Technical Service Bulletins

• Accessories Control Systems
  • DTC B1876, B1880, B1915 And/Or B1920 In The ECS Module Due To High Current Aftermarket Devices (06-21-18)
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
• Air Bag, SRS
  • DTC B1876, B1880, B1915 And/Or B1920 In The ECS Module Due To High Current Aftermarket Devices (06-21-18)
• Anti-Theft Systems
  • Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
• Automatic Trans
  • MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
• Auxiliary Emission Control Systems
  • 5.4L 2V - Intermittent Rough Idle - Non-Commanded EGR Flow (05-4-17)
  • General Pcm Programming Procedures (04-24-14)
• Axle Shafts
  • Clunk Or Bump When Starting From A Stop (05-26-10)
• Body Electrical
  • UPFITTER Bulletin - Online Access To Ford Wiring Diagrams And Workshop Manuals (Q-118R1)
  • No Crank / Starter Terminal Fatigue (06-19-14)
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
  • Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
  • UPFITTER Bulletin - Guidelines For Modifying Ford Light Truck Wheelbases (Q-18R5)
  • UPFITTER Bulletin - 125°C Wiring Requirements Revision For Ford Truck Quality Program Guidelines Book (Q-94)
• Body Interior
  • DTC B1876, B1880, B1915 And/Or B1920 In The ECS Module Due To High Current Aftermarket Devices (06-21-18)
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
• Brakes Control Systems
  • Brake Pedal Kickback Or Grabbing (99-25-8)
• Charging Systems
  • Stuck High Voltage Charge Cord Information Sheet (G0000127)
  • UPFITTER Bulletin - Online Access To Ford Wiring Diagrams And Workshop Manuals (Q-118R1)
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
  • UPFITTER Bulletin - 125°C Wiring Requirements Revision For Ford Truck Quality Program Guidelines Book (Q-94)
• Cooling System (Mechanical)
  • All Chain Driven Water Pumps (TT003-13)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
  • Diesel Coolant Maintenance - Service Tips (09-8-5)
  • Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
• Cruise Control Systems
  • Speed Control Diagnostics - W/O SCP (06-8-5)
• Differentials & Drive Axles
  • Clunk Or Bump When Starting From A Stop (05-26-10)
• Driveshaft & Universal Joints
  • Clunk Or Bump When Starting From A Stop (05-26-10)
  • UPFITTER Bulletin - Guidelines For Modifying Ford Light Truck Wheelbases (Q-18R5)
  • UPFITTER Bulletin - Driveshaft Corrosion On E-Series Chassis (Q-82)
• Engine Control Systems
  • WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
  • Alternative Fuel Vehicle - Compressed Natural Gas Fuel Tank Inspection (05-5-6)
  • 5.4L 2V - Intermittent Rough Idle - Non-Commanded EGR Flow (05-4-17)
  • General Pcm Programming Procedures (04-24-14)
• Entertainment Systems
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
• Exhaust
  • Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
  • Stainless Steel Exhaust Studs - 5.4L And 6.8L 2V Engines (09-22-8)
  • UPFITTER Bulletin - Guidelines For Modifying Ford Light Truck Wheelbases (Q-18R5)
• Exterior Body Panels
  • Alternative Fuel Vehicle - Compressed Natural Gas Fuel Tank Inspection (05-5-6)
  • UPFITTER Bulletin - Guidelines For Modifying Ford Light Truck Wheelbases (Q-18R5)
• Exterior Lights
  • Adding Additional Bulbs To Turn Indicator Or Hazard Flasher Circuits - Service Tips (06-17-7)
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
• Frames, Subframes & Crossmembers
  • Spring Tower Weld Repair And Replacement Procedure (05-22-16)
  • Chassis Component Torque Update For E-Coated Frames (04-8-4)
  • UPFITTER Bulletin - Guidelines For Modifying Ford Light Truck Wheelbases (Q-18R5)
• Front Suspension
  • Spring Tower Weld Repair And Replacement Procedure (05-22-16)
  • Chassis Component Torque Update For E-Coated Frames (04-8-4)
• Fuel System
  • Alternative Fuel Vehicle - Compressed Natural Gas Fuel Tank Inspection (05-5-6)
• Fuses & Circuit Breakers
  • UPFITTER Bulletin - Online Access To Ford Wiring Diagrams And Workshop Manuals (Q-118R1)
  • No Crank / Starter Terminal Fatigue (06-19-14)
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
  • Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
  • UPFITTER Bulletin - 125°C Wiring Requirements Revision For Ford Truck Quality Program Guidelines Book (Q-94)
• Gauges & Instrument Panels
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
• HVAC Control Systems
  • Blower Motor Inoperable Or Only Functions On One Speed (11-11-21)
  • Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
• Ignition System
  • 4.6L 2V, 5.4L 2V, Or 6.8L 2V - Spark Plug Thread Repair Procedure - Not Covered Under New Vehicle Limited Warranty (07-21-2)
  • WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
• Interior/Exterior Trim
  • UPFITTER Bulletin - Recommended Practices And Processes For Vehicle Modifications Requiring Seat/Seat Restraint System Removal/Assembly (Including Recommendations To Avoid Introduction Of External Contaminants/Debris During Vehicle Modification) (Q-192)
• Lubrication System
  • 7.3L Or 6.0L - Oil Pan Corrosion (05-20-3)
• Manual Steering
  • MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
  • Chassis Component Torque Update For E-Coated Frames (04-8-4)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • 4.6L 2V, 5.4L 2V, Or 6.8L 2V - Spark Plug Thread Repair Procedure - Not Covered Under New Vehicle Limited Warranty (07-21-2)
  • Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
  • 7.3L Or 6.0L - Oil Pan Corrosion (05-20-3)
  • Chassis Component Torque Update For E-Coated Frames (04-8-4)
• Mechanical - Hydraulic
  • UPFITTER Bulletin - Frame Modifications And Brake Line Integrity (Q-219)
  • Brake Pedal Kickback Or Grabbing (99-25-8)
  • UPFITTER Bulletin - Guidelines For Modifying Ford Light Truck Wheelbases (Q-18R5)
• Mirrors
  • Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
  • Ford Interior Mirror Job Aid (G0000001)
• Parking Brake System
  • UPFITTER Bulletin - Guidelines For Modifying Ford Light Truck Wheelbases (Q-18R5)
• Passive Restraints
  • UPFITTER Bulletin - Recommended Practices And Processes For Vehicle Modifications Requiring Seat/Seat Restraint System Removal/Assembly (Including Recommendations To Avoid Introduction Of External Contaminants/Debris During Vehicle Modification) (Q-192)
  • Safety Belt Retraction Speed (05-16-11)
• Rear Suspension
  • Cutaway And Strip Chassis Vehicles - Rear Axle/Spring Spacer (07-14-3)
  • Chassis Component Torque Update For E-Coated Frames (04-8-4)
• Restraints Control Systems
  • DTC B1876, B1880, B1915 And/Or B1920 In The ECS Module Due To High Current Aftermarket Devices (06-21-18)
• Seats
  • UPFITTER Bulletin - Recommended Practices And Processes For Vehicle Modifications Requiring Seat/Seat Restraint System Removal/Assembly (Including Recommendations To Avoid Introduction Of External Contaminants/Debris During Vehicle Modification) (Q-192)
  • Safety Belt Retraction Speed (05-16-11)
• Starter
  • Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
  • No Crank / Starter Terminal Fatigue (06-19-14)
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
• Steering Column
  • Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
• Steering Control Systems
  • MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
• Steering Gear
  • MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
  • Chassis Component Torque Update For E-Coated Frames (04-8-4)
• Steering Linkage
  • Chassis Component Torque Update For E-Coated Frames (04-8-4)
• System
  • 4.6L 2V, 5.4L 2V, Or 6.8L 2V - Spark Plug Thread Repair Procedure - Not Covered Under New Vehicle Limited Warranty (07-21-2)
  • No Crank / Starter Terminal Fatigue (06-19-14)
  • WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
  • Alternative Fuel Vehicle - Compressed Natural Gas Fuel Tank Inspection (05-5-6)
  • 5.4L 2V - Intermittent Rough Idle - Non-Commanded EGR Flow (05-4-17)
  • General Pcm Programming Procedures (04-24-14)
• Wheels & Tire System
  • Vibration/Harshness Above 45 Mph (72 Km/H) After Tire Balance (05-24-8)
  • UPFITTER Bulletin - E-Series And F-Series 4-Corner Weight Analysis Update (Q-128)
  • Chassis Component Torque Update For E-Coated Frames (04-8-4)
• Wiring Diagrams
  • UPFITTER Bulletin - Online Access To Ford Wiring Diagrams And Workshop Manuals (Q-118R1)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • UPFITTER Bulletin - Online Access To Ford Wiring Diagrams And Workshop Manuals (Q-118R1)
  • No Crank / Starter Terminal Fatigue (06-19-14)
  • UPFITTER Bulletin - General Electrical Practices (Q-130)
  • Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
  • UPFITTER Bulletin - Guidelines For Modifying Ford Light Truck Wheelbases (Q-18R5)
  • UPFITTER Bulletin - 125°C Wiring Requirements Revision For Ford Truck Quality Program Guidelines Book (Q-94)