Technical Service Bulletins

• A/C Compressor
  • Filtering Refrigerant After Compressor Replacement (98-12-5)
  • Identification Of Non-Ford Approved Refrigerants (99-19-6)
  • Use Of R-12 Refrigerant Substitutes (96-17-10)
  • A/C System Service - List Of Bulletins To Reference (96-15-6)
  • Ford Approved Flushing Procedures For A/C System (95-8-1)
  • R-12 Refrigerant Substitutes - Service Tip (94-14-3)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
  • New Refrigerant Fitting "O" Rings (91-22-5)
  • Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
  • A/C "O" Ring Usage Table (90-14-8)
  • A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
  • Accessory Belt Squeal - New High-Profile V-Belts (87-5-31)
  • A/C Leak In Interior - A/C System Sealing/Repair (86-9-14)
  • A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
  • A/C Compressor Clutch Assembly I.D. (85-23-3)
• Accessories Control Systems
  • Latches - Door - Replacement Required (91-8-4)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
• Accessory Drive Belts
  • Accessory Belt Squeal - New High-Profile V-Belts (87-5-31)
• Aerodynamic Devices
  • Window Regulator Inoperative Or Handle Loose (85-3-1)
• Anti-Theft Systems
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Latches - Door - Replacement Required (91-8-4)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Door Locks Inoperative - Aftermarket Rustproofing (85-12-2)
  • Wind Noise Diagnostic/Repair Procedures (85-8-17)
  • Window Regulator Inoperative Or Handle Loose (85-3-1)
• Automatic Trans
  • MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
  • Transmission Fluid Usage Chart (98-8-8)
  • Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
  • Torque Converter Leak Test Procedure - New Tool (96-24-9)
  • New Rotunda Fluid Changer - Service Tip (95-16-10)
  • AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
  • AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
  • Harsh/Delayed Upshift Diagnosis & Repair (91-24-3)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • AOD Trans 1-2 Slip/3-2 Bump - Clutch Friction Plates (88-7-12)
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • AOD Transmission New Overdrive Band Anchor Pin (87-22-13)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • A/T Cooler Line Connections Leak - Modify Connectors (87-18-13)
  • New ATF Applications Chart (87-18-14)
  • Driveline Vibration/Boom - New Driveshaft Assembly (86-15-14)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • AOD Trans Main CONTRL Valve Body Gasket (86-13-17)
  • New Synthetic Trans Fluid Information/Application (86-11-17)
  • AOD Trans Revised TV Control Pressure Specifications (86-2-16)
  • AOD Oversensitive 4/3 Shift - TV Cable/Valve Body (86-1-11)
  • AOD Trans Revised Main Control Valve Body Assembly (86-1-10)
  • 6.9L Diesel Low Power On Grade - Upshift Kit (85-21-17)
  • AOD A/T Low Mileage Overhaul - Service Tips/Update (85-11-9)
  • AOD No Drive After 4-3 COASTDOWN - 3-4 Shift Valve (85-10-12)
  • AOD Transmission Main Control Valve Body Changes (85-4-18)
  • AOD Transmission Design Changes (84-20-6)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Auxiliary Emission Control Systems
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
  • Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
  • Nylon Fuel Line Service (92-12-16)
  • Electronic Control Modules - Damage From Arc Welding (91-7-5)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • Emission Maintenance Warning Module - Information (89-22-8)
  • 6.9/7.3L Eng Surge Hard/No Start - Cold Idle Switch (89-18-9)
  • TPS Service Replacement Chart (89-16-4)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
  • 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
  • High Flow Pre-Vent Fuel Tank Filler Cap Availability (88-25-13)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • 6.9/7.3L Diesel Eng Glow Plug System Diagnostics (88-11-19)
  • 6.9L Eng New Crankcase Vent Tube Assembly (88-8-15)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • 6.9L Diesel Surge - Cold Idle Temp Switch Diagnosis (87-17-14)
  • 6.9L Diesel New Shutoff Solenoid/GOVERNER Cover R & R (87-16-20)
  • 5.0L EFI White/Gray Smoke At Idle - THERMACTOR SYS (87-5-33)
  • Accessory Belt Squeal - New High-Profile V-Belts (87-5-31)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • 5.8L Altitude Compensation System Description (86-12-17)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • Shop Manual Revision - Emission System Maintenance (85-4-40)
  • 4.9L Eng - Hesitation Or Stumble - Revise EGR System (84-4-36)
  • 4.9 L Eng PCV Valve Pops Out Of Rocker Arm Cover (85-16-17)
  • 5.8L 4V O/8500 GVW - Hesitation/Surge/Rough Idle (85-16-18)
  • 7.5L Eng Surge At Normal Temp - Install EGR Valve (85-15-21)
  • EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
  • EEC IV - Invalid, Erratic Service Codes (85-12-12)
  • Map Sensor New Part Numbers/Applications (85-12-17)
  • 5.8L Eng Choke/Vacuum System Information (85-8-23)
  • 4.9L Eng C5/C6/AOD Trans False Code 15 (85-5-30)
  • 4.9L Stumble: Revised EGR System (85-5-29)
  • 5.8L Eng White Exhaust Smoke @ Idle After Long Drive (85-5-32)
  • EGR Valve Position Sensor Part Id Information (85-5-17)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
  • 4.9/5.0/5.8/6.9/7.5L Eng Spark Knock - Diag List (86-6-33)
  • 5.8L Eng HAERD Start/Hesitate/Stumble After Hot Soak (85-22-23)
  • 5.8L Eng Hard Start/Stall/Poor Fuel Economy (89-6T-17)
  • EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
  • Emission Light Stays On - Replace/Reset Procedure (85-21-11)
  • EMW/IMS Warning Module Definition Location (89-11T-20)
  • Engine Compartment Intermittent Concern Diag Process (85-17-3)
  • Revised EEC Power Relay Pin-Out Location (85-15-5)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
• Axle Shafts
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • Driveline Vibration/Boom - New Driveshaft Assembly (86-15-14)
  • Aluminum Or Graphite Propeller Shaft Service Caution (85-10-24)
• Blowers, Superchargers & Turbochargers
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 7.5L Eng Water Pump Leak - New Water Pump/Pulley (87-7-24)
  • V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
  • 7.5L Eng Non-OEM A/C Fan Installation Caution (85-15-11)
• Body Interior
  • Electrical Diode Identification And Replacements (96-24-6)
  • A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
  • Latches - Door - Replacement Required (91-8-4)
  • Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
• Brakes Control Systems
  • Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
• Charging Systems
  • 7.5L Eng Water Pump Leak - New Water Pump/Pulley (87-7-24)
  • Accessory Belt Squeal - New High-Profile V-Belts (87-5-31)
  • V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
  • 7.5L Eng Non-OEM A/C Fan Installation Caution (85-15-11)
  • Choke Won't Open - Alternator Stator Connection (85-12-24)
  • All Models No/Low Charging - Open Alternator Stator (86-11-4)
• Clutch
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • Driveline Vibration/Boom - New Driveshaft Assembly (86-15-14)
  • Hydraulic Clutch Diagnosis And Parts List (85-5-26)
  • Asbestos Brake & Clutch Warnings (83-22-1)
• Cooling Fan
  • Cooling System - Use Of Recycled Engine Coolant (90-4-10)
• Cooling System (Mechanical)
  • Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • Use Of Recycled Coolant - Service Tip (95-18-2)
  • 6.9L/7.3 I.D.I. Damaged Cylinders - Coolant In Oil (95-5-24)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
  • Nylon Fuel Line Service (92-12-16)
  • Cooling System - Use Of Recycled Engine Coolant (90-4-10)
  • 6.9L Diesel Injection Pump Replacement Adapter Kit (90-3-10)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 6.9L & 7.3L Diesel Coolant Leak From Cylinder Head (88-26-10)
  • 6.9L & 7.3L Diesel Coolant Water/Antifreeze Ratio (88-26-11)
  • 6.9/7.3L Diesel Crankcase Expansion Plug Tool (88-25-16)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 6.9/7.3L Crankshaft Rear Oil Seal Leak - Seal R & R (88-11-17)
  • 6.9L Diesel New Cylinder Head Gasket (88-5-17)
  • Revised Electric Fuel Pump Testing (87-11-15)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • 7.5L Eng Water Pump Leak - New Water Pump/Pulley (87-7-24)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 6.9L Eng Poor Heater Output - Redesigned Thermostat (85-17-11)
  • 4.9/5.0L Eng New Front Cover/Crankshaft Seal (85-15-10)
  • 7.5L Eng Non-OEM A/C Fan Installation Caution (85-15-11)
  • 4.9/7.5L Front Crankshaft Seal Oil Leak - New Seal (85-12-25)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • Diagnostic Tips For Heater Core Leaks (85-5-2)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4.9L Eng New Idle Mixture Setting Procedure (85-1-23)
  • 6.9L Diesel WATERPUMP New Installation Procedure (84-22-9)
  • 5.8L 4V Hard Start/Poor Power/Idle/Run - Carburetor (84-18-22)
  • 6.9/7.3L Eng Valve Stem Oil Shield Elimination Info (89-11-10)
  • 6.9L Diesel Eng Oil Use/Change Information (85-7-16)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
• Cruise Control Systems
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 4.9/5.0L Eng Cruise Control Slows Going Up Grades (87-18-19)
• Differentials & Drive Axles
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • Driveline Vibration/Boom - New Driveshaft Assembly (86-15-14)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Aluminum Or Graphite Propeller Shaft Service Caution (85-10-24)
  • Rear Axle Pinion Angle Adjustment - Tapered Shims (85-5-28)
• Driveshaft & Universal Joints
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • Driveline Vibration/Boom - New Driveshaft Assembly (86-15-14)
  • Aluminum Or Graphite Propeller Shaft Service Caution (85-10-24)
• Engine Control Systems
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
  • Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
  • Electronic Control Modules - Damage From Arc Welding (91-7-5)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • Emission Maintenance Warning Module - Information (89-22-8)
  • 6.9/7.3L Eng Surge Hard/No Start - Cold Idle Switch (89-18-9)
  • TPS Service Replacement Chart (89-16-4)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
  • 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • 6.9/7.3L Diesel Eng Glow Plug System Diagnostics (88-11-19)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • 6.9L Diesel Surge - Cold Idle Temp Switch Diagnosis (87-17-14)
  • 6.9L Diesel New Shutoff Solenoid/GOVERNER Cover R & R (87-16-20)
  • 5.0L EFI White/Gray Smoke At Idle - THERMACTOR SYS (87-5-33)
  • Fuel Line Spring Lock Coupling R & R (87-3-8)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • 5.8L Altitude Compensation System Description (86-12-17)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
  • EEC IV - Invalid, Erratic Service Codes (85-12-12)
  • Map Sensor New Part Numbers/Applications (85-12-17)
  • 5.8L Eng Choke/Vacuum System Information (85-8-23)
  • 4.9L Eng C5/C6/AOD Trans False Code 15 (85-5-30)
  • EGR Valve Position Sensor Part Id Information (85-5-17)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
  • 4.9/5.0/5.8/6.9/7.5L Eng Spark Knock - Diag List (86-6-33)
  • 4.9/5.0/5.8/7.5L Eng Stumble/Knock/Surge - Vac Leak (86-7-16)
  • 5.8L Eng HAERD Start/Hesitate/Stumble After Hot Soak (85-22-23)
  • EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
  • Emission Light Stays On - Replace/Reset Procedure (85-21-11)
  • EMW/IMS Warning Module Definition Location (89-11T-20)
  • Engine Compartment Intermittent Concern Diag Process (85-17-3)
  • Revised EEC Power Relay Pin-Out Location (85-15-5)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
• Entertainment Systems
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • Coil Durability & Radio Frequency Interference (84-22-8)
• Exhaust
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • Rear Cargo Floor Warm - New Exhaust Heat Deflectors (89-14-14)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 4.9L Exhaust Manifold Warp/Leak - New Manifold/ECM (88-7-16)
  • 5.0/5.8L C6 Driveline Vibration/Body Boom Diagnosis (88-7-17)
  • 4.9L Eng Rough Idle/Exhaust Leak - Loose Bolts (86-9-18)
  • 5.8L Eng Poor Idle/Mileage - Intake Heat Control VLV (85-25-25)
  • 6.9L Eng Exhaust Manifold New Mounting Hardware (85-11-17)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 6.9L Diesel Exhaust Manifold Torque Specifications (84-16-30)
  • 4.9L Eng Exhaust Noise Misdiagnosed As Piston Slap (85-21-15)
  • 4.9L Eng Revised Exhaust Manifold Installation Info (86-6-23)
• Exterior Body Panels
  • Water Leaks: Identification And Correction (92-9-10)
  • Lower Body Stone Protection Repair Tips (90-15-3)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Roof Support Rattle - Roof Support Bows Contact Roof (89-13-12)
• Exterior Lights
  • Latches - Door - Replacement Required (91-8-4)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
• Frames, Subframes & Crossmembers
  • Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
  • Lower Body Stone Protection Repair Tips (90-15-3)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Running Boards Noise/Shake - Installation Tip (87-8-12)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Roof Support Rattle - Roof Support Bows Contact Roof (89-13-12)
• Front Suspension
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Front/Rear SUSP Spring Description/Applications (85-9A-1)
  • Outside Edge Front Tire Wear - New Caster Adjust Kit (85-19-16)
• Fuel System
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
  • Nylon Fuel Line Service (92-12-16)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • Emission Maintenance Warning Module - Information (89-22-8)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • CFI Fuel Injector Contamination - Replace Injector (87-17-5)
  • Fuel Line Spring Lock Coupling R & R (87-3-8)
  • 6.9L Diesel Fuel Return Line Cap Leak - New Tee (87-2-23)
  • 5.8/7.5L Poor Performance - Throttle Shaft Housing (87-1-25)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
• Fuses & Circuit Breakers
  • Wiring - Wire Harness Terminal Repair Kit (99-6-3)
  • Electrical - New Terminal Grease For Service (98-24-6)
  • Electrical Diode Identification And Replacements (96-24-6)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Wire Harness Terminal & Connector Service Kit (89-19-5)
  • Wiring System Diagnosis Cautions (87-4-8)
  • Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
  • Wiring Diagram Symbols Explanation (85-11-5)
  • No A/C Blower - New Fuse/Fuse Holder (85-10-19)
  • Wire Color Code Change (85-4-8)
• Gauges & Instrument Panels
  • Fuel Tank Sending Unit Wiring Damaged - New Wiring (89-14-6)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • Damaged Fuel Tank Sending Unit Connector Repair (89-7T-14)
  • New In Car Fuel Sender Test Procedure (86-15-5)
• General Servicing
  • A/C System Service - List Of Bulletins To Reference (96-15-6)
• Hazardous Waste Material
  • Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Asbestos Brake & Clutch Warnings (83-22-1)
• Headlights
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
• HVAC Control Systems
  • Filtering Refrigerant After Compressor Replacement (98-12-5)
  • Identification Of Non-Ford Approved Refrigerants (99-19-6)
  • Use Of R-12 Refrigerant Substitutes (96-17-10)
  • A/C System Service - List Of Bulletins To Reference (96-15-6)
  • Ford Approved Flushing Procedures For A/C System (95-8-1)
  • R-12 Refrigerant Substitutes - Service Tip (94-14-3)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
  • Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
  • New Refrigerant Fitting "O" Rings (91-22-5)
  • A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
  • Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
  • Electronic Control Modules - Damage From Arc Welding (91-7-5)
  • A/C "O" Ring Usage Table (90-14-8)
  • Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
  • Auxiliary Blower Motor Runs On High Only - Resistor (88-20-13)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • A/C Leaks At Condenser Outlet Tube - New Tube (87-20-19)
  • A/C Vents/Blower Water Leak - VENTURI Tube/Deflector (86-23-14)
  • A/C Leak In Interior - A/C System Sealing/Repair (86-9-14)
  • 6.9L Eng Poor Heater Output - Redesigned Thermostat (85-17-11)
  • A/C Leaks Into Interior - Rework A/C Drain System (85-11-16)
  • No A/C Blower - New Fuse/Fuse Holder (85-10-19)
  • Diagnostic Tips For Heater Core Leaks (85-5-2)
  • A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
• Identification
  • Corporate Standard Circuit Nos. & Wire Color Codes (87-15-3)
• Ignition Switch/Steering Lock
  • Instrument Cluster Warning Lights Dimly Lit (93-24-10)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Latches - Door - Replacement Required (91-8-4)
• Ignition System
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
  • Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
  • Nylon Fuel Line Service (92-12-16)
  • New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
  • Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
  • 6.9L Diesel Injection Pump Replacement Adapter Kit (90-3-10)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • Distributor Gear Matched To Distributor At Assembly (89-6-11)
  • 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
  • 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
  • 4.9L Eng Rough During Extended Idle - New Bowl Vent (87-18-21)
  • 5.8/7.5L Eng With HOLLEY Carb Hard Hot Soak Start (87-19-13)
  • Revised Electric Fuel Pump Testing (87-11-15)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
  • New Distributor Drive Gear Removal Tool (87-2-18)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
  • Dynamic Timing Meter Tool Periodic Calibration (86-9-16)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
  • TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
  • DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
  • Distributor Stator Assembly R & R (85-4-21)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4.9L Eng New Idle Mixture Setting Procedure (85-1-23)
  • 5.8L 4V Eng Cold Stall - Choke PULLDOWN Setting (84-24-11)
  • Coil Durability & Radio Frequency Interference (84-22-8)
  • 5.8L Carb Eng - Rich Condition - Carb Gasket (84-22-11)
  • 5.8L 4V Hard Start/Poor Power/Idle/Run - Carburetor (84-18-22)
  • 4.9/5.0/5.8L Eng Calculating Mpg (90-6-15)
  • 4.9L Carb Eng Rough Idle - Diagnostic Steps (85-16-22)
  • 5.8L Eng HAERD Start/Hesitate/Stumble After Hot Soak (85-22-23)
  • 6.9L Eng - Various Diesel Timing Methods Explained (85-16-24)
  • 6.9L Eng Oil Extended Idle Service Procedure (85-25-18)
  • 7.5L Carb Eng Stall On Cold DRIVEAWAY - New Choke (85-16-23)
  • 7.5L Eng Stalls/Fuel Starvation - Modify Pickup (85-22-30)
  • Engine Compartment Intermittent Concern Diag Process (85-17-3)
  • Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
  • No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
  • Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
• Infotainment
  • Coil Durability & Radio Frequency Interference (84-22-8)
• Interior/Exterior Trim
  • Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
  • Water Leaks: Identification And Correction (92-9-10)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Wind Noise Diagnostic/Repair Procedures (85-8-17)
  • Window Regulator Inoperative Or Handle Loose (85-3-1)
• Interior/Illumination Lights
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
• Locking Hubs
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • Driveline Vibration/Boom - New Driveshaft Assembly (86-15-14)
• Lubrication System
  • Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
  • Oil Level Checking Procedure - Gasoline Engines (85-25-20)
  • 4.9L Knocking Noise On Initial Start-Up (95-8-8)
  • Nylon Fuel Line Service (92-12-16)
  • 6.9L Diesel Injection Pump Replacement Adapter Kit (90-3-10)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 6.9L & 7.3L Diesel Coolant Leak From Cylinder Head (88-26-10)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 6.9/7.3L Crankshaft Rear Oil Seal Leak - Seal R & R (88-11-17)
  • 6.9L Diesel New Cylinder Head Gasket (88-5-17)
  • Revised Electric Fuel Pump Testing (87-11-15)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • 6.9L Eng Excessive Oil Consumption Diagnosis (87-3-19)
  • 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
  • 7.5L Eng Engine Oil Consumption Guidelines (86-16-16)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 6.9L Eng Oil Use/Dipstick Info (85-25-19)
  • 4.9/5.0L Eng New Front Cover/Crankshaft Seal (85-15-10)
  • 4.9/7.5L Front Crankshaft Seal Oil Leak - New Seal (85-12-25)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • Using Oil-Leak-BLACKLITE (85-5-13)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4.9L Eng New Idle Mixture Setting Procedure (85-1-23)
  • Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
  • 5.8L Carb Eng - Rich Condition - Carb Gasket (84-22-11)
  • 5.8L 4V Hard Start/Poor Power/Idle/Run - Carburetor (84-18-22)
  • 7.5L Eng Oil Pick-Up Tube Installation Tip (84-9-18)
  • 6.9/7.3L Eng Valve Stem Oil Shield Elimination Info (89-11-10)
  • 6.9L Diesel Eng Oil Use/Change Information (85-7-16)
  • 6.9L Eng Oil Extended Idle Service Procedure (85-25-18)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
• Manual Steering
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Accessory Belt Squeal - New High-Profile V-Belts (87-5-31)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
• Manual Trans
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • M/T Fluid Usage/Drivetrain Lubrication Charts (89-8-16)
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • Driveline Vibration/Boom - New Driveshaft Assembly (86-15-14)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • M4OD/Tod Transmission Main Bearing Change (85-4-35)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Mechanical
  • Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • Oil Level Checking Procedure - Gasoline Engines (85-25-20)
  • 4.9L Knocking Noise On Initial Start-Up (95-8-8)
  • 6.9L/7.3 I.D.I. Damaged Cylinders - Coolant In Oil (95-5-24)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
  • Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
  • AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
  • Nylon Fuel Line Service (92-12-16)
  • New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
  • 5.0L Eng AOD Trans Metal To Metal Engine Noise (91-4-10)
  • Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
  • 6.9L Diesel Injection Pump Replacement Adapter Kit (90-3-10)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
  • 6.9L & 7.3L Diesel Coolant Leak From Cylinder Head (88-26-10)
  • 6.9/7.3L Dies Debris In Oil Cooler Bundle - Replace (88-25-15)
  • 6.9/7.3L Diesel Crankcase Expansion Plug Tool (88-25-16)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • 6.9/7.3L Crankshaft Rear Oil Seal Leak - Seal R & R (88-11-17)
  • 6.9L Eng New Crankcase Vent Tube Assembly (88-8-15)
  • Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
  • 6.9L Diesel New Cylinder Head Gasket (88-5-17)
  • 6.9L Diesel New Crankshaft R & R (87-23-13)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • 4.9L Eng Rough During Extended Idle - New Bowl Vent (87-18-21)
  • 6.9L Eng New Cylinder Re-Ringing/Re-Honing (87-17-10)
  • 6.9L Diesel New Valve Rocker Arm Assembly R & R (87-16-18)
  • 6.9L Diesel Valley Pan Gasket Water Port Sealing (87-16-17)
  • 6.9L Diesel Crankshaft Wear Sleeve Installation Tool (87-12-16)
  • 5.0L Eng Knock - Main Bearing Clearance Adjustment (87-11-12)
  • Revised Electric Fuel Pump Testing (87-11-15)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • 6.9L Eng Cylinder Bore Taper Revised Specifications (87-5-32)
  • Accessory Belt Squeal - New High-Profile V-Belts (87-5-31)
  • 6.9L Eng Excessive Oil Consumption Diagnosis (87-3-19)
  • 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
  • 7.5L Oil Consumption - Intake Valve Guide Seal (87-2-24)
  • 7.5L Eng Engine Oil Consumption Guidelines (86-16-16)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 6.9L Eng Oil Use/Dipstick Info (85-25-19)
  • 4.9/5.0L Eng New Front Cover/Crankshaft Seal (85-15-10)
  • 4.9/7.5L Front Crankshaft Seal Oil Leak - New Seal (85-12-25)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • 4.9L Eng Revised Camshaft Gear Removal Tool (85-8-27)
  • Using Oil-Leak-BLACKLITE (85-5-13)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4.9L Eng New Idle Mixture Setting Procedure (85-1-23)
  • 6.9L Diesel Cylinder Head Bolts New Torque Specs (85-1-19)
  • Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
  • 5.8L Carb Eng - Rich Condition - Carb Gasket (84-22-11)
  • 6.9L Diesel New Valve Spring Assembly Installation (84-19-20)
  • 5.8L 4V Hard Start/Poor Power/Idle/Run - Carburetor (84-18-22)
  • 4.9 New Cylinder Head Torque Specifications (84-11-19)
  • 4.9/5.0/5.8/6.9/7.5L Eng Front Eng Noise - Loose Nut (86-10-15)
  • 4.9/5.0/5.8L Eng Calculating Mpg (90-6-15)
  • 4.9L Carb Eng Rough Idle - Diagnostic Steps (85-16-22)
  • 4.9L Eng Exhaust Noise Misdiagnosed As Piston Slap (85-21-15)
  • 4.9L Eng Noise From Left Side - Glue Engine Mount (86-6-36)
  • 6.9/7.3L Eng Valve Stem Oil Shield Elimination Info (89-11-10)
  • 6.9L Diesel Eng Oil Use/Change Information (85-7-16)
  • 6.9L Eng Oil Extended Idle Service Procedure (85-25-18)
  • 7.5L Eng Stalls/Fuel Starvation - Modify Pickup (85-22-30)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
  • Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
• Mechanical - Air
  • Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
• Mechanical - Hydraulic
  • Brakes - Soft Pedal Feel/Brake Wear &/Or Pull (98-5A-29)
  • Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
  • Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
  • Occasional Or Intermittent Brake Squeal - Normal (90-22-6)
  • Premature Brake Wear - Rear Height Sensing Valve (89-25-16)
  • Poor Rear Brakes - Rear Height Sensing Valve R & R (88-12-20)
  • Brake Shudder Vibration - New H/D Brake Rotors (87-24-14)
  • Brake Rotor Cracked/Shudder/Vibration - New Rotor (87-16-16)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Brake Rotors Updated Diagnosis/Service (85-9-8)
  • Brake Fluid Discoloration Diagnosis (84-12-8)
  • Asbestos Brake & Clutch Warnings (83-22-1)
  • Occasional\Intermittent Brake Squeal - Normal (86-6-9)
  • Vehicle Height Sensing Proportioning Valve Service (85-21-14)
• Mirrors
  • Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
  • Power Front Door Window Jams In The Up Position (89-10T-24)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
  • Power Door Window Jams - New Regulator (89-20-13)
• Paint & Coatings
  • Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
  • Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
  • Exterior Paint Comprehensive Repair Procedures (91-18-1)
  • Lower Body Stone Protection Repair Tips (90-15-3)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
• Passive Restraints
  • Front Safety Belt Outboard Tongue - New Service Kit (93-12-1)
  • Latches - Door - Replacement Required (91-8-4)
  • Safety Belt Tongue Cover Parts Availability (88-25-2)
  • Safety Belt - Replacement Procedure After Accident (88-15-3)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Seat/Shoulder Belt General Service Information (85-2-4)
• Rear Suspension
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Front/Rear SUSP Spring Description/Applications (85-9A-1)
  • Outside Edge Front Tire Wear - New Caster Adjust Kit (85-19-16)
• Seats
  • Seat - Leather Cleaning Procedure (98-17-1)
  • Front Safety Belt Outboard Tongue - New Service Kit (93-12-1)
  • Power Front Door Window Jams In The Up Position (89-10T-24)
  • Safety Belt Tongue Cover Parts Availability (88-25-2)
  • Safety Belt - Replacement Procedure After Accident (88-15-3)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Seat/Shoulder Belt General Service Information (85-2-4)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
  • Noise/Rattle - Roof Support Bows Contact Roof Panel (89-7T-29)
  • Power Door Window Jams - New Regulator (89-20-13)
• Sleeper
  • Latches - Door - Replacement Required (91-8-4)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
• Starter
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
  • Battery Testing Procedure (91-10-10)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • 6.9L Diesel Injection Pump Replacement Adapter Kit (90-3-10)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • 5.8/7.5L Eng With HOLLEY Carb Hard Hot Soak Start (87-19-13)
  • Revised Electric Fuel Pump Testing (87-11-15)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • 6.9L Eng Worn Starter Motor Ring Gear - New Starter (85-10-21)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4.9L Eng New Idle Mixture Setting Procedure (85-1-23)
  • 5.8L Carb Eng - Rich Condition - Carb Gasket (84-22-11)
  • 5.8L 4V Hard Start/Poor Power/Idle/Run - Carburetor (84-18-22)
  • Auxiliary Battery New Weather Resistant Relay (85-21-12)
  • Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
  • Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
• Steering Control Systems
  • Electronic Control Modules - Damage From Arc Welding (91-7-5)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • Engine Compartment Intermittent Concern Diag Process (85-17-3)
• Steering Gear
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Steering Linkage
  • XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
  • Steering Off Center/Unequal Turn Angles - Drag Link (88-14-14)
  • Steering Drift/Pull - Ball Socket Preload Diagnosis (86-6-22)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Wheel Stud Replacement Procedure (86-11-19)
• Sun Roof/T-Top/Convertible Top
  • Water Leaks: Identification And Correction (92-9-10)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Window Regulator Inoperative Or Handle Loose (85-3-1)
  • Noise/Rattle - Roof Support Bows Contact Roof Panel (89-7T-29)
• Suspension Control Systems
  • Electronic Control Modules - Damage From Arc Welding (91-7-5)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • Engine Compartment Intermittent Concern Diag Process (85-17-3)
• System
  • Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
  • 6.9L - Glow Plug Control System Upgrade (98-4-20)
  • CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
  • 6.9L/7.3L Diesel Stalls When Coming To A Stop (94-5-11)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
  • 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
  • Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
  • Nylon Fuel Line Service (92-12-16)
  • New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
  • Electronic Control Modules - Damage From Arc Welding (91-7-5)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • 6.9L Diesel Injection Pump Replacement Adapter Kit (90-3-10)
  • Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
  • Emission Maintenance Warning Module - Information (89-22-8)
  • 6.9/7.3L Eng Surge Hard/No Start - Cold Idle Switch (89-18-9)
  • TPS Service Replacement Chart (89-16-4)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • 5.8L-4V High Alt. Poor Fuel Economy/Hard Start/Stall (89-12-9)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Distributor Gear Matched To Distributor At Assembly (89-6-11)
  • EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
  • 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
  • High Flow Pre-Vent Fuel Tank Filler Cap Availability (88-25-13)
  • 6.1L/7.0L/7.5L 4V - Spark Knock/Backfire/Poor PERF. (88-20-20)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • 6.9/7.3L Crankshaft Rear Oil Seal Leak - Seal R & R (88-11-17)
  • 6.9/7.3L Diesel Eng Glow Plug System Diagnostics (88-11-19)
  • 6.9L Eng New Crankcase Vent Tube Assembly (88-8-15)
  • 6.9L Diesel New Cylinder Head Gasket (88-5-17)
  • New Altitude COMPENSATOR Kit: 5.8L & 7.5L Engines (87-23-14)
  • TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
  • 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
  • 4.9L Eng Rough During Extended Idle - New Bowl Vent (87-18-21)
  • 5.8/7.5L Eng With HOLLEY Carb Hard Hot Soak Start (87-19-13)
  • 6.9L Diesel Surge - Cold Idle Temp Switch Diagnosis (87-17-14)
  • CFI Fuel Injector Contamination - Replace Injector (87-17-5)
  • 6.9L Diesel New Shutoff Solenoid/GOVERNER Cover R & R (87-16-20)
  • Revised Electric Fuel Pump Testing (87-11-15)
  • 6.9L Diesel Poor Engine Performance Diagnosis (87-10-21)
  • 5.8/7.5L Fuel Sender Auxiliary Port Rubber Cap (87-7-26)
  • TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
  • 5.0L EFI White/Gray Smoke At Idle - THERMACTOR SYS (87-5-33)
  • Fuel Line Spring Lock Coupling R & R (87-3-8)
  • New Distributor Drive Gear Removal Tool (87-2-18)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • 5.8L Altitude Compensation System Description (86-12-17)
  • TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
  • Dynamic Timing Meter Tool Periodic Calibration (86-9-16)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
  • TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
  • 5.8L Eng Poor Idle/Mileage - Intake Heat Control VLV (85-25-25)
  • DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
  • Shop Manual Revision - Emission System Maintenance (85-4-40)
  • 4.9L Eng - Hesitation Or Stumble - Revise EGR System (84-4-36)
  • 4.9 L Eng PCV Valve Pops Out Of Rocker Arm Cover (85-16-17)
  • 5.8L 4V O/8500 GVW - Hesitation/Surge/Rough Idle (85-16-18)
  • 7.5L Eng Surge At Normal Temp - Install EGR Valve (85-15-21)
  • 4.9/5.0L Eng New Front Cover/Crankshaft Seal (85-15-10)
  • EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
  • 4.9/7.5L Front Crankshaft Seal Oil Leak - New Seal (85-12-25)
  • EEC IV - Invalid, Erratic Service Codes (85-12-12)
  • Map Sensor New Part Numbers/Applications (85-12-17)
  • 6.9L Dies A/T Vacuum Regulator Valve New Adjustment (85-11-20)
  • 5.8L Eng Choke/Vacuum System Information (85-8-23)
  • No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
  • 4.9L Eng C5/C6/AOD Trans False Code 15 (85-5-30)
  • 4.9L Stumble: Revised EGR System (85-5-29)
  • 5.8L Eng White Exhaust Smoke @ Idle After Long Drive (85-5-32)
  • EGR Valve Position Sensor Part Id Information (85-5-17)
  • Distributor Stator Assembly R & R (85-4-21)
  • 6.9L Diesel Fuel Injection Pump Authorized Service (85-2-19)
  • 4.9L Eng New Idle Mixture Setting Procedure (85-1-23)
  • 5.8L 4V Eng Cold Stall - Choke PULLDOWN Setting (84-24-11)
  • Coil Durability & Radio Frequency Interference (84-22-8)
  • 5.8L Carb Eng - Rich Condition - Carb Gasket (84-22-11)
  • 5.8L 4V Hard Start/Poor Power/Idle/Run - Carburetor (84-18-22)
  • 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
  • 4.9/5.0/5.8/6.9/7.5L Eng Spark Knock - Diag List (86-6-33)
  • 4.9/5.0/5.8/7.5L Eng Stumble/Knock/Surge - Vac Leak (86-7-16)
  • 4.9/5.0/5.8L Eng Calculating Mpg (90-6-15)
  • 4.9L Carb Eng Rough Idle - Diagnostic Steps (85-16-22)
  • 5.8L Eng HAERD Start/Hesitate/Stumble After Hot Soak (85-22-23)
  • 5.8L Eng Hard Start/Stall/Poor Fuel Economy (89-6T-17)
  • 6.9/7.3L Eng Valve Stem Oil Shield Elimination Info (89-11-10)
  • 6.9L Eng - Various Diesel Timing Methods Explained (85-16-24)
  • 6.9L Eng Oil Extended Idle Service Procedure (85-25-18)
  • 7.5L Carb Eng Stall On Cold DRIVEAWAY - New Choke (85-16-23)
  • 7.5L Eng Stalls/Fuel Starvation - Modify Pickup (85-22-30)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
  • Emission Light Stays On - Replace/Reset Procedure (85-21-11)
  • EMW/IMS Warning Module Definition Location (89-11T-20)
  • Engine Compartment Intermittent Concern Diag Process (85-17-3)
  • Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
  • No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
  • Revised EEC Power Relay Pin-Out Location (85-15-5)
  • Service PROC For Nylon Fuel Tubes & Push Connectors (85-19-20)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
• Transfer Case
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Driveline Boom/Vibration In Od - New Driveshaft (88-4-17)
  • Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
  • Driveline Vibration/Boom - New Driveshaft Assembly (86-15-14)
• Transmission Control Systems
  • AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Electronic Control Modules - Damage From Arc Welding (91-7-5)
• Vacuum Pumps/Lines/Tanks/Water Trap
  • Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
  • Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
  • 6.9L & 7.3L Diesel Coolant Leak From Cylinder Head (88-26-10)
• Wheel Hubs
  • Wheel Stud Replacement Procedure (86-11-19)
• Wheels & Tire System
  • Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
  • Tire Company Phone Numbers For Customer Assistance (98-5-2)
  • 16X6 Single Steel Wheel Vibration - Pilot/Lug Holes (91-11-16)
  • 5.0/5.8L C6 Driveline Vibration/Body Boom Diagnosis (88-7-17)
  • Wheel Lug Nuts Binding - New Nuts/Torque Specs (87-7-21)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Front Tire Wear - Rotate Tires And Check Alignment (86-24-27)
  • Outside Edge Front Tire Wear - New Caster Adjust Kit (85-19-16)
  • Tire Wear - Load/Tire Inflation Information (89-5T-20)
  • Vehicle Modifications Require Resetting Toe (86-24-28)
  • Wheel Stud Replacement Procedure (86-11-19)
• Window Motors & Regulators
  • "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
  • Water Leaks: Identification And Correction (92-9-10)
  • Power Front Door Window Jams In The Up Position (89-10T-24)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
  • Door & Vent Windows - Excessive Efforts To Open (85-4-2)
  • Wind Noise Diagnostic/Repair Procedures (85-8-17)
  • Window Regulator Inoperative Or Handle Loose (85-3-1)
  • Battery Drain - Electrical Component Diagnosis (84-15-9)
  • Noise/Rattle - Roof Support Bows Contact Roof Panel (89-7T-29)
  • Power Door Window Jams - New Regulator (89-20-13)
• Wiper/Washer Systems
  • False Low Wiper Fluid Light - Fluid Dilution (84-21-9)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Wiring - Wire Harness Terminal Repair Kit (99-6-3)
  • Electrical - New Terminal Grease For Service (98-24-6)
  • Electrical Diode Identification And Replacements (96-24-6)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Wire Harness Terminal & Connector Service Kit (89-19-5)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Wiring System Diagnosis Cautions (87-4-8)
  • Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
  • Wiring Diagram Symbols Explanation (85-11-5)
  • Wire Color Code Change (85-4-8)