Technical Service Bulletins

• A/C Compressor
  • R-12 To R-134A A/C Adaptation Service Procedure (24-01-95 REV. A)
  • A/C End Cover/Valve Plate Leak - Revised Rebuild Kit (24-01-89)
  • A/C Clutch Failure - Diagnosis/Repair (24-02-86)
  • A/C Clutch Replacement - Blower Motor Resistor Check (24-01-85)
  • A/C Clutch Slip/Blower Operates All Speeds But Low (24-02-85)
• Accessories Control Systems
  • Trailer Tow Wiring Installation Instructions (08-05-91)
• Automatic Trans
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • A/T Failure - ATF Cooler Flushing Procedure (21-10-89)
  • AURO Trans High Pullout Effort From Park (21-14-87)
  • Increased Shifting Effort - Reroute Speedo Cable (21-14-86)
  • A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
  • Quick Adjust Throttle Pressure Cable (21-18-85)
  • Torque Converter Shudder - ATF Type (21-04-85)
  • A/T Gear Shift Indicator Misaligned - Readjustment (19-02-85)
  • Torque Converter Replacement Trans Repair Caution (21-11-85)
• Auxiliary Emission Control Systems
  • Trailer Tow Wiring Installation Instructions (08-05-91)
  • Fails Emission Test For High Co - Emissions Kit (25-04-88)
  • 2.2L Eng A413 Trans Backfire On DECEL (18-04-87)
  • 2.6L Eng No Power Highway Speeds - Carburetor Icing (18-05-87)
  • Rough Cold Idle/DRIVEAWAY Die Out - Map Sensor Kit (18-03-86 REV. A)
  • 2.6L Low Power At High Speed In Cold - Aspirator Kit (18-46-86)
  • 2.6L Eng Poor PERF/Smoke/Fuel Foaming After Hot Soak (18-41-86)
  • 2.2L Carb A/T Off Idle Hesitate - ACCEL Pump Nozzle (18-30-86)
  • 2.6L Eng - Surging/Rough Idle -EGR Bleed Delay Valve (18-23-86)
  • EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
  • Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
  • Long Cold Crank Time - Thermal Carb Bowl Vent Valve (18-31-85)
  • High Altitude Conversion/Adjustments (25-04-85)
  • 2.6L Fed Fails I/M Co Emissions - High Altitude Kit (25-07-85)
  • Oil In Air Filter Box - New High Flow PCV Valve (14-11-85)
  • 2.2L Fed Carb Eng Cold Start Stall - New Kit (18-11-85)
  • Revised Emission Control Maintenance Schedule (26-03-84)
• Body Interior
  • Trailer Tow Wiring Installation Instructions (08-05-91)
  • A/C Clutch Slip/Blower Operates All Speeds But Low (24-02-85)
• Charging Systems
  • Charging System Diagnosis For All CHRYSLER Vehicles (08-03-86)
  • Fm Radio Noise - Replace Regulator (08-09-85)
• Clutch
  • Clutch Growl At Medium/High Speed - Release Lever (06-02-89 REV. A)
  • Reverse Clash/Clutch Won't Release - Pressure Plate (06-01-86 REV. A)
  • A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
• Cooling System (Mechanical)
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • 1.5/1.6/2.0/2.2/2.3/2.6L Eng Overheat - REPL Reserve (07-01-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
• Differentials & Drive Axles
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
• Engine Control Systems
  • Trailer Tow Wiring Installation Instructions (08-05-91)
  • Rough Cold Idle/DRIVEAWAY Die Out - Map Sensor Kit (18-03-86 REV. A)
  • 2.2L Carb A/T Off Idle Hesitate - ACCEL Pump Nozzle (18-30-86)
  • EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
  • Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
• Entertainment Systems
  • Fm Radio Noise - Replace Regulator (08-09-85)
• Exhaust
  • 2.6L Exhaust Flex Joint Squeak - Cone Washers (11-02-85)
• Exterior Body Panels
  • Liftgate Prop Rods Attachment Points Cracks Repair (23-23-93)
  • Fuel Tank Gurgle - Install T-Shaped Check Valve (14-02-85)
• Exterior Lights
  • Trailer Tow Wiring Installation Instructions (08-05-91)
• Front Suspension
  • Front Shock Towers Sheet Metal Screws Installation (02-08-92)
  • Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
• Fuel System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • Rough Cold Idle/DRIVEAWAY Die Out - Map Sensor Kit (18-03-86 REV. A)
  • Sag On Long Left Turns - Fuel Filter SYS Rework Kit (18-37-86)
  • EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
  • 2.6L Eng Unleaded Fuel USEAGE In Overseas Operations (14-07-85)
  • 2.2L Carb Vapor Lock Kit - New Diode Wiring Jumper (18-13-85 REV. A)
  • 2.6L Vapor Lock Kit - New Diode Wiring Jumper (18-18-85 REV. A)
  • Long Cold Crank Time - Thermal Carb Bowl Vent Valve (18-31-85)
  • High Altitude Conversion/Adjustments (25-04-85)
  • 2.6L Fed Fails I/M Co Emissions - High Altitude Kit (25-07-85)
  • 2.6L Poor Power When Cold - Thermal Check Valve Kit (18-14-85)
  • 2.6L Low Power In Cold - New Air Cleaner Temp Sensor (14-17-85)
  • Poor Performance - Clean Fuel System Rust/Corrosion (14-04-85)
  • Propane Or Co Idle Mixture Adjustment Applications (14-46-84)
• Fuses & Circuit Breakers
  • Trailer Tow Wiring Installation Instructions (08-05-91)
• Gauges & Instrument Panels
  • Dash Panel Crack Repair Procedure (23-01-93)
  • A/T Gear Shift Indicator Misaligned - Readjustment (19-02-85)
• Headlights
  • Trailer Tow Wiring Installation Instructions (08-05-91)
• HVAC Control Systems
  • R-12 To R-134A A/C Adaptation Service Procedure (24-01-95 REV. A)
  • A/C Heater Blend Air Door Sticking (24-11-94)
  • A/C Condenser Support Package (24-01-86)
  • A/C Clutch Slip/Blower Operates All Speeds But Low (24-02-85)
• Identification
  • Non-Tilt Steering Column Usage/Identification (19-04-85)
• Ignition System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • 2.6L Fails Emission Test For High Co - Emissions Kit (25-01-88)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • 2.6L High Alt Fuel Foaming/Black Exhaust - New Carb (18-54-86)
  • 2.6L Fuel Foaming -Pressure Regulator/Fuel Reservoir (18-48-86)
  • 2.6L Federal Cold Sag On ACCEL - Vacuum Advance Kit (18-20-86)
  • 2.2L 2V Rich Loading/Carburetor Icing - Delay Valve (18-10-86)
  • 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
  • 2.6L Cold Engine Sag During Medium To Heavy ACCEL (18-12-85)
  • 2.6L Eng Lacks Power After Extended Run Cold Weather (18-48-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • 2.6L Eng - Fuel Flow Restriction - New Fuel Hose (14-54-84)
• Interior/Illumination Lights
  • Trailer Tow Wiring Installation Instructions (08-05-91)
• Lubrication System
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • New "SG" Quality Engine Oil (10-51-89)
  • 2.6L High Alt Fuel Foaming/Black Exhaust - New Carb (18-54-86)
  • Engine Oil Viscosity Recommendation From CHRYSLER (09-17-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
• Manual Steering
  • Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
• Manual Trans
  • Clutch Splines/Pilot Bushing Lubricant Info (06-01-89)
  • Hard Shifting Into/Out Of 5TH - Strut Retainer Plate (21-07-86 REV. A)
  • Shift Linkage Ball Socket Disengagement - Retainers (21-05-86)
  • A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
• Mechanical
  • New "SG" Quality Engine Oil (10-51-89)
  • Eng W/Jet Valve Miss/Fouled Plugs - REPL Jet Valve (18-17-88)
  • 2.6L Fails Emission Test For High Co - Emissions Kit (25-01-88)
  • 2.2/2.5L Timing Belt Skips/No Cold Start - Sealing (09-07-86)
  • 2.6L High Alt Fuel Foaming/Black Exhaust - New Carb (18-54-86)
  • 2.6L Fuel Foaming -Pressure Regulator/Fuel Reservoir (18-48-86)
  • 2.6L Federal Cold Sag On ACCEL - Vacuum Advance Kit (18-20-86)
  • 2.2L 2V Rich Loading/Carburetor Icing - Delay Valve (18-10-86)
  • 2.6L Cylinder Head & Block Resurfacing Limits (09-08-86)
  • 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
  • 2.2L Eng New Cylinder Head Bolts (09-13-85)
  • 2.6L Exhaust Flex Joint Squeak - Cone Washers (11-02-85)
  • 2.2L Eng New Connecting Rod (09-12-85)
  • 2.6L Eng Lacks Power After Extended Run Cold Weather (18-48-85)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • 2.6L Eng - Fuel Flow Restriction - New Fuel Hose (14-54-84)
• Mechanical - Hydraulic
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
• Paint & Coatings
  • Off Color Paint - Color Variance Chart Program (23-02-91)
• Rear Suspension
  • Front Shock Towers Sheet Metal Screws Installation (02-08-92)
  • Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
• Restraints Control Systems
  • Trailer Tow Wiring Installation Instructions (08-05-91)
• Schedule
  • Revised Emission Control Maintenance Schedule (26-03-84)
• Seats
  • Middle Outboard Seat Belt Modification (23-14-91)
• Starter
  • 2.6L High Alt Fuel Foaming/Black Exhaust - New Carb (18-54-86)
  • 2.6L Fuel Foaming -Pressure Regulator/Fuel Reservoir (18-48-86)
  • Charging System Diagnosis For All CHRYSLER Vehicles (08-03-86)
  • 2.2L 2V Rich Loading/Carburetor Icing - Delay Valve (18-10-86)
  • Dual Ball Battery State Of Charge Indicator (08-31-84)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • 2.6L Eng - Fuel Flow Restriction - New Fuel Hose (14-54-84)
• Steering Column
  • Non-Tilt Steering Column Usage/Identification (19-04-85)
• Steering Gear
  • Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
• Steering Linkage
  • Rear Wheel Toe-In Specifications Revision (02-03-85)
  • Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
  • Front Suspension Alignment Revised Toe-In Specs (02-11-84)
• System
  • Trailer Tow Wiring Installation Instructions (08-05-91)
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • Fails Emission Test For High Co - Emissions Kit (25-04-88)
  • 2.6L Fails Emission Test For High Co - Emissions Kit (25-01-88)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • 2.2L Eng A413 Trans Backfire On DECEL (18-04-87)
  • 2.6L Eng No Power Highway Speeds - Carburetor Icing (18-05-87)
  • Rough Cold Idle/DRIVEAWAY Die Out - Map Sensor Kit (18-03-86 REV. A)
  • Sag On Long Left Turns - Fuel Filter SYS Rework Kit (18-37-86)
  • 2.6L High Alt Fuel Foaming/Black Exhaust - New Carb (18-54-86)
  • 2.6L Low Power At High Speed In Cold - Aspirator Kit (18-46-86)
  • 2.6L Fuel Foaming -Pressure Regulator/Fuel Reservoir (18-48-86)
  • 2.6L Eng Poor PERF/Smoke/Fuel Foaming After Hot Soak (18-41-86)
  • 2.2L Carb A/T Off Idle Hesitate - ACCEL Pump Nozzle (18-30-86)
  • 2.6L Federal Cold Sag On ACCEL - Vacuum Advance Kit (18-20-86)
  • 2.6L Eng - Surging/Rough Idle -EGR Bleed Delay Valve (18-23-86)
  • 2.2L 2V Rich Loading/Carburetor Icing - Delay Valve (18-10-86)
  • EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
  • 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
  • Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
  • 2.2L Carb Vapor Lock Kit - New Diode Wiring Jumper (18-13-85 REV. A)
  • 2.6L Vapor Lock Kit - New Diode Wiring Jumper (18-18-85 REV. A)
  • Long Cold Crank Time - Thermal Carb Bowl Vent Valve (18-31-85)
  • High Altitude Conversion/Adjustments (25-04-85)
  • 2.6L Fed Fails I/M Co Emissions - High Altitude Kit (25-07-85)
  • 2.6L Poor Power When Cold - Thermal Check Valve Kit (18-14-85)
  • 2.6L Cold Engine Sag During Medium To Heavy ACCEL (18-12-85)
  • 2.6L Eng Lacks Power After Extended Run Cold Weather (18-48-85)
  • Oil In Air Filter Box - New High Flow PCV Valve (14-11-85)
  • 2.6L Low Power In Cold - New Air Cleaner Temp Sensor (14-17-85)
  • 2.2L Fed Carb Eng Cold Start Stall - New Kit (18-11-85)
  • Poor Performance - Clean Fuel System Rust/Corrosion (14-04-85)
  • Revised Emission Control Maintenance Schedule (26-03-84)
  • Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
  • 2.6L Eng - Fuel Flow Restriction - New Fuel Hose (14-54-84)
  • Propane Or Co Idle Mixture Adjustment Applications (14-46-84)
• Wheels & Tire System
  • Tire Thump/Vibration - Flat-Spotting Diagnosis (22-52-89)
  • Wheel Alignment Specifications Revision (02-04-86)
  • Fwd & RWD Tire Rotation Patterns (22-01-86)
  • Front Suspension Alignment Revised Toe-In Specs (02-11-84)
• Window Motors & Regulators
  • Drum And Cable Window Regulator Retrofit Procedure (23-29-93)
  • Liftgate Prop Rods Attachment Points Cracks Repair (23-23-93)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Trailer Tow Wiring Installation Instructions (08-05-91)