Technical Service Bulletins

• Accessories Control Systems
  • Various Vehicles - Module Reprogramming (G0000150)
  • 2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCS) U2100 And/Or U2101- Programmable Module Installation (PMI) Procedure (SSM 47843)
  • Sync Gen 1 And Gen 2 Vehicle Health Report Service Ending - Disabling Automatic Updates (18-7018)
  • Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
  • Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
  • Hybrid Only - Wrench Lamp And DTC U3000:46 - Built On Or Before 11/30/2009 (11-7-27)
  • Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False DTC B11D6:15 With Intermittent Faults - Built On Or Before 5/21/2010 (10-20-6)
  • Hybrid Only - Instrument Cluster Display - Default To Enlighten Mode After Ignition Key Cycle - Built On Or Before 3/22/2010 (10-15-5)
  • Sync Functions Inoperative, DTC U3000-41,U0485, Or U0100, And/Or Battery Draw With Accessory Protocol Interface Module Connected (09-14-3)
  • Speedometer Inoperative - Built On Or Before 6/25/2009 (09-13-9)
• Anti-Lock Brakes
  • Change In Brake Pedal Travel And/Or Abs Control/Brake Warning Lamp - DTC C0048 - Vehicles Built On Or Before 10/17/2009 (09-22-11)
  • Change In Brake Pedal Travel And/Or Electronic Stability Control/Brake Warning Lamp - DTC C1011:1C, C1011:1F Or C100A:64 - Built On Or Before 5/15/2009 (09-12-13)
• Anti-Theft Systems
  • Passive Anti Theft System(Pats) Key Programming (G0000156)
• Auxiliary Emission Control Systems
  • Hybrid - Illuminated Mil With DTCS P0030 And/Or P0130 (16-0143)
  • Mil Lamp On With DTCS P144A, P2196, P2198 And/Or P1A0C - Built On Or Before 3/4/2011 (12-3-19)
  • Hybrid Only - Wrench Light With DTC P0A7C - Built On Or Before 9/09/2010 (11-7-31)
  • Hybrid Only - Wrench Lamp With DTC P0C2F, Reduction In Power Or High Idle Speed (11-5-2)
  • 6F35 Transmission - 5TH Gear Only - After Using Grade Assist On Steep Downgrade - DTC Grouping P072F, P073A, P073B Or P07A8, P07A9, P07AA, P0731, P0732 (10-12-12)
  • 3.0L - Rpm Fluctuations During Acceleration Immediately Following A Cold Start - Enhancement For DTC P061B - Built On Or Before 12/7/2009 (10-4-11)
  • Service Engine Soon Lamp Illuminated - Diagnostic Trouble Code (DTC) P0111 - Intake Air Temperature Sensor Range/Performance (10-4-1)
  • Hybrid Only - DTCS P0442, P0456 Or P1450 - Built On Or Before 4/6/2009 (10-1-3)
  • DTC P0400 EGR Flow (09-19-13)
• Axle Shafts
  • Single Wheel Stud Fracture On Rear Hub (12-2-9)
  • Front Constant Velocity (CV) Boot Kits Available - Service Tip (10-4-12)
• Battery Management Systems
  • High Voltage Battery Charging Process (20-7073)
  • HV Battery Charging Process For FHEV Vehicles (18-7070)
• Body Electrical
  • Hybrid - DTC P0A0A And Stop Safely Now Message - Built On Or Before 12/31/2010 (12-5-14)
• Body Interior
  • Various Vehicles - Module Reprogramming (G0000150)
  • 2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCS) U2100 And/Or U2101- Programmable Module Installation (PMI) Procedure (SSM 47843)
  • Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
  • Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
  • Hybrid Only - Wrench Lamp And DTC U3000:46 - Built On Or Before 11/30/2009 (11-7-27)
  • Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False DTC B11D6:15 With Intermittent Faults - Built On Or Before 5/21/2010 (10-20-6)
  • Sync Functions Inoperative, DTC U3000-41,U0485, Or U0100, And/Or Battery Draw With Accessory Protocol Interface Module Connected (09-14-3)
  • Speedometer Inoperative - Built On Or Before 6/25/2009 (09-13-9)
• Brakes Control Systems
  • Hybrid - Red Brake Lamp On - DTC C1015:64 - Built On Or Before 8/29/2011 (11-11-10)
  • Change In Brake Pedal Travel And/Or Abs Control/Brake Warning Lamp - DTC C0048 - Vehicles Built On Or Before 10/17/2009 (09-22-11)
  • Change In Brake Pedal Travel And/Or Electronic Stability Control/Brake Warning Lamp - DTC C1011:1C, C1011:1F Or C100A:64 - Built On Or Before 5/15/2009 (09-12-13)
• Charging Systems
  • Plug-In Hybrids And Electric Vehicles - Customer Defined Value Charge Concerns (G0000132)
  • Stuck High Voltage Charge Cord Information Sheet (G0000127)
• Collision/Avoidance
  • Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
  • Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False Blockage And/Or Diagnostic Trouble Code (DTC) - U3000 - Built On Or Before 3/29/2011 (11-8-3)
  • Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False DTC B11D6:15 With Intermittent Faults - Built On Or Before 5/21/2010 (10-20-6)
• Communication Devices
  • Sync Programming Gen 1, Gen 2, Sync 3 (24-7088)
  • Sync Gen 1 And Gen 2 Vehicle Health Report Service Ending - Disabling Automatic Updates (18-7018)
  • SIRIUS Radio With Navigation - Various Functionality Concerns - Built On Or Before 3/8/2010 (11-11-16)
  • Sync - Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (10-8-3)
  • Sync System Defaults To Or Stays In Privacy Mode, Multiple Vehicle Lines (10-2-8)
  • Sync Functions Inoperative, DTC U3000-41,U0485, Or U0100, And/Or Battery Draw With Accessory Protocol Interface Module Connected (09-14-3)
• Cooling Fan
  • Malfunction Indicator Lamp (Mil) With Diagnostic Trouble Codes (DTCS) P1285, P1299, P0128, P0301, P0302, P0303, P0304, P0316 (11-8-17)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
• Cruise Control Systems
  • Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
• Differentials & Drive Axles
  • Front Constant Velocity (CV) Boot Kits Available - Service Tip (10-4-12)
• Driveshaft & Universal Joints
  • Front Constant Velocity (CV) Boot Kits Available - Service Tip (10-4-12)
• Engine Control Systems
  • Sync Programming Gen 1, Gen 2, Sync 3 (24-7088)
  • Various Vehicles - Module Reprogramming (G0000150)
  • Reduced Electric Vehicle Operation (20-2142)
  • 2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCS) U2100 And/Or U2101- Programmable Module Installation (PMI) Procedure (SSM 47843)
  • Diagnostic Trouble Code (DTC) P1635 (19-7008)
  • Hybrid - Illuminated Mil With DTCS P0030 And/Or P0130 (16-0143)
  • Easy Fuel CAPLESS - Concerns With Fuel Nozzle Insertion Or Removal (14-0132)
  • Hybrid - DTC P0A0A And Stop Safely Now Message - Built On Or Before 12/31/2010 (12-5-14)
  • Mil Lamp On With DTCS P144A, P2196, P2198 And/Or P1A0C - Built On Or Before 3/4/2011 (12-3-19)
  • Hybrid - Possible Misdiagnosis Of Start/Stall With Or Without DTCS P0A7D, P1A0C (11-11-8)
  • Malfunction Indicator Lamp (Mil) With Diagnostic Trouble Codes (DTCS) P1285, P1299, P0128, P0301, P0302, P0303, P0304, P0316 (11-8-17)
  • Hybrid Only - Wrench Light With DTC P0A7C - Built On Or Before 9/09/2010 (11-7-31)
  • Hybrid Only - Wrench Lamp And DTC U3000:46 - Built On Or Before 11/30/2009 (11-7-27)
  • Hybrid Only - Wrench Lamp With DTC P0C2F, Reduction In Power Or High Idle Speed (11-5-2)
  • 2.5L - DTCS P0016 And P052A/B - Possible Hard To Start And/Or Rough Idle Concern (11-2-10)
  • DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
  • 6F35 Transmission - 5TH Gear Only - After Using Grade Assist On Steep Downgrade - DTC Grouping P072F, P073A, P073B Or P07A8, P07A9, P07AA, P0731, P0732 (10-12-12)
  • 3.0L - Rpm Fluctuations During Acceleration Immediately Following A Cold Start - Enhancement For DTC P061B - Built On Or Before 12/7/2009 (10-4-11)
  • Service Engine Soon Lamp Illuminated - Diagnostic Trouble Code (DTC) P0111 - Intake Air Temperature Sensor Range/Performance (10-4-1)
  • Hybrid Only - DTCS P0442, P0456 Or P1450 - Built On Or Before 4/6/2009 (10-1-3)
  • Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Code (DTC) P2135 - Built Between 6/22/2009 - 10/15/2009 (09-23-5)
  • DTC P0400 EGR Flow (09-19-13)
• Entertainment Systems
  • Sync Gen 1 And Gen 2 Vehicle Health Report Service Ending - Disabling Automatic Updates (18-7018)
  • Fm Radio Reception/Sound Quality Changes While Driving Or Satellite Radio Signal Bleed Through When Using Audio System In Aux Mode (10-13-3)
• Exhaust
  • Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
• Exterior Body Panels
  • Easy Fuel CAPLESS - Concerns With Fuel Nozzle Insertion Or Removal (14-0132)
  • Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
• Fuel System
  • Easy Fuel CAPLESS - Concerns With Fuel Nozzle Insertion Or Removal (14-0132)
  • DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
  • Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Code (DTC) P2135 - Built Between 6/22/2009 - 10/15/2009 (09-23-5)
• Gauges & Instrument Panels
  • Hybrid Only - Instrument Cluster Display - Default To Enlighten Mode After Ignition Key Cycle - Built On Or Before 3/22/2010 (10-15-5)
  • Speedometer Inoperative - Built On Or Before 6/25/2009 (09-13-9)
• HVAC Control Systems
  • 2.5L Heater Core Noise (12-1-19)
  • Intermittent A/C Operations During Extended Drive (10-22-1)
  • Dual Automatic Temperature Control (DATC) - Pass - Temperature Blend Door Stuck In Hot Mode - Built Before 6/1/2009 (09-17-4)
• Infotainment
  • Sync Gen 1 And Gen 2 Vehicle Health Report Service Ending - Disabling Automatic Updates (18-7018)
  • Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
  • SIRIUS Radio With Navigation - Various Functionality Concerns - Built On Or Before 3/8/2010 (11-11-16)
• Interior/Exterior Trim
  • Various Vehicles - Running Board Concern Analysis (G0000073)
  • Loose Rear Window Glass Molding - Built On Or Before 6/7/2011 (11-7-17)
  • Steering Column Opening Trim Panel Reinforcement Loose (10-12-13)
  • Passenger-Side - Instrument Panel Loose Appearance Applique - Built On Or Before 9/9/2009 (09-22-10)
• Lubrication System
  • 2.5L Engine - Underbody Cover Oil Drain Access Door Out Of Position, Loose, Damaged Or Missing - Built On Or Before 10/22/2009 (10-4-10)
• Manual Steering
  • 3.5L Engine Steering Grunt Noise - Built From 8/1/2009 To 4/28/2010 (10-23-4)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • 2.5L - DTCS P0016 And P052A/B - Possible Hard To Start And/Or Rough Idle Concern (11-2-10)
  • DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
  • 2.5L Engine - Underbody Cover Oil Drain Access Door Out Of Position, Loose, Damaged Or Missing - Built On Or Before 10/22/2009 (10-4-10)
  • Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Code (DTC) P2135 - Built Between 6/22/2009 - 10/15/2009 (09-23-5)
• Mechanical - Hydraulic
  • Single Wheel Stud Fracture On Rear Hub (12-2-9)
  • Hybrid - Red Brake Lamp On - DTC C1015:64 - Built On Or Before 8/29/2011 (11-11-10)
  • Change In Brake Pedal Travel And/Or Abs Control/Brake Warning Lamp - DTC C0048 - Vehicles Built On Or Before 10/17/2009 (09-22-11)
  • Change In Brake Pedal Travel And/Or Electronic Stability Control/Brake Warning Lamp - DTC C1011:1C, C1011:1F Or C100A:64 - Built On Or Before 5/15/2009 (09-12-13)
• Mirrors
  • Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
  • Ford Interior Mirror Job Aid (G0000001)
  • Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False DTC B11D6:15 With Intermittent Faults - Built On Or Before 5/21/2010 (10-20-6)
• Starter
  • High Voltage Battery Charging Process (20-7073)
  • Hybrid - Possible Misdiagnosis Of Start/Stall With Or Without DTCS P0A7D, P1A0C (11-11-8)
  • Hybrid Only - Wrench Lamp And DTC U3000:46 - Built On Or Before 11/30/2009 (11-7-27)
  • Sync Functions Inoperative, DTC U3000-41,U0485, Or U0100, And/Or Battery Draw With Accessory Protocol Interface Module Connected (09-14-3)
• Steering Control Systems
  • Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
  • 3.5L Engine Steering Grunt Noise - Built From 8/1/2009 To 4/28/2010 (10-23-4)
• Steering Gear
  • 3.5L Engine Steering Grunt Noise - Built From 8/1/2009 To 4/28/2010 (10-23-4)
• Sun Roof/T-Top/Convertible Top
  • Roof Opening Panel - Water Leaks - Water Collecting At Roof Center Console - Built On Or Before 4/30/2009 (10-10-2)
• System
  • Hybrid - Illuminated Mil With DTCS P0030 And/Or P0130 (16-0143)
  • Easy Fuel CAPLESS - Concerns With Fuel Nozzle Insertion Or Removal (14-0132)
  • Hybrid - DTC P0A0A And Stop Safely Now Message - Built On Or Before 12/31/2010 (12-5-14)
  • Mil Lamp On With DTCS P144A, P2196, P2198 And/Or P1A0C - Built On Or Before 3/4/2011 (12-3-19)
  • Hybrid - Possible Misdiagnosis Of Start/Stall With Or Without DTCS P0A7D, P1A0C (11-11-8)
  • Malfunction Indicator Lamp (Mil) With Diagnostic Trouble Codes (DTCS) P1285, P1299, P0128, P0301, P0302, P0303, P0304, P0316 (11-8-17)
  • Hybrid Only - Wrench Light With DTC P0A7C - Built On Or Before 9/09/2010 (11-7-31)
  • Hybrid Only - Wrench Lamp And DTC U3000:46 - Built On Or Before 11/30/2009 (11-7-27)
  • Hybrid Only - Wrench Lamp With DTC P0C2F, Reduction In Power Or High Idle Speed (11-5-2)
  • 2.5L - DTCS P0016 And P052A/B - Possible Hard To Start And/Or Rough Idle Concern (11-2-10)
  • DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
  • 6F35 Transmission - 5TH Gear Only - After Using Grade Assist On Steep Downgrade - DTC Grouping P072F, P073A, P073B Or P07A8, P07A9, P07AA, P0731, P0732 (10-12-12)
  • 3.0L - Rpm Fluctuations During Acceleration Immediately Following A Cold Start - Enhancement For DTC P061B - Built On Or Before 12/7/2009 (10-4-11)
  • Service Engine Soon Lamp Illuminated - Diagnostic Trouble Code (DTC) P0111 - Intake Air Temperature Sensor Range/Performance (10-4-1)
  • Hybrid Only - DTCS P0442, P0456 Or P1450 - Built On Or Before 4/6/2009 (10-1-3)
  • Malfunction Indicator Lamp (Mil) On With Diagnostic Trouble Code (DTC) P2135 - Built Between 6/22/2009 - 10/15/2009 (09-23-5)
  • DTC P0400 EGR Flow (09-19-13)
• Transmission Control Systems
  • 2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCS) U2100 And/Or U2101- Programmable Module Installation (PMI) Procedure (SSM 47843)
  • 6F35 Transmission - 5TH Gear Only - After Using Grade Assist On Steep Downgrade - DTC Grouping P072F, P073A, P073B Or P07A8, P07A9, P07AA, P0731, P0732 (10-12-12)
• Wheel Hubs
  • Single Wheel Stud Fracture On Rear Hub (12-2-9)
• Wheels & Tire System
  • Single Wheel Stud Fracture On Rear Hub (12-2-9)
• Window Motors & Regulators
  • Various Vehicles - Glass Concern Analysis (G0000179)
  • Loose Rear Window Glass Molding - Built On Or Before 6/7/2011 (11-7-17)
  • External Scratches On Front Door Window Glass - Built On Or Before 12/15/2009 (10-15-7)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Hybrid - DTC P0A0A And Stop Safely Now Message - Built On Or Before 12/31/2010 (12-5-14)