Technical Service Bulletins

• Accessories Control Systems
  • Various Vehicles - Module Reprogramming (G0000150)
  • Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
  • Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
  • Sync - Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (10-8-4)
• Anti-Theft Systems
  • Passive Anti Theft System(Pats) Key Programming (G0000156)
  • Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
  • Rear Door Lock Inoperative - Built On Or Before 10/15/2009 (09-23-4)
• Automatic Trans
  • 4F27E Transmission - Symptoms Of Direct Clutch Failure - 2-3 Or 2-4 Upshift Flare - Lack Of 3RD And/Or 4TH Gear - DTCS P0733, P0734, P0751 And/Or P0972 (14-0002)
  • Whine/Howl Or Groan Type Noise With Vehicle In Motion - Intermediate Shaft Bearing (13-4-24)
  • Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
  • Warble Type Noise On Acceleration - Front Drive Intermediate Shaft Bearing - Built Between 10/1/2009 - 10/31/2009 (09-26-3)
• Auxiliary Emission Control Systems
  • Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
• Axle Shafts
  • Whine/Howl Or Groan Type Noise With Vehicle In Motion - Intermediate Shaft Bearing (13-4-24)
  • Warble Type Noise On Acceleration - Front Drive Intermediate Shaft Bearing - Built Between 10/1/2009 - 10/31/2009 (09-26-3)
• Body Interior
  • Various Vehicles - Module Reprogramming (G0000150)
  • Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
  • Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
  • Sync - Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (10-8-4)
• Charging Systems
  • Stuck High Voltage Charge Cord Information Sheet (G0000127)
• Clutch
  • Squeak Noise When Applying And/Or Releasing Clutch Pedal (09-22-3)
• Communication Devices
  • Sync Programming Gen 1, Gen 2, Sync 3 (24-7088)
  • Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
  • Sync - Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (10-8-4)
  • Sync System Defaults To Or Stays In Privacy Mode, Multiple Vehicle Lines (10-2-8)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
• Differentials & Drive Axles
  • Whine/Howl Or Groan Type Noise With Vehicle In Motion - Intermediate Shaft Bearing (13-4-24)
  • Warble Type Noise On Acceleration - Front Drive Intermediate Shaft Bearing - Built Between 10/1/2009 - 10/31/2009 (09-26-3)
• Driveshaft & Universal Joints
  • Warble Type Noise On Acceleration - Front Drive Intermediate Shaft Bearing - Built Between 10/1/2009 - 10/31/2009 (09-26-3)
• Engine Control Systems
  • Sync Programming Gen 1, Gen 2, Sync 3 (24-7088)
  • Various Vehicles - Module Reprogramming (G0000150)
  • Diagnostic Trouble Code (DTC) P1635 (19-7008)
  • DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
  • Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
  • Ticking Noise At Idle - Fuel Rail - Built On Or Before 12/23/2009 (10-9-3)
• Entertainment Systems
  • Fm Radio Reception/Sound Quality Changes While Driving Or Satellite Radio Signal Bleed Through When Using Audio System In Aux Mode (10-13-3)
• Exhaust
  • Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
• Exterior Body Panels
  • Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
• Front Suspension
  • Click/Pop Noise From Front End While Turning Or Going Over Bumps (10-8-5)
• Fuel System
  • DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
  • Ticking Noise At Idle - Fuel Rail - Built On Or Before 12/23/2009 (10-9-3)
• Ignition Switch/Steering Lock
  • Ignition Key Binding In Ignition Cylinder When Turning To Start Position Only - Built On Or Before 8/3/2009 (09-19-15)
• Infotainment
  • Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
• Interior/Exterior Trim
  • Various Vehicles - Running Board Concern Analysis (G0000073)
  • Front Center Console Lid Contacting Driver Seat Back (10-2-12)
• Manual Trans
  • Whine/Howl Or Groan Type Noise With Vehicle In Motion - Intermediate Shaft Bearing (13-4-24)
• Mechanical
  • 2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear MAINSEAL Kit Tool Usage (SSM 47632)
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Engine Vibration At Idle (11-3-24)
  • DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
  • Ticking Noise At Idle - Fuel Rail - Built On Or Before 12/23/2009 (10-9-3)
• Mirrors
  • Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
  • Ford Interior Mirror Job Aid (G0000001)
• Paint & Coatings
  • Paint Degradation/Road Abrasion (10-15-6)
• Parking Brake System
  • Squeak/Creak Noise While Driving Over Bumps - Park Brake Cable Contact With Routing Eyelets (10-24-6)
  • Squeak/Creak Noise While Driving Over Bumps - Park Brake Cable Contact With Routing Eyelets (10-1-4)
• Passive Restraints
  • Front Center Console Lid Contacting Driver Seat Back (10-2-12)
• Procedures
  • 2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear MAINSEAL Kit Tool Usage (SSM 47632)
• Seats
  • Front Center Console Lid Contacting Driver Seat Back (10-2-12)
• Steering Column
  • Leather Wrapped Steering Wheel - Leather Coming Loose (09-24-6)
• Suspension Control Systems
  • Click/Pop Noise From Front End While Turning Or Going Over Bumps (10-8-5)
• System
  • DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
  • Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
  • Ticking Noise At Idle - Fuel Rail - Built On Or Before 12/23/2009 (10-9-3)
• Transmission Control Systems
  • 4F27E Transmission - Symptoms Of Direct Clutch Failure - 2-3 Or 2-4 Upshift Flare - Lack Of 3RD And/Or 4TH Gear - DTCS P0733, P0734, P0751 And/Or P0972 (14-0002)
  • Intermittent No Crank/No Start - DTC P1260 - Transmission Shift Flare On Initial 2-3 Shift After A Re-Start (10-21-8)
• Window Motors & Regulators
  • Various Vehicles - Glass Concern Analysis (G0000179)
  • Front Door Glass Top Run Distorted, Folded Or Torn (10-9-1)
  • Door Glass - Slow Close/Binds When Going Up/WINDNOISE Or Top Window Run Folded/Loose (09-22-9)