X | |||||||||||||||||||
| Replace engine air cleaner filter. | X | X | X | X | X | |||||||||||||||||||
| Replace air conditioning/cabin air filter. | X | X | X | X | X | X | X | X | X | X | ||||||||||||||
| Replace spark plugs.(2) | X | X | ||||||||||||||||||||||
| Flush and replace the engine coolant at 10 years or 150, 000 miles (240, 000 km) whichever comes first. | X | |||||||||||||||||||||||
| Inspect and replace PCV valve if necessary. | X | |||||||||||||||||||||||
|
||||||||||||||||||||||||