Technical Service Bulletins

• A/C Compressor
  • Filtering Refrigerant After Compressor Replacement (98-12-5)
  • Use Of R-12 Refrigerant Substitutes (96-17-10)
  • A/C System Service - List Of Bulletins To Reference (96-15-6)
  • R-12 Refrigerant Substitutes - Service Tip (94-14-3)
  • Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
  • A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
  • A/C Leak In Interior - A/C System Sealing/Repair (86-9-14)
  • A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
  • WARNER A/C Compressor Clutch Assembly R & R (85-4-3)
  • A/C Clutch Inoperative - Field Coil Diagnosis (83-22-5)
  • Manual Heater Erratic/INOP - Replace Vacuum Valve (83-1-10)
  • A/C Compressor Clutch Assembly I.D. (85-23-3)
• Accessories Control Systems
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
• Anti-Theft Systems
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Sliding Door Hits Quarter Panel - Repair Procedure (84-4-26)
  • Anti-Theft INOP - Contaminated Mating Connector (83-18-6)
• Automatic Trans
  • MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
  • New Rotunda Fluid Changer - Service Tip (95-16-10)
  • AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
  • AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
  • Harsh/Delayed Upshift Diagnosis & Repair (91-24-3)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • AOD Trans 1-2 Slip/3-2 Bump - Clutch Friction Plates (88-7-12)
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • AOD Transmission New Overdrive Band Anchor Pin (87-22-13)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • New ATF Applications Chart (87-18-14)
  • 4.9/5.0/5.8L Driveline Shake/Noise - New Driveshaft (86-15-15)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • AOD Trans Main CONTRL Valve Body Gasket (86-13-17)
  • New Synthetic Trans Fluid Information/Application (86-11-17)
  • AOD Trans Revised TV Control Pressure Specifications (86-2-16)
  • AOD Trans Fluid Leak - Front Seal Collapsed (85-24-7)
  • 6.9L Diesel Low Power On Grade - Upshift Kit (85-21-17)
  • AOD No Drive After 4-3 COASTDOWN - 3-4 Shift Valve (85-10-12)
  • C5/C6/AOD Trans O'Heats Cold Days - New Oil Cooler (84-20-14)
  • 4.9L AOD Trans Excess 3/Od Shifting - Adj TV Cable (84-15-16)
  • C-5 And AOD A/T Case Bolt R & R - Sealant Application (84-2-7)
  • Binding At The Drive Shaft/Slip Yoke Junction (83-16-23)
  • AOD A/T New 3-4 Shift Valve/Sleeve/Spring (83-10-11)
  • 6.9L Eng ATX Trans Vacuum Regulating Valve Info (83-10-21)
  • AOD Trans Fluid Leak - UNTORQUED Pipe Plugs (83-6-12)
  • AOD Trans Harsh Downshift - Torsion Return Spring (83-13-9)
  • AOD Trans Revised Front Pump Gasket (83-12-8)
  • AOD Trans Revised TV Linkage Adjustment (83-20-11)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Auxiliary Emission Control Systems
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 6.9/7.3L Eng Surge Hard/No Start - Cold Idle Switch (89-18-9)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • High Flow Pre-Vent Fuel Tank Filler Cap Availability (88-25-13)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • 6.9/7.3L Diesel Eng Glow Plug System Diagnostics (88-11-19)
  • 6.9L Eng New Crankcase Vent Tube Assembly (88-8-15)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • 6.9L Diesel Surge - Cold Idle Temp Switch Diagnosis (87-17-14)
  • 6.9L Diesel New Shutoff Solenoid/GOVERNER Cover R & R (87-16-20)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • 4.9L Rough Idle/Vacuum Leak - EGR Valve Diagnosis (86-20-12)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
  • 6.9L Diesel Fuel Injection Nozzle Opening Pressure (84-1-17)
  • 5.0L Rough Idle/Knock/Poor Mpg - Intake Heat Control (83-22-23)
  • Passenger COMPART. Hissing Or Moan Noise - Tab Valve (83-23-21)
  • 4.9L Eng High Altitude Adjustments (83-7-24)
  • 4.9L Eng - White Exhaust Smoke At Idle - Diagnosis (83-6-24)
  • 4.9L Eng - Rough Idle - A/C Solenoid & Bracket (82-24-20)
  • 5.0/5.8L Eng Spark Knock - Resetting Calibration (83-6-26)
  • 6.1/7.0/7.5L Eng High Altitude Improved DRIVEABILITY (83-10-22)
  • All Models Proper Idle Emissions Testing Procedure (83-6-14)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
• Axle Shafts
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • 4.9/5.0/5.8L Driveline Shake/Noise - New Driveshaft (86-15-15)
  • Binding At The Drive Shaft/Slip Yoke Junction (83-16-23)
  • King Pin Service Caution - Spindle Thread Protection (83-4-13)
• Blowers, Superchargers & Turbochargers
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
• Body Interior
  • A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
  • Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Modifying A/C Snap SWTCH (83-5-17)
• Charging Systems
  • V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
  • Choke Won't Open - Alternator Stator Connection (85-12-24)
  • Alternator - Rectifier Bench Test Procedure (84-3-5)
• Clutch
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • 4.9/5.0/5.8L Driveline Shake/Noise - New Driveshaft (86-15-15)
  • Stiff Clutch/Shifting - Clutch Linkage Conversion (85-18-10)
  • Hydraulic Clutch Diagnosis And Parts List (85-5-26)
  • Clutch Release Bearing Squeak/Scrap (85-2-14)
  • Asbestos Brake & Clutch Warnings (83-22-1)
  • Binding At The Drive Shaft/Slip Yoke Junction (83-16-23)
  • High Effort Clutch Replacement Parts List (85-22-24)
• Cooling System (Mechanical)
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • Use Of Recycled Coolant - Service Tip (95-18-2)
  • 6.9L/7.3 I.D.I. Damaged Cylinders - Coolant In Oil (95-5-24)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 6.9L & 7.3L Diesel Coolant Leak From Cylinder Head (88-26-10)
  • 6.9L & 7.3L Diesel Coolant Water/Antifreeze Ratio (88-26-11)
  • 6.9/7.3L Diesel Crankcase Expansion Plug Tool (88-25-16)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 6.9/7.3L Crankshaft Rear Oil Seal Leak - Seal R & R (88-11-17)
  • 4.9/5.0/5.8/6.9/7.3/7.5L Eng Leak - Intake Man GASK (88-11-16)
  • 6.9L Diesel New Cylinder Head Gasket (88-5-17)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 6.9L Eng Poor Heater Output - Redesigned Thermostat (85-17-11)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • Diagnostic Tips For Heater Core Leaks (85-5-2)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 6.9L Diesel Eng Overheats - Correct Thermostat Info (84-5-18)
  • 6.9L Diesel WATERPUMP New Installation Procedure (84-22-9)
  • CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
  • 6.9L Diesel Cooling System Revised Refill Procedure (84-9-15)
  • 6.9L Diesel Coolant Leaks-Engines Up To Model 61493 (84-7-10)
  • 6.9L Diesel Oil Filter Gasket Leak - Torquing (84-7-12)
  • 7.5L Exhaust System Muffler Shell Wrinkling/SPLITING (84-6-22)
  • 6.9L Diesel New Dynamic Timing Specifications (83-24-23)
  • 7.5L Eng Fuel Selector Valve Diagnosis (83-22-21)
  • 6.9L Eng Blocked Cooling Passage - Repair Service (83-16-19)
  • Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
  • 6.9L Diesel Dynamic Injection Timing Light Setting (83-12-16)
  • Diagnostic Procedure For Accelerator Linkage (83-7-20)
  • 6.9L Diesel Fuel Injectors New Opening Pressure (83-3-20)
  • 3.8/5.0L Eng New One-Piece Rear Main Seal Info (83-8-5)
  • 6.9L Diesel Eng Oil Use/Change Information (85-7-16)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Cruise Control Systems
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 4.9/5.0L Eng Cruise Control Slows Going Up Grades (87-18-19)
• Differentials & Drive Axles
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • 4.9/5.0/5.8L Driveline Shake/Noise - New Driveshaft (86-15-15)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Rear Axle Pinion Angle Adjustment - Tapered Shims (85-5-28)
  • Differential Pinion Shaft Lock Bolt Removal (84-6-15)
  • 8.8" Ring Gear Rear Axle Vent Oil Leak - Modify Vent (83-23-17)
  • Binding At The Drive Shaft/Slip Yoke Junction (83-16-23)
  • Drive Axles Lubricant Draining/Filling (83-3-23)
• Driveshaft & Universal Joints
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • 4.9/5.0/5.8L Driveline Shake/Noise - New Driveshaft (86-15-15)
  • Binding At The Drive Shaft/Slip Yoke Junction (83-16-23)
• Engine Control Systems
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 6.9/7.3L Eng Surge Hard/No Start - Cold Idle Switch (89-18-9)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • 6.9/7.3L Diesel Eng Glow Plug System Diagnostics (88-11-19)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • 6.9L Diesel Surge - Cold Idle Temp Switch Diagnosis (87-17-14)
  • 6.9L Diesel New Shutoff Solenoid/GOVERNER Cover R & R (87-16-20)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4.9L Eng - Rough Idle - A/C Solenoid & Bracket (82-24-20)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
• Entertainment Systems
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • Coil Durability & Radio Frequency Interference (84-22-8)
• Exhaust
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 5.0/5.8L C6 Driveline Vibration/Body Boom Diagnosis (88-7-17)
  • 6.9L Eng Exhaust Manifold New Mounting Hardware (85-11-17)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 6.9L Diesel Exhaust Manifold Torque Specifications (84-16-30)
  • 7.5L Eng Muffler Damage/Leakage - Reinforcing Clamp (84-9-16)
  • Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
  • 4.9L Eng Revised Exhaust Manifold Installation Info (86-6-23)
  • 6.9L Eng Revised Torque Limits & Sequences (83-12-14)
• Exterior Body Panels
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • "Fuel Spit-Back" Overfill Of Fuel Tank (84-2-9)
  • 6.9L Diesel Fuel Selector Valve Diagnosis (83-23-20)
  • Roof Support Rattle - Roof Support Bows Contact Roof (89-13-12)
• Exterior Lights
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
  • Headlamp Bulb Options - Halogen Or Incandescent (83-5-4)
• Frames, Subframes & Crossmembers
  • Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Running Boards Noise/Shake - Installation Tip (87-8-12)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Replacement #1 CROSSMEMBER Kits Available (83-18-18)
  • Roof Support Rattle - Roof Support Bows Contact Roof (89-13-12)
• Front Suspension
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Outside Edge Front Tire Wear - New Caster Adjust Kit (85-19-16)
• Fuel System
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • CFI Fuel Injector Contamination - Replace Injector (87-17-5)
  • 6.9L Diesel Fuel Return Line Cap Leak - New Tee (87-2-23)
  • 5.8/7.5L Poor Performance - Throttle Shaft Housing (87-1-25)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
• Fuses & Circuit Breakers
  • Electrical - New Terminal Grease For Service (98-24-6)
  • Wire Harness Terminal & Connector Service Kit (89-19-5)
  • 6.9L Diesel Glow Plug Wiring Harness Availability (89-5-16)
  • Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
  • No A/C Blower - New Fuse/Fuse Holder (85-10-19)
• Gauges & Instrument Panels
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • 7.5L In-Tank Fuel Filter Damage - Sender R & R Caution (83-25-22)
  • New In Car Fuel Sender Test Procedure (86-15-5)
• General Servicing
  • A/C System Service - List Of Bulletins To Reference (96-15-6)
• Hazardous Waste Material
  • Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Asbestos Brake & Clutch Warnings (83-22-1)
• Headlights
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
  • Headlamp Bulb Options - Halogen Or Incandescent (83-5-4)
• HVAC Control Systems
  • Filtering Refrigerant After Compressor Replacement (98-12-5)
  • Use Of R-12 Refrigerant Substitutes (96-17-10)
  • A/C System Service - List Of Bulletins To Reference (96-15-6)
  • R-12 Refrigerant Substitutes - Service Tip (94-14-3)
  • Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
  • Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
  • A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
  • Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • A/C Leak In Interior - A/C System Sealing/Repair (86-9-14)
  • 6.9L Eng Poor Heater Output - Redesigned Thermostat (85-17-11)
  • A/C Leaks Into Interior - Rework A/C Drain System (85-11-16)
  • No A/C Blower - New Fuse/Fuse Holder (85-10-19)
  • Diagnostic Tips For Heater Core Leaks (85-5-2)
  • A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
  • 4.9L Eng - A/C Refrigerant Loss - New Line & Clip (84-19-17)
  • FS6 A/C Compressor Oil Leak - Compressor Head Kit (84-19-2)
  • Condensation From AIRDUCTS - A/C Aspirator Drain Kit (84-18-21)
  • Low Moan Noise During A/C Operation - Tie Strap Line (84-1-11)
  • Manual Heater Erratic/INOP - Replace Vacuum Valve (83-1-10)
  • Redesigned A/C Damper Door (89-11-9)
• Identification
  • Corporate Standard Circuit Nos. & Wire Color Codes (87-15-3)
  • 6.9L Eng Calibration Decal (83-8-13)
• Ignition Switch/Steering Lock
  • Instrument Cluster Warning Lights Dimly Lit (93-24-10)
• Ignition System
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
  • 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
  • 5.8/7.5L Eng With HOLLEY Carb Hard Hot Soak Start (87-19-13)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • New Distributor Drive Gear Removal Tool (87-2-18)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • Dynamic Timing Meter Tool Periodic Calibration (86-9-16)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
  • TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
  • Coil Durability & Radio Frequency Interference (84-22-8)
  • 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
  • 6.9L Hard Start/Poor Performance - Air Leak Repair (84-16-32)
  • CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
  • 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
  • 7.5L Hesitation/Power Sag Under Load - Fuel Filter (84-3-28)
  • 5.0L Eng Hesitation/Stalls When Hot - Canister Purge (83-24-24)
  • 5.8L Vapor Lock:Fuel Pump (83-24-26)
  • 6.9L Diesel New Dynamic Timing Specifications (83-24-23)
  • 6.9L Eng INJ Pump Shaft Broke - W/Pump Bolt Too Long (83-25-20)
  • 7.5L Eng Fuel Selector Valve Diagnosis (83-22-21)
  • 6.9L Diesel Dynamic Injection Timing Light Setting (83-12-16)
  • Diagnostic Procedure For Accelerator Linkage (83-7-20)
  • 6.9L Diesel Fuel Injectors New Opening Pressure (83-3-20)
  • Ignition Rotor Alignment (83-3-9)
  • 5.0/5.8L Eng Setting Distributor Rotor Alignment (83-8-14)
  • 5.0/5.8L Eng Spark Knock - Resetting Calibration (83-6-26)
  • 6.1/7.0/7.5L Eng High Altitude Improved DRIVEABILITY (83-10-22)
  • 6.9L Eng - Various Diesel Timing Methods Explained (85-16-24)
  • 6.9L Eng Dynamic Timing Pick-Up Installation Info (83-10-19)
  • 6.9L Eng Oil Extended Idle Service Procedure (85-25-18)
  • 7.5L Eng Rough Idle/Loads Up During Warm Up (83-12-18)
  • Distributor Centrifugal Advance Not Serviceable (83-10-15)
• Infotainment
  • Coil Durability & Radio Frequency Interference (84-22-8)
• Interior/Exterior Trim
  • Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Push Button Binds On Door Handle - New Door Hardware (85-3-9)
• Interior/Illumination Lights
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
  • Headlamp Bulb Options - Halogen Or Incandescent (83-5-4)
• Locking Hubs
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • 4.9/5.0/5.8L Driveline Shake/Noise - New Driveshaft (86-15-15)
  • Binding At The Drive Shaft/Slip Yoke Junction (83-16-23)
• Lubrication System
  • Oil Level Checking Procedure - Gasoline Engines (85-25-20)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 6.9L & 7.3L Diesel Coolant Leak From Cylinder Head (88-26-10)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 6.9/7.3L Crankshaft Rear Oil Seal Leak - Seal R & R (88-11-17)
  • 4.9/5.0/5.8/6.9/7.3/7.5L Eng Leak - Intake Man GASK (88-11-16)
  • 6.9L Diesel New Cylinder Head Gasket (88-5-17)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • 6.9L Eng Excessive Oil Consumption Diagnosis (87-3-19)
  • 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
  • 7.5L Eng Engine Oil Consumption Guidelines (86-16-16)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 6.9L Eng Oil Use/Dipstick Info (85-25-19)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • Using Oil-Leak-BLACKLITE (85-5-13)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
  • CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
  • 7.5L Eng Oil Pick-Up Tube Installation Tip (84-9-18)
  • 6.9L Diesel Coolant Leaks-Engines Up To Model 61493 (84-7-10)
  • 6.9L Diesel Oil Filter Gasket Leak - Torquing (84-7-12)
  • 7.5L Exhaust System Muffler Shell Wrinkling/SPLITING (84-6-22)
  • 6.9L Diesel Sub-Zero Weather Warming/Idling Caution (84-1-13)
  • 6.9L Diesel New Dynamic Timing Specifications (83-24-23)
  • 7.5L Eng Fuel Selector Valve Diagnosis (83-22-21)
  • Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
  • 6.9L Diesel Dynamic Injection Timing Light Setting (83-12-16)
  • Diagnostic Procedure For Accelerator Linkage (83-7-20)
  • 6.9L Diesel Exhaust Smoke - Diagnosis (83-4-16)
  • 6.9L Diesel Fuel Injectors New Opening Pressure (83-3-20)
  • 3.8/5.0L Eng New One-Piece Rear Main Seal Info (83-8-5)
  • 6.9L Diesel Eng Oil Use/Change Information (85-7-16)
  • 6.9L Eng Oil Extended Idle Service Procedure (85-25-18)
  • 7.5L Eng Rough Idle/Loads Up During Warm Up (83-12-18)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Manual Steering
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
• Manual Trans
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • M/T Fluid Usage/Drivetrain Lubrication Charts (89-8-16)
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • 4.9/5.0/5.8L Driveline Shake/Noise - New Driveshaft (86-15-15)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Clutch Release Bearing Squeak/Scrap (85-2-14)
  • Shift Knob Pulls Off - New Design Shift Lever (83-19-17)
  • Binding At The Drive Shaft/Slip Yoke Junction (83-16-23)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Mechanical
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • Oil Level Checking Procedure - Gasoline Engines (85-25-20)
  • 6.9L/7.3 I.D.I. Damaged Cylinders - Coolant In Oil (95-5-24)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
  • 5.0L Eng AOD Trans Metal To Metal Engine Noise (91-4-10)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 6.9L & 7.3L Diesel Coolant Leak From Cylinder Head (88-26-10)
  • 6.9/7.3L Dies Debris In Oil Cooler Bundle - Replace (88-25-15)
  • 6.9/7.3L Diesel Crankcase Expansion Plug Tool (88-25-16)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 6.9/7.3L Crankshaft Rear Oil Seal Leak - Seal R & R (88-11-17)
  • 4.9/5.0/5.8/6.9/7.3/7.5L Eng Leak - Intake Man GASK (88-11-16)
  • 6.9L Eng New Crankcase Vent Tube Assembly (88-8-15)
  • 6.9L Diesel New Cylinder Head Gasket (88-5-17)
  • 6.9L Diesel New Crankshaft R & R (87-23-13)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • 6.9L Eng New Cylinder Re-Ringing/Re-Honing (87-17-10)
  • 6.9L Diesel New Valve Rocker Arm Assembly R & R (87-16-18)
  • 6.9L Diesel Valley Pan Gasket Water Port Sealing (87-16-17)
  • 6.9L Diesel Crankshaft Wear Sleeve Installation Tool (87-12-16)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • 6.9L Eng Cylinder Bore Taper Revised Specifications (87-5-32)
  • 6.9L Eng Excessive Oil Consumption Diagnosis (87-3-19)
  • 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
  • 7.5L Oil Consumption - Intake Valve Guide Seal (87-2-24)
  • 7.5L Eng Engine Oil Consumption Guidelines (86-16-16)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 6.9L Eng Oil Use/Dipstick Info (85-25-19)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • Using Oil-Leak-BLACKLITE (85-5-13)
  • Poor Run/Oil Consumption - Air Cleaner/Carb Sealing (83-25-21-S)
  • 4.9L Eng Rocker Arm Assembly Caution (85-3-12)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 6.9L Diesel Cylinder Head Bolts New Torque Specs (85-1-19)
  • Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
  • 6.9L Diesel New Valve Spring Assembly Installation (84-19-20)
  • 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
  • 6.9L Hard Start/Poor Performance - Air Leak Repair (84-16-32)
  • CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
  • 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
  • 4.9 New Cylinder Head Torque Specifications (84-11-19)
  • 6.9L Diesel Pre-Combustion Insert Crack Inspection (84-8-23)
  • 6.9L Diesel Coolant Leaks-Engines Up To Model 61493 (84-7-10)
  • 6.9L Diesel Oil Filter Gasket Leak - Torquing (84-7-12)
  • 7.5L Exhaust System Muffler Shell Wrinkling/SPLITING (84-6-22)
  • 4.9L Eng Cold Piston Slap - Vacuum System/Pistons (84-23-14-S)
  • 7.5L Hesitation/Power Sag Under Load - Fuel Filter (84-3-28)
  • 6.9L Diesel Sub-Zero Weather Warming/Idling Caution (84-1-13)
  • 5.0L Eng Hesitation/Stalls When Hot - Canister Purge (83-24-24)
  • 5.8L Vapor Lock:Fuel Pump (83-24-26)
  • 6.9L Diesel New Dynamic Timing Specifications (83-24-23)
  • 6.9L Eng INJ Pump Shaft Broke - W/Pump Bolt Too Long (83-25-20)
  • 4.9L Low/No Oil Pressure - Check/Replace Camshaft (83-22-18)
  • 5.0L Rough Idle/Knock/Poor Mpg - Intake Heat Control (83-22-23)
  • 7.5L Eng Fuel Selector Valve Diagnosis (83-22-21)
  • Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
  • Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
  • Oil Dipstick Level Markings (83-13-7)
  • 6.9L Diesel Dynamic Injection Timing Light Setting (83-12-16)
  • Diagnostic Procedure For Accelerator Linkage (83-7-20)
  • 6.9L Diesel Exhaust Smoke - Diagnosis (83-4-16)
  • 6.9L Diesel Fuel Injectors New Opening Pressure (83-3-20)
  • 2.2/6.9L Eng Cylinder Head Resurfacing Warning (83-10-18)
  • 3.8/5.0L Eng New One-Piece Rear Main Seal Info (83-8-5)
  • 6.9L Diesel Eng Oil Use/Change Information (85-7-16)
  • 6.9L Eng Oil Extended Idle Service Procedure (85-25-18)
  • 6.9L Eng Revised Torque Limits & Sequences (83-12-14)
  • 7.5L Eng Rough Idle/Loads Up During Warm Up (83-12-18)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Mechanical - Hydraulic
  • Brakes - Soft Pedal Feel/Brake Wear &/Or Pull (98-5A-29)
  • Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
  • Brake Shudder Vibration - New H/D Brake Rotors (87-24-14)
  • Brake Rotor Cracked/Shudder/Vibration - New Rotor (87-16-16)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Front Disc Brakes Squeal - New Brake Pad Insulation (86-8-13)
  • Brake Rotors Updated Diagnosis/Service (85-9-8)
  • Rear Brakes Accelerated Wear - Brake Service Kit (84-16-28)
  • Brake Fluid Discoloration Diagnosis (84-12-8)
  • Asbestos Brake & Clutch Warnings (83-22-1)
  • Front Disc Brake Noise - Brake Pad Insulator Kit (85-3-10)
• Mirrors
  • Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
• Paint & Coatings
  • Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
  • Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Super Seal Compound & Equipment - Concern Diagnosis (83-3-4)
• Passive Restraints
  • Safety Belt Tongue Cover Parts Availability (88-25-2)
  • Safety Belt - Replacement Procedure After Accident (88-15-3)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Seat/Shoulder Belt General Service Information (85-2-4)
• Rear Suspension
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Outside Edge Front Tire Wear - New Caster Adjust Kit (85-19-16)
• Seats
  • Safety Belt Tongue Cover Parts Availability (88-25-2)
  • Safety Belt - Replacement Procedure After Accident (88-15-3)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Seat/Shoulder Belt General Service Information (85-2-4)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
  • Noise/Rattle - Roof Support Bows Contact Roof Panel (89-7T-29)
• Sleeper
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
• Solar Ventilation
  • Manual Heater Erratic/INOP - Replace Vacuum Valve (83-1-10)
• Starter
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 5.8/7.5L Eng With HOLLEY Carb Hard Hot Soak Start (87-19-13)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • 6.9L Eng Worn Starter Motor Ring Gear - New Starter (85-10-21)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
  • 6.9L Hard Start/Poor Performance - Air Leak Repair (84-16-32)
  • CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
  • 5.8L Vapor Lock:Fuel Pump (83-24-26)
  • 6.9L Diesel New Dynamic Timing Specifications (83-24-23)
  • 6.9L Eng INJ Pump Shaft Broke - W/Pump Bolt Too Long (83-25-20)
  • 7.5L Eng Fuel Selector Valve Diagnosis (83-22-21)
  • 6.9L Diesel Dynamic Injection Timing Light Setting (83-12-16)
  • Battery Test Procedure Using Rotunda Battery Tester (83-8-2)
  • Diagnostic Procedure For Accelerator Linkage (83-7-20)
  • 6.9L Diesel Fuel Injectors New Opening Pressure (83-3-20)
  • Auxiliary Battery New Weather Resistant Relay (85-21-12)
• Steering Control Systems
  • Electronic Modules - Damage From Static Electricity (88-13-3)
• Steering Gear
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Manual Steering Gear Adjustments (83-3-17)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Steering Linkage
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Steering Off Center/Unequal Turn Angles - Drag Link (88-14-14)
  • King Pin Service Caution - Spindle Thread Protection (83-4-13)
  • Manual Steering Gear Adjustments (83-3-17)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Wheel Stud Replacement Procedure (86-11-19)
• Sun Roof/T-Top/Convertible Top
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Noise/Rattle - Roof Support Bows Contact Roof Panel (89-7T-29)
• Suspension Control Systems
  • Electronic Modules - Damage From Static Electricity (88-13-3)
• System
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 6.9/7.3L Eng Surge Hard/No Start - Cold Idle Switch (89-18-9)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • High Flow Pre-Vent Fuel Tank Filler Cap Availability (88-25-13)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • 6.9/7.3L Crankshaft Rear Oil Seal Leak - Seal R & R (88-11-17)
  • 6.9/7.3L Diesel Eng Glow Plug System Diagnostics (88-11-19)
  • 4.9/5.0/5.8/6.9/7.3/7.5L Eng Leak - Intake Man GASK (88-11-16)
  • 6.9L Eng New Crankcase Vent Tube Assembly (88-8-15)
  • 6.9L Diesel New Cylinder Head Gasket (88-5-17)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
  • 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
  • 5.8/7.5L Eng With HOLLEY Carb Hard Hot Soak Start (87-19-13)
  • 6.9L Diesel Surge - Cold Idle Temp Switch Diagnosis (87-17-14)
  • CFI Fuel Injector Contamination - Replace Injector (87-17-5)
  • 6.9L Diesel New Shutoff Solenoid/GOVERNER Cover R & R (87-16-20)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • New Distributor Drive Gear Removal Tool (87-2-18)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • 4.9L Rough Idle/Vacuum Leak - EGR Valve Diagnosis (86-20-12)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • Dynamic Timing Meter Tool Periodic Calibration (86-9-16)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
  • TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
  • EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
  • Coil Durability & Radio Frequency Interference (84-22-8)
  • 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
  • 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
  • 6.9L Hard Start/Poor Performance - Air Leak Repair (84-16-32)
  • CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
  • 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
  • 6.9L Diesel Coolant Leaks-Engines Up To Model 61493 (84-7-10)
  • 6.9L Diesel Oil Filter Gasket Leak - Torquing (84-7-12)
  • 7.5L Hesitation/Power Sag Under Load - Fuel Filter (84-3-28)
  • 6.9L Diesel Fuel Injection Nozzle Opening Pressure (84-1-17)
  • 5.0L Eng Hesitation/Stalls When Hot - Canister Purge (83-24-24)
  • 5.8L Vapor Lock:Fuel Pump (83-24-26)
  • 6.9L Diesel New Dynamic Timing Specifications (83-24-23)
  • 6.9L Eng INJ Pump Shaft Broke - W/Pump Bolt Too Long (83-25-20)
  • 5.0L Rough Idle/Knock/Poor Mpg - Intake Heat Control (83-22-23)
  • 7.5L Eng Fuel Selector Valve Diagnosis (83-22-21)
  • Passenger COMPART. Hissing Or Moan Noise - Tab Valve (83-23-21)
  • Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
  • 6.9L Diesel Dynamic Injection Timing Light Setting (83-12-16)
  • 4.9L Eng High Altitude Adjustments (83-7-24)
  • Diagnostic Procedure For Accelerator Linkage (83-7-20)
  • 4.9L Eng - White Exhaust Smoke At Idle - Diagnosis (83-6-24)
  • 6.9L Diesel Fuel Injectors New Opening Pressure (83-3-20)
  • Ignition Rotor Alignment (83-3-9)
  • 4.9L Eng - Rough Idle - A/C Solenoid & Bracket (82-24-20)
  • 3.8/5.0L Eng New One-Piece Rear Main Seal Info (83-8-5)
  • 5.0/5.8L Eng Setting Distributor Rotor Alignment (83-8-14)
  • 5.0/5.8L Eng Spark Knock - Resetting Calibration (83-6-26)
  • 6.1/7.0/7.5L Eng High Altitude Improved DRIVEABILITY (83-10-22)
  • 6.9L Eng - Various Diesel Timing Methods Explained (85-16-24)
  • 6.9L Eng Dynamic Timing Pick-Up Installation Info (83-10-19)
  • 6.9L Eng Oil Extended Idle Service Procedure (85-25-18)
  • 7.5L Eng Rough Idle/Loads Up During Warm Up (83-12-18)
  • All Models Proper Idle Emissions Testing Procedure (83-6-14)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Distributor Centrifugal Advance Not Serviceable (83-10-15)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
• Transfer Case
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • 4.9/5.0/5.8L Driveline Shake/Noise - New Driveshaft (86-15-15)
  • Binding At The Drive Shaft/Slip Yoke Junction (83-16-23)
• Transmission Control Systems
  • AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
  • 6.9L Diesel New C6 A/T Delayed/Harsh Shift - Normal (84-16-31)
• Vacuum Pumps/Lines/Tanks/Water Trap
  • 6.9L & 7.3L Diesel Coolant Leak From Cylinder Head (88-26-10)
  • 7.5L Exhaust System Muffler Shell Wrinkling/SPLITING (84-6-22)
  • Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
• Wheel Hubs
  • Wheel Stud Replacement Procedure (86-11-19)
• Wheels & Tire System
  • Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
  • 5.0/5.8L C6 Driveline Vibration/Body Boom Diagnosis (88-7-17)
  • Wheel Lug Nuts Binding - New Nuts/Torque Specs (87-7-21)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • All Season Tires Outer Edge Appearance Tire Wear (84-6-12)
  • King Pin Service Caution - Spindle Thread Protection (83-4-13)
  • Outside Edge Front Tire Wear - New Caster Adjust Kit (85-19-16)
  • Rear Axle Dog Tracking - Alignment Check Info (83-7-18)
  • Wheel Stud Replacement Procedure (86-11-19)
• Window Motors & Regulators
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
  • Glass - Mottling In Tempered Glass (83-16-4)
  • Noise/Rattle - Roof Support Bows Contact Roof Panel (89-7T-29)
• Wiper/Washer Systems
  • False Low Wiper Fluid Light - Fluid Dilution (84-21-9)
  • Wiper Motor Noise - New Motor (83-22-16)
  • Wiper Blade Delivery Covers (93-9-3)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Electrical - New Terminal Grease For Service (98-24-6)
  • Wire Harness Terminal & Connector Service Kit (89-19-5)
  • 6.9L Diesel Glow Plug Wiring Harness Availability (89-5-16)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Engine Compartment - Use Waterproof Wire Connectors (87-2-6)