Section 3015 (Climate Control System - General Information)
WARNING: This page is about a different car, the 2016 Ford F-150. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description And Operation
- Climate Control System - Vehicles With: Dual Automatic Temperature Control (DATC) - Component Location
- Climate Control System - Vehicles With: Dual Automatic Temperature Control (DATC) - Overview
- Climate Control System - Vehicles With: Dual Automatic Temperature Control (DATC) - System Operation and Component Description
- System Operation
- System Diagram
- Network Message Chart
- The Refrigerant Cycle
- Control System Logic
- A/C Request
- Heating and Ventilation
- Cabin Heater Coolant Pump
- Air Handling
- Auto
- Off
- Max A/C
- Panel
- Panel/Floor
- Floor
- Floor/Defrost
- Max Defrost
- MyTemp
- Remote Start - Message Center Set To Auto
- Remote Start - Message Center Set To Last User Settings
- Component Description
- FCIM - Dual Automatic Temperature Control (DATC)
- Ambient Air Temperature (AAT) Sensor
- Blower Motor Control Module
- Compressor Clutch Assembly
- Evaporator Core
- Heater Core
- Climate Control Housing
- Air Distribution Door Actuator
- Air Inlet Door Actuator
- Driver Side Temperature Door Actuator
- Passenger Side Temperature Door Actuator
- Air Conditioning (A/C) Pressure Transducer
- In-Vehicle Temperature And Humidity Sensor
- Autolamp-Sunload Sensor
- Evaporator Temperature Sensor
- Air Discharge Temperature Sensors
- Fixed Displacement A/C Compressor
- Condenser
- Receiver Drier
- Thermostatic Expansion Valve (TXV)
- Service Gauge Port Valves
- Refrigerant System Dye
- System Operation
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC) - Component Location
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC) - Overview
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC) - System Operation and Component Description
- System Operation
- Component Description
- FCIM - Electronic Manual Temperature Control (EMTC)
- Ambient Air Temperature (AAT) Sensor
- Blower Motor Control Module
- Compressor Clutch Assembly
- Evaporator Core
- Heater Core
- Climate Control Housing
- In-Vehicle Temperature And Humidity Sensor
- Air Discharge Temperature Sensors
- Air Distribution Door Actuator
- Air Inlet Door Actuator
- Temperature Door Actuator
- Evaporator Temperature Sensor
- Air Conditioning (A/C) Pressure Transducer
- Fixed Displacement A/C Compressor
- Condenser
- Receiver Drier
- Thermostatic Expansion Valve (TXV)
- Service Gauge Port Valves
- Refrigerant System Dye
- Diagnosis And Testing
- Climate Control System - Vehicles With: Dual Automatic Temperature Control (DATC)
- DTC Charts
- Symptom Charts
- Pinpoint Test(s)
- Pinpoint Test A : P0532, P0533
- Pinpoint Test B : P0645
- Pinpoint Test C : Unable To Duplicate The Customer Concern And No Diagnostic Trouble Codes (DTCS) Present
- Pinpoint Test D : The Air Inlet Door Is Inoperative
- Pinpoint Test E : Incorrect Or Erratic Direction Of Airflow From Outlets
- Pinpoint Test F : Insufficient, Erratic Or No Heat
- Pinpoint Test G : The A/C (Air Conditioning) Is Inoperative
- Pinpoint Test H : The A/C (Air Conditioning) Is Always On - A/C (Air Conditioning) Mode Always Commanded On
- Pinpoint Test I : The Temperature Control Is Inoperative Or Does Not Operate Correctly - Driver Side
- Pinpoint Test J : The Temperature Control Is Inoperative Or Does Not Operate Correctly - Passenger Side
- Pinpoint Test K : The Blower Motor Is Inoperative
- Pinpoint Test L : The Blower Motor Does Not Operate Correctly
- Pinpoint Test M : Air Discharge Temperature Sensor Circuit Faults
- Pinpoint Test N : B105A:12, B105A:14, B1A61:11, B1A61:15, B1A69:12, B1A69:14
- Pinpoint Test O : B1A63:11, B1A63:15, B1A64:11, B1A64:15
- Pinpoint Test P : B1B71:11, B1B71:15
- Pinpoint Test Q : C1B14:11, C1B14:12
- Pinpoint Test R : P193E
- Pinpoint Test S : Insufficient Heat In Auto Start-Stop Mode Only
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC)
- DTC Charts
- Symptom Charts
- Pinpoint Test(s)
- Pinpoint Test A : P0532, P0533
- Pinpoint Test B : P0645
- Pinpoint Test C : Unable To Duplicate The Customer Concern And No Diagnostic Trouble Codes (DTCS) Present
- Pinpoint Test D : The Air Inlet Door Is Inoperative
- Pinpoint Test E : Incorrect Or Erratic Direction Of Airflow From Outlets
- Pinpoint Test F : Insufficient, Erratic Or No Heat
- Pinpoint Test G : The A/C (Air Conditioning) Is Inoperative
- Pinpoint Test H : The A/C (Air Conditioning) Is Always On - A/C (Air Conditioning) Mode Always Commanded On
- Pinpoint Test I : The Temperature Control Is Inoperative Or Does Not Operate Correctly
- Pinpoint Test J : The Blower Motor Is Inoperative
- Pinpoint Test K : The Blower Motor Does Not Operate Correctly
- Pinpoint Test L : B1B71:11, B1B71:15
- Pinpoint Test M : C1B14:11, C1B14:12
- Pinpoint Test N : P193E
- Pinpoint Test O : Insufficient Heat In Auto Start-Stop Mode Only
- Pinpoint Test P : B105A:12, B105A:14, B1A61:11, B1A61:15, B1A69:12, B1A69:14
- Pinpoint Test Q : Air Discharge Temperature Sensor Circuit Faults
- Climate Control System - Vehicles With: Dual Automatic Temperature Control (DATC)
- General Procedures
- Air Conditioning (A/C) Clutch Air Gap Adjustment
- Air Conditioning (A/C) Clutch and Air Conditioning (A/C) Clutch Field Coil
- Air Conditioning (A/C) Compressor Leak Detection
- Air Conditioning (A/C) Odor Treatment
- Air Conditioning (A/C) System Flushing
- Air Conditioning (A/C) System Recovery, Evacuation and Charging
- Condenser Core Leak Check
- Electronic Leak Detection
- Evaporator Core Leak Check
- Fluorescent Dye Leak Detection
- Heater Core Leak Check
- Refrigerant System Tests - 2.7L EcoBoost (238kW/324PS)
- Refrigerant System Tests - 3.5L EcoBoost (272kW/370PS)
- Refrigerant System Tests - 3.5L Duratec (209kW/284PS)
- Refrigerant System Tests - 5.0L 32V Ti-VCT
- Refrigerant Identification Testing
- Refrigerant Oil Adding
- Removal And Installation
- Air Conditioning (A/C) Clutch and Air Conditioning (A/C) Clutch Field Coil
- Air Conditioning (A/C) Compressor - 2.7L EcoBoost (238kW/324PS)
- Air Conditioning (A/C) Compressor - 3.5L EcoBoost (272kW/370PS)
- Air Conditioning (A/C) Compressor - 3.5L Duratec (209kW/284PS)
- Air Conditioning (A/C) Compressor - 5.0L 32V Ti-VCT
- Air Conditioning (A/C) Compressor Inlet Line - 2.7L EcoBoost (238kW/324PS)
- Air Conditioning (A/C) Compressor Inlet Line - 3.5L EcoBoost (272kW/370PS)
- Air Conditioning (A/C) Compressor Inlet Line - 3.5L Duratec (209kW/284PS)
- Air Conditioning (A/C) Compressor Inlet Line - 5.0L 32V Ti-VCT
- Air Conditioning (A/C) Compressor Outlet Line - 2.7L EcoBoost (238kW/324PS)
- Air Conditioning (A/C) Compressor Outlet Line - 3.5L Duratec (209kW/284PS)
- Air Conditioning (A/C) Compressor Outlet Line - 3.5L EcoBoost (272kW/370PS)
- Air Conditioning (A/C) Compressor Outlet Line - 5.0L 32V Ti-VCT
- Air Conditioning (A/C) Pressure Relief Valve
- Air Conditioning (A/C) Pressure Transducer
- Air Distribution Door Actuator
- Air Inlet Door Actuator
- Ambient Air Temperature Sensor
- Blower Motor Control Module
- Cabin Air Filter
- Cabin Heater Coolant Pump - 2.7L EcoBoost (238kW/324PS)
- Center Registers
- Climate Control Housing
- Condenser
- Desiccant Bag
- Driver Side Footwell Air Discharge Temperature Sensor
- Driver Side Register
- Driver Side Register Air Discharge Temperature Sensor
- Driver Side Temperature Door Actuator
- Evaporator
- Evaporator Temperature Sensor
- Heater Core
- Heating, Ventilation and Air Conditioning (HVAC) Control Module
- In-Vehicle Temperature and Humidity Sensor
- Passenger Side Footwell Air Discharge Temperature Sensor
- Passenger Side Register
- Passenger Side Register Air Discharge Temperature Sensor
- Passenger Side Temperature Door Actuator
- Thermostatic Expansion Valve
- Sunload Sensor
- Temperature Door Actuator
- Thermostatic Expansion Valve Manifold and Tube Assembly - 2.7L EcoBoost (238kW/324PS)
- Thermostatic Expansion Valve Manifold and Tube Assembly - 3.5L EcoBoost (272kW/370PS)
- Thermostatic Expansion Valve Manifold and Tube Assembly - 3.5L Duratec (209kW/284PS)
- Thermostatic Expansion Valve Manifold and Tube Assembly - 5.0L 32V Ti-VCT