Section 68 (Engine Cooling System (Diesel)): Specifications
WARNING: This page is about a different car, the 2013 Ford F-550 Super Duty, 2013 Ford F-450 Super Duty, 2013 Ford F-350 Super Duty, and 2013 Ford F-250 Super Duty. However, it is still accessible from the selected car via links, so may be relevant.
MATERIAL
| Item | Specification | Fill Capacity |
|---|---|---|
| Motorcraft® Engine Cooling System Iron Cleaner VC-9 | - | - |
| Motorcraft® Orange Antifreeze/Coolant Concentrated VC-3-B (US); CVC-3-B2 (Canada) |
WSS-M97B44-D | 27.8L (29.4 qt) |
| Motorcraft® Orange Antifreeze/Coolant Prediluted VC-3DIL-B (US); CVC-3DIL-B (Canada) |
WSS-M97B44-D2 | 27.8L (29.4 qt) |
| Motorcraft® Specialty Orange Engine Coolant Revitalizer VC-12 |
- | - |
GENERAL SPECIFICATIONS
| Pressure Tests | |
|---|---|
| Complete cooling system maximum pressure | Use individual reading listed on the pressure relief cap |
| Pressure relief cap | Use individual readings listed on the pressure relief cap |
| Radiator (out of vehicle) | 138 kPa (20 psi) |
| Thermostat Opening Temperatures | |
| Starts to open - (low temperature) | 88-92°C (190-198°F) |
| Fully open - (low temperature) | 100°C (212°F) |
| Starts to open - (high temperature) | 92-95°C (198-203°F) |
| Fully open - (high temperature) | 103°C (217°F) |
TORQUE SPECIFICATIONS
| Description | Nm | lb-ft | lb-in |
|---|---|---|---|
| A/C tube fitting nuts | 15 | - | 133 |
| Battery cable bracket bolts | 12 | - | 106 |
| Block heater | 41 | 30 | - |
| Charge Air Cooler (CAC) bolts | 12 | - | 106 |
| Coolant crossover manifold bolts | 10 | - | 89 |
| Coolant outlet connection bolts | 10 | - | 89 |
| Coolant pump bolts - large bolts | 24 | 18 | - |
| Coolant pump bolts - small bolts | 10 | - | 89 |
| Cooling fan-to-cooling fan clutch nuts | 7 Nm | - | 62 lb-in |
| Cooling fan clutch | 133 Nm | 98 lb-ft | - |
| Cooling fan clutch electrical connector bracket bolt | 24 Nm | 18 lb-ft | - |
| Cooling fan shroud bolts | 7 Nm | - | 62 lb-in |
| Cooling fan stator nuts | 17 Nm | - | 150 lb-in |
| Cylinder block drain plug | 60 | 44 | - |
| Degas bottle bolts | 19 | - | 168 |
| Engine wiring harness-to-coolant crossover bolt | 10 | - | 89 |
| Fuel tube bracket bolts | 10 | - | 89 |
| Grille bracket bolts - lower | 3 | - | 27 |
| Grille bracket bolts - upper | 40 | 30 | - |
| Heater inlet tube bolts | 10 | - | 89 |
| Power steering fluid cooler bolts | 35 | 26 | - |
| Power steering fluid reservoir bolt | 7 | - | 62 |
| Power steering pressure hose bracket screw | 5 | - | 44 |
| Radiator bracket bolts | 35 | 26 | - |
| Radiator bolster bolts | 40 | 30 | - |
| Secondary degas bottle bolts | 7 | - | 62 |
| Secondary radiator bolts | 11 | - | 97 |