Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- 2.3/3.8L Eng A/C Compressor Clutch Replacement (87-5-4)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- WARNER A/C Compressor Clutch Assembly R & R (85-4-3)
- A/C Clutch Inoperative - Field Coil Diagnosis (83-22-5)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Accessory Drive Belts
- Anti-Lock Brakes
- Anti-Theft Systems
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Map COMPRATMENT Assembly Pulls Out Of Trim Panel (85-22-1)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- Door Front Wind Noise - CUTLINE Seal/Weatherstrip (85-12-4)
- Hood Latch Stuck Closed - Improved Cable Retention (84-5-3)
- Aftermarket Theft Device - EEC Warnings (85-7-8)
- Anti-Theft INOP - Contaminated Mating Connector (83-18-6)
- Inoperative Hood Latch Assembly - New Clip (83-7-2)
- Reprogramming Keyless Entry Auto Door Lock Function (83-17-4)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
- AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- AOD Trans 1-2 Slip/3-2 Bump - Clutch Friction Plates (88-7-12)
- AOD Transmission New Overdrive Band Anchor Pin (87-22-13)
- New ATF Applications Chart (87-18-14)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- AOD Trans Main CONTRL Valve Body Gasket (86-13-17)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- AOD Trans Revised TV Control Pressure Specifications (86-2-16)
- AOD Trans Fluid Leak - Front Seal Collapsed (85-24-7)
- AOD No Drive After 4-3 COASTDOWN - 3-4 Shift Valve (85-10-12)
- C5 Trans 3-2 Downshift - Pressure Booster Spring (84-24-6)
- C-5 And AOD A/T Case Bolt R & R - Sealant Application (84-2-7)
- AOD Delayed 3-4/Oversensitive 4-3 - Shift Revision (83-19-10)
- AOD Automatic Transmission Design Changes (83-18-10)
- 5.0L Eng AOD/ATX Trans Erratic Shift - TV Rod Return (83-15-6)
- AOD Trans Erratic Shift - Restricted TV Rod Return (83-15-6)
- AOD A/T New 3-4 Shift Valve/Sleeve/Spring (83-10-11)
- AOD Trans Fluid Leak - UNTORQUED Pipe Plugs (83-6-12)
- AOD Trans Harsh Downshift - Torsion Return Spring (83-13-9)
- AOD Trans New ORFICE Control Plug (85-14-7)
- AOD Trans Revised Front Pump Gasket (83-12-8)
- AOD Trans Revised TV Linkage Adjustment (83-20-11)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- C5 Trans Revised Rear Output Shaft/Seal (83-9-5)
- Extension Housing Bolts Treated With A Sealant (83-6-11)
- Auxiliary Emission Control Systems
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- 5.0L Low Oil Pressure - Oil Screen/Cover/PCV Valve (88-5-10)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- 2.3L Turbo Poor Performance - Oil In Air Vane Meter (88-3-11)
- 5.0L Eng PCV Valve Replacement Interval (87-14-11)
- 2.3L EFI Turbo Burning Oil/Knock/Rough Idle/Stall (87-11-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 5.0L Idle Stall/EGR Valve Stuck - Diagnosis/Repair (86-2-22)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- Turbo Eng Excess Whine/Oil Consumption Diagnosis (84-22-4)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- 2.3L EFI Turbo Code 67 With New Processor - Normal (84-14-12)
- 5.0L Eng Lope/Surge At 35MPH - BMAP Sensor Wiring (84-14-15)
- Oil Film In Vane Air Outlet/Meter - New SEPERATOR (84-6-18-S)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- 2.3L EFI Stall/Erratic Idle - Base Idle Setting (84-14-14)
- No Start Below 32 Degrees - Frozen Vane Air Meter (84-11-10)
- 3.8L Stall On DECEL - Carb Throttle Speed Positioner (83-1-8)
- 2.3/3.3/3.8/5.0L Eng Air Pump Noise - New Pump (86-11-24)
- 2.3L Eng Poor PERF/Idle/Stall - Speed Control Nipple (86-10-8)
- 2.3L Eng Poor Performance/Fuel Economy (85-17-5)
- 3.8L Eng Drive Belt Squeal - MISALIGN P/Steer Pulley (83-5-14)
- Aftermarket Theft Device - EEC Warnings (85-7-8)
- All Models Proper Idle Emissions Testing Procedure (83-6-14)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- 3.8L Eng Anti-Diesel Relay Location (83-18-8)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Brakes Control Systems
- Charging Systems
- V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- 5.0L Overheating During High Temps (85 Degrees And Above) (84-6-14)
- Alternator - Rectifier Bench Test Procedure (84-3-5)
- 2.3L Eng Water Cooled Turbo Replacement Info (86-6-12)
- 3.8L Eng Drive Belt Squeal - MISALIGN P/Steer Pulley (83-5-14)
- V-Ribbed Drive Belt Replacement Information (83-11-3)
- Clutch
- Component Locations
- Cooling Fan
- Cooling System (Mechanical)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- 2.3L Leaks Oil: Revised Cylinder Head Gasket & Bolts (94-6-4)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 2.3L Turbo Poor Performance - Oil In Air Vane Meter (88-3-11)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- 3.8L Eng Service Oil Pan Gasket Kit (86-14-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- 3.8L Poor Idle/Run - Spark Plugs/Intake Valve Seals (84-16-16-S)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- 5.0L Overheating During High Temps (85 Degrees And Above) (84-6-14)
- 3.8L Eng New One Piece Oil Pan Gasket R & R (83-22-12)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 2.3L Eng Water Cooled Turbo Replacement Info (86-6-12)
- 2.3L Turbo Engine Noise - Replace Heater Hose Clamp (83-13-18)
- 2.8/3.8/5.0L Eng RTV Engine Sealant Info (83-13-8)
- 3.8/5.0L Eng New One-Piece Rear Main Seal Info (83-8-5)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Cruise Control Systems
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 2.3L EFI Turbo Burning Oil/Knock/Rough Idle/Stall (87-11-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- Turbo Eng Excess Whine/Oil Consumption Diagnosis (84-22-4)
- 2.3L EFI Turbo Code 67 With New Processor - Normal (84-14-12)
- 5.0L Eng Lope/Surge At 35MPH - BMAP Sensor Wiring (84-14-15)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- 2.3L EFI Stall/Erratic Idle - Base Idle Setting (84-14-14)
- No Start Below 32 Degrees - Frozen Vane Air Meter (84-11-10)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 3.8L Stall On DECEL - Carb Throttle Speed Positioner (83-1-8)
- 2.3L Eng Poor Performance/Fuel Economy (85-17-5)
- Aftermarket Theft Device - EEC Warnings (85-7-8)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Fuel Filler Door Inoperative - Repair Latch/Solenoid (84-3-1)
- "Fuel Spit-Back" Overfill Of Fuel Tank (84-2-9)
- Inoperative Electric Fuel Pump - Pound Tank W/Mallet (82-3-7-S)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- 3.8L Stall On DECEL - Carb Throttle Speed Positioner (83-1-8)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Erratic Fuel Gauge - Replace Fuel Sender (84-18-16)
- Fuel Gauge Reads 1/4 When Empty - Fuel Sender Filter (83-24-5)
- 3.8/5.0L Eng Low Fuel Economy Indication TRIPMINDER (83-9-2)
- New Fuel Gauge Test (83-20-6)
- New In Car Fuel Sender Test Procedure (86-15-5)
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C Low Side Pressure Hose Service Adapter Tool (87-7-2)
- 2.3L Eng A/C Belt Rumble - A/C System Repair (86-3-7)
- A/C Orifice Tube Replacement Kit Installation (85-12-9)
- A/C Automatic Temp Control Erratic - Diverter Valve (85-9-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Cold Air Leaks From Evaporator - Housing Repairs (86-4-6)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised DURA Spark Ignition Module (89-10T-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Rough Idle - Replacement Intake Manifold (86-13-16)
- 2.3L EFI Turbo Rough Idle/Stall - Turbo Pipe Plug (86-4-16)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- 2.3L Turbo Stall/No Idle - Inlet Air Tube Pipe Plug (85-10-15)
- 3.8L Eng Rough Idle - Loose Crossover Heat Tubes (85-7-9)
- 3.8L Poor Idle/Run - Spark Plugs/Intake Valve Seals (84-16-16-S)
- Distributor Stator Assembly R & R (85-4-21)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 3.8L CANADA Models Idle High - Electric Choke Wire (84-9-12)
- Off-Idle Tip-In Stumble/Stall - Fuel Bowl/ACCEL Pump (84-3-21)
- 1.6L/2.3L Eng - E-Coil Buzz/Click - New E-Coil (84-3-18)
- 5.0L CFI Overheat/High Idle - Caution/Curb Idle SPD (83-25-12)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 3.8L Eng Anti-Diesel Relay Location (83-18-8)
- 5.0L CFI Cold/Warm Hesitation - Set Fast/Curb Idle (83-7-10)
- Ignition Rotor Alignment (83-3-9)
- 3.8L Stall On DECEL - Carb Throttle Speed Positioner (83-1-8)
- 3.8L Eng Spark Knock - New Distributor Armature (82-17-16)
- 1.6/2.3/2.8L Eng Ignition Timing Setting Procedure (83-10-3)
- 1.6L/2.3L Eng Stall At Idle/Roughness (83-14-12)
- 2.3L Eng Water Cooled Turbo Replacement Info (86-6-12)
- 3.8/5.0L Eng Poor PERFORMNCE - Low Fuel Pressure Fix (85-14-11)
- 3.8L CANADIAN Eng Hard/No Start/Miss/Fouled Plugs (83-17-10)
- 4.2/5.0/5.8L CARV Eng Runs Rich - Choke PULLDOWN (86-5-6)
- Aftermarket Theft Device - EEC Warnings (85-7-8)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Interior/Exterior Trim
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Map COMPRATMENT Assembly Pulls Out Of Trim Panel (85-22-1)
- Door Front Wind Noise - CUTLINE Seal/Weatherstrip (85-12-4)
- Engine Noise Transmits To Interior - Diagnostics (83-9-7)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- 2.3L Leaks Oil: Revised Cylinder Head Gasket & Bolts (94-6-4)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 2.3L Turbo Poor Performance - Oil In Air Vane Meter (88-3-11)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- 3.8L Eng Service Oil Pan Gasket Kit (86-14-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 3.8L Poor Idle/Run - Spark Plugs/Intake Valve Seals (84-16-16-S)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.3L EFI Turbo - Oil Supply Elbow Inspection (84-20-11)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- 5.0L Overheating During High Temps (85 Degrees And Above) (84-6-14)
- 3.8L Eng New One Piece Oil Pan Gasket R & R (83-22-12)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 2.3L Eng Water Cooled Turbo Replacement Info (86-6-12)
- 2.8/3.8/5.0L Eng RTV Engine Sealant Info (83-13-8)
- 3.8/5.0L Eng New One-Piece Rear Main Seal Info (83-8-5)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Manual Steering
- Revised Torque Requirement For New Tie Rods (96-1-1)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Power Steering CII Pump Leakage At Dipstick Cap (86-9-7)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- Power Steering Dipstick Leaking - Center Vent Stick (85-1-11-S)
- Power Steering Service - New Short Rack Kit (83-22-11)
- Power Steering Fluid Dark Colored (83-17-5)
- Power Steering Pump Rotor/C-Clip Changes (83-10-6)
- Power Steer New Rack & Pinion Gear Housing/Valve Bore (82-25-12)
- 3.8L Eng Drive Belt Squeal - MISALIGN P/Steer Pulley (83-5-14)
- Manual Trans
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gear Shift Pops Off - New Design Shift Knob (83-15-7)
- 2.3/5.0L Eng T50D Trans Fill Plug Caution (83-13-12)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- T-50D Trans Click/Rattle Noise In 2ND Under Load (83-14-10)
- Mechanical
- 2.3L Leaks Oil: Revised Cylinder Head Gasket & Bolts (94-6-4)
- AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
- 5.0L Eng AOD Trans Metal To Metal Engine Noise (91-4-10)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- 2.3L Turbo Poor Performance - Oil In Air Vane Meter (88-3-11)
- 3.8L Eng Service Oil Pan Gasket Kit (86-14-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Rough Idle - Replacement Intake Manifold (86-13-16)
- 2.3L EFI Turbo Rough Idle/Stall - Turbo Pipe Plug (86-4-16)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- Fuel Pump Noise - High Pressure Fuel Pump/Damper (85-11-12)
- 2.3L Turbo Stall/No Idle - Inlet Air Tube Pipe Plug (85-10-15)
- 3.8L Eng Rough Idle - Loose Crossover Heat Tubes (85-7-9)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 3.8L Poor Idle/Run - Spark Plugs/Intake Valve Seals (84-16-16-S)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.3L EFI Turbo Excess Whistle - Repair Outlet Hose (84-20-8)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2.3L Eng Oil Consumption - Restricted Vent Tube (84-16-23)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 3.8L CANADA Models Idle High - Electric Choke Wire (84-9-12)
- 3.3L Eng THERMACTOR Pump Mount Broken - New Bracket (84-8-20)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- 5.0L Overheating During High Temps (85 Degrees And Above) (84-6-14)
- Off-Idle Tip-In Stumble/Stall - Fuel Bowl/ACCEL Pump (84-3-21)
- 5.0L CFI Overheat/High Idle - Caution/Curb Idle SPD (83-25-12)
- 3.8L Eng New One Piece Oil Pan Gasket R & R (83-22-12)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Oil Dipstick Level Markings (83-13-7)
- 5.0L CFI Cold/Warm Hesitation - Set Fast/Curb Idle (83-7-10)
- 3.8L Stall On DECEL - Carb Throttle Speed Positioner (83-1-8)
- 1.6L/2.3L Eng Stall At Idle/Roughness (83-14-12)
- 2.3L Eng Water Cooled Turbo Replacement Info (86-6-12)
- 2.8/3.8/5.0L Eng RTV Engine Sealant Info (83-13-8)
- 3.8/5.0L Eng New Front Engine Mount Stud Size (83-14-7)
- 3.8/5.0L Eng New One-Piece Rear Main Seal Info (83-8-5)
- 3.8/5.0L Eng Poor PERFORMNCE - Low Fuel Pressure Fix (85-14-11)
- 3.8L Eng C5 Trans Vibration - New Engine CROSSMEMBER (83-8-10)
- 3.8L Eng Drive Belt Squeal - MISALIGN P/Steer Pulley (83-5-14)
- 4.2/5.0/5.8L CARV Eng Runs Rich - Choke PULLDOWN (86-5-6)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Park Brake Won't Stay Applied - New Release Spring (84-14-8)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Replacement Brake Pad Installation Information (83-25-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Front Disc Brake Shoe/Lining Revision (83-22-8)
- New Caliper Pin (86-10-3)
- Rear Brake Squeal - New Bonded Brake Shoe (86-19-5)
- Riveted Rear Brake Shoe Squeal - New Bonded Shoe (86-19-5)
- Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Drivers Power Seat Rocks When Braking/Accelerating (85-8-1)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Fuel Filler Door Inoperative - Repair Latch/Solenoid (84-3-1)
- Paint & Coatings
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Super Seal Compound & Equipment - Concern Diagnosis (83-3-4)
- Passive Restraints
- Rear Suspension
- Schedule
- Seats
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Drivers Power Seat Rocks When Braking/Accelerating (85-8-1)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Fuel Filler Door Inoperative - Repair Latch/Solenoid (84-3-1)
- Front Seat Back Moves - Replace Inertia Latch (86-16-1)
- Sleeper
- Starter
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Fuel Pump Noise - High Pressure Fuel Pump/Damper (85-11-12)
- 3.8L Battery Drain - Anti-Dieseling Relay Check (85-4-6)
- 2.3L EFI Turbo Excess Whistle - Repair Outlet Hose (84-20-8)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Battery Test Procedure Using Rotunda Battery Tester (83-8-2)
- 2.3L Eng Water Cooled Turbo Replacement Info (86-6-12)
- Aftermarket Theft Device - EEC Warnings (85-7-8)
- Steering Column
- Steering Column Switches
- Steering Control Systems
- Steering Gear
- Revised Torque Requirement For New Tie Rods (96-1-1)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Power Steering CII Pump Leakage At Dipstick Cap (86-9-7)
- Power Steering Dipstick Leaking - Center Vent Stick (85-1-11-S)
- Power Steering Service - New Short Rack Kit (83-22-11)
- Power Steer New Rack & Pinion Gear Housing/Valve Bore (82-25-12)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 2.3L Leaks Oil: Revised Cylinder Head Gasket & Bolts (94-6-4)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Revised DURA Spark Ignition Module (89-10T-3)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 5.0L Low Oil Pressure - Oil Screen/Cover/PCV Valve (88-5-10)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- 2.3L Turbo Poor Performance - Oil In Air Vane Meter (88-3-11)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- 5.0L Eng PCV Valve Replacement Interval (87-14-11)
- 2.3L EFI Turbo Burning Oil/Knock/Rough Idle/Stall (87-11-18)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- 3.8L Eng Service Oil Pan Gasket Kit (86-14-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Rough Idle - Replacement Intake Manifold (86-13-16)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 2.3L EFI Turbo Rough Idle/Stall - Turbo Pipe Plug (86-4-16)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 5.0L Idle Stall/EGR Valve Stuck - Diagnosis/Repair (86-2-22)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- 2.3L Turbo Stall/No Idle - Inlet Air Tube Pipe Plug (85-10-15)
- 3.8L Eng Rough Idle - Loose Crossover Heat Tubes (85-7-9)
- 3.8L Poor Idle/Run - Spark Plugs/Intake Valve Seals (84-16-16-S)
- Distributor Stator Assembly R & R (85-4-21)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- Turbo Eng Excess Whine/Oil Consumption Diagnosis (84-22-4)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2.3L EFI Turbo Code 67 With New Processor - Normal (84-14-12)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- 5.0L Eng Lope/Surge At 35MPH - BMAP Sensor Wiring (84-14-15)
- Oil Film In Vane Air Outlet/Meter - New SEPERATOR (84-6-18-S)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- 2.3L EFI Stall/Erratic Idle - Base Idle Setting (84-14-14)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- No Start Below 32 Degrees - Frozen Vane Air Meter (84-11-10)
- 3.8L CANADA Models Idle High - Electric Choke Wire (84-9-12)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- Off-Idle Tip-In Stumble/Stall - Fuel Bowl/ACCEL Pump (84-3-21)
- 1.6L/2.3L Eng - E-Coil Buzz/Click - New E-Coil (84-3-18)
- 5.0L CFI Overheat/High Idle - Caution/Curb Idle SPD (83-25-12)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 3.8L Eng New One Piece Oil Pan Gasket R & R (83-22-12)
- 3.8L Eng Anti-Diesel Relay Location (83-18-8)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 5.0L CFI Cold/Warm Hesitation - Set Fast/Curb Idle (83-7-10)
- Ignition Rotor Alignment (83-3-9)
- 3.8L Stall On DECEL - Carb Throttle Speed Positioner (83-1-8)
- 3.8L Eng Spark Knock - New Distributor Armature (82-17-16)
- 1.6/2.3/2.8L Eng Ignition Timing Setting Procedure (83-10-3)
- 1.6L/2.3L Eng Stall At Idle/Roughness (83-14-12)
- 2.3/3.3/3.8/5.0L Eng Air Pump Noise - New Pump (86-11-24)
- 2.3L Eng Poor PERF/Idle/Stall - Speed Control Nipple (86-10-8)
- 2.3L Eng Poor Performance/Fuel Economy (85-17-5)
- 2.3L Eng Water Cooled Turbo Replacement Info (86-6-12)
- 2.8/3.8/5.0L Eng RTV Engine Sealant Info (83-13-8)
- 3.8/5.0L Eng New One-Piece Rear Main Seal Info (83-8-5)
- 3.8/5.0L Eng Poor PERFORMNCE - Low Fuel Pressure Fix (85-14-11)
- 3.8L CANADIAN Eng Hard/No Start/Miss/Fouled Plugs (83-17-10)
- 4.2/5.0/5.8L CARV Eng Runs Rich - Choke PULLDOWN (86-5-6)
- Aftermarket Theft Device - EEC Warnings (85-7-8)
- All Models Proper Idle Emissions Testing Procedure (83-6-14)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- POLYCAST Wheel Paint Chip/Peels: Repaint Procedure (87-23-6)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- All Season Tires Outer Edge Appearance Tire Wear (84-6-12)
- Outer Edge Front Tire Wear - Alignment Information (85-23-9)
- Wheel Stud Replacement Procedure (86-11-19)
- Window Motors & Regulators
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Door Front Wind Noise - CUTLINE Seal/Weatherstrip (85-12-4)
- Drivers Power Seat Rocks When Braking/Accelerating (85-8-1)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Fuel Filler Door Inoperative - Repair Latch/Solenoid (84-3-1)
- Glass - Mottling In Tempered Glass (83-16-4)
- Revised Windshield Installation Procedures (89-6T-4)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Park Brake Won't Stay Applied - New Release Spring (84-14-8)
- 2.3L Eng Water Cooled Turbo Replacement Info (86-6-12)
- 4.9/5.0/5.8/6.9/7.5L Eng New Hydraulic Clutch Info (83-6-15)