Technical Service Bulletins

• A/C Compressor
  • Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
  • Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
  • Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
  • Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
  • New PAG Oil Released (02-01-39-004B)
  • Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
  • J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
  • A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
  • Essential Tool J 43600 ACR 2000 (00-01-38-006)
  • PUREGUARD 2 Operating Alert (73-12-13)
• Accessories & Equipment
  • Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
  • Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
  • Part and Accessory Replacement Policy (04-00-89-011)
• Accessories Control Systems
  • GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
  • Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
  • Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
  • OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
  • HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
  • Security Lamp Illuminated On The IP, Engine Stalls, No Start, DTC B2960 (Security System Sensor Data Incorrect But Valid) Set (Inspect And Repair Cause Of DTC B2960) (01-08-56-004A)
  • No/Hard/Slow Start Noise During Cranking DTC P0338 (00-06-04-014)
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
• Accessory Drive Belts
  • Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
• Air Bag, SRS
  • General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
  • Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
  • Squeak Noise In Steering Column - Sir Module Coil (99-02-35-001)
  • Operating Vehicle With Sir Warning Light Illuminated (83-81-34)
• Anti-Lock Brakes
  • GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
• Anti-Theft Systems
  • Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
  • Key Code Information (99-00-89-011E)
  • Remote Keyless Entry Operational Characteristics (99-08-52-005C)
  • Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
  • Security Lamp Illuminated On The IP, Engine Stalls, No Start, DTC B2960 (Security System Sensor Data Incorrect But Valid) Set (Inspect And Repair Cause Of DTC B2960) (01-08-56-004A)
  • Procedure For Aligning Rear Side Replacement Door (99-08-64-028)
  • Noisy/Binding Front Doors/Hard To/Won't Stay Open (99-08-64-024)
  • UPFITTER Bulletin - PASSLOCK Disablement For Vehicle Remote Start Capability (UI 26)
  • Reduced Range/Operation Of Remote Keyless Entry (86-90-06)
  • Information - Essential Tool J-43241 Remote Keyless Entry And Passive Keyless Entry Transmitter Tester (83-90-12)
  • SMU - "Key-In Warning Alarm Fails On" Revised Table (86-81-04)
  • SMU - Theft Deterrent System & DTC B2958 Tables (86-90-02)
• Automatic Trans
  • Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
  • Information On Driveline Clunk Noise (99-04-20-002O)
  • Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
  • Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
  • Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
  • Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
  • Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
  • Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
  • Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
  • No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
  • No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
  • Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
  • 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC® Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
  • Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
  • Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
  • Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
  • New Product Feedback Form and Process For Automatic Transmission Core Returns (01-07-30-029A)
  • Transmission Fluid Leak Diagnosis (01-07-30-041B)
  • Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
  • Most Frequently Asked Questions And Answers For J 45096 TRANSFLOW Transmission Oil Cooling System Flushing Machine (03-07-30-027)
  • Park/Neutral Position Switch Connector Cannot Be Removed (Replace Switch And Connectors) (01-07-30-021)
  • Revised DTC Tables For P0716 And P0717 (00-07-30-015)
  • New Solenoid Testing Kit From KENT MOORE (99-07-30-021)
  • New Tech 2 TCC Test - Component Slipping/DTC P1870 (99-07-30-023)
  • Service Engine Soon Light/DTC P1810 Set - PFP Switch (99-07-30-013)
  • Revised Turbine Shaft Seal Installer For 4L60E Trans (99-07-30-011)
  • 7.4L Eng 4L80-E Trans Surge TRAILERING - Program VCM (99-06-04-016)
  • 4L60E Trans TCC/Internal Slipping/DTC P1870 Diag (99-07-30-005)
  • 4L80E Trans Stalls/Surge At Stops/Shifted Into Gear (87-71-63A)
  • 4L60E Trans New Calibrations (87-71-69)
  • Harsh 1-2 Upshift Or Harsh Upshifts All Gears (87-71-62)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
  • New Product Information For 4L60-E Transmission (77-71-75)
  • Proper Fill Tube & Bottom Pan Combination (77-71-74)
• Auxiliary Emission Control Systems
  • Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
  • Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
  • I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
  • New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
  • Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
  • ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
  • Test Guidelines For Use Of Essential Tool J 41413-200 Evaporative System Tester (01-06-04-044)
  • Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
  • 7.4L - Mil On With DTC P0446 Set - Reprogram Pcm (00-06-04-042)
  • Powertrain Control Module Product Feedback Program (00-06-04-026)
  • No/Hard/Slow Start Noise During Cranking DTC P0338 (00-06-04-014)
  • Evaporative Emissions Testing On Vehicles (00-06-04-001)
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
  • On Board Diagnostic SYS Improvements - Reprogram Pcm (99-06-04-037)
  • 7.4L Eng Tick/Knock/Rattle Noise - Reprogram VCM (99-06-04-014)
  • 7.4L Eng Noise From A.I.R. Valves On Start-Up - REPL (99-06-04-002)
  • SMU - Section 0B - New Crankcase Vent System Service (83-02-01)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • 4.3/5.0/5.7/7.0L Eng OBD II DTC P1404 - REFLASH VCM (86-65-03)
  • Bi-Fuel CNG Mass Sensor/Mix Control Valve, Tank, ECM (76-63-08A)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
  • Hard/No Start, DTC 13/P0215 -Elect. Shutoff Solenoid (87-63-04)
  • Excessive Ticking Noise In Ambient Temperature (87-63-02)
  • Engine High Idle/Flare When Shifting Gears (76-65-07)
• Blowers, Superchargers & Turbochargers
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
• Body Electrical
  • Updated Transfer Case Connector Service Kit Now Available For Transfer Case Speed Sensor Wire Harness Connector that Comes Loose Or Connector Retainer Clip Breaks (06-04-21-001)
  • Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
  • UPFITTER Bulletin - PASSLOCK Disablement For Vehicle Remote Start Capability (UI 26)
• Body Interior
  • Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
  • Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
  • OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
  • HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
  • No/Hard/Slow Start Noise During Cranking DTC P0338 (00-06-04-014)
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
  • Park/Neutral Switch Connector Cannot Be Removed (83-71-10A)
• Brakes Control Systems
  • Brake Fluid Level & Filling Recommendations (00-05-22-004)
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
• Charging Systems
  • Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
  • Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
  • Battery and Charging System Electrical Diagnostics (99-06-03-012)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
  • Cs-144 Generator Replacement (99-06-03-011)
• Clutch
  • Noise From Clutch Housing No Clutch/Disc Cracked (99-07-31-003A)
• Collision/Avoidance
  • Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
• Communication Devices
  • Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
  • Information on OnStar® Analog-Only Systems (06-08-64-007A)
  • OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
  • OnStar(R) Kit Part Numbers and Compatibility (99-08-46-001A)
  • Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
  • OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
  • Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
• Cooling Fan
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
• Cooling System (Mechanical)
  • Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
  • Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
  • DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
  • Engine Coolant Recycling and Warranty Information (00-06-02-006D)
  • Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
  • DEX-COOL(R) Engine Coolant Information (736214)
  • 7.4L - Mil On With DTC P0446 Set - Reprogram Pcm (00-06-04-042)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • Injection Pump Exchange Program Cancellation (57-63-04D)
  • Diesel Engine Hesitation, White Smoke/Rough Idle (87-63-03)
  • Engine Oil Consumption Guidelines (76-60-04)
• Differentials & Drive Axles
  • Recommended Axle Lubricant (76-02-02A)
• Electronic Steering
  • Info - Essential Tool J43485 Power Steering Bleeder Adapter (83-32-09)
• Electronic Suspension
  • GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
• Engine Control Systems
  • Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
  • Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
  • Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
  • Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
  • Rough Idle After Start, And/Or A Service Engine Soon (SES) Light (Unstick And Clean Central Sequential Fuel Injection (CSFI) Poppet Valves Or Convert To MFI) (87-65-07)
  • ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
  • Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
  • Fuel Transfer Pump Inoperative (Replace Fuel Transfer Module) (01-06-04-037B)
  • SMU - Revised Diagnostic Trouble Codes (DTCS) P0404, P0405, P1404 (01-06-04-043)
  • 7.4L - Mil On With DTC P0446 Set - Reprogram Pcm (00-06-04-042)
  • Powertrain Control Module Product Feedback Program (00-06-04-026)
  • No/Hard/Slow Start Noise During Cranking DTC P0338 (00-06-04-014)
  • Evaporative Emissions Testing On Vehicles (00-06-04-001)
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
  • On Board Diagnostic SYS Improvements - Reprogram Pcm (99-06-04-037)
  • 7.4L Eng Tick/Knock/Rattle Noise - Reprogram VCM (99-06-04-014)
  • UPFITTER Bulletin - Hard To Re-Start Diesel Engines (UI 20)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • 4.3/5.0/5.7/7.0L Eng OBD II DTC P1404 - REFLASH VCM (86-65-03)
  • UPFITTER Bulletin - Fuel Tank Removal/Loosening (SVIE 10)
  • Bi-Fuel CNG Mass Sensor/Mix Control Valve, Tank, ECM (76-63-08A)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
  • Hard/No Start, DTC 13/P0215 -Elect. Shutoff Solenoid (87-63-04)
  • Engine High Idle/Flare When Shifting Gears (76-65-07)
• Entertainment Systems
  • Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
  • Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
  • Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
  • Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
  • Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
  • Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
  • Cleaning Cassette Tape Player And Clearing CLN Message From Radio Display (01-08-44-006A)
  • Accessory Receptacle/Cigar Lighter Is Inoperative (99-08-45-005)
  • Cassette Player Cleaning & Maintenance (99-08-44-008)
  • Compact Disc (Cd) Players And Compatible CD'S (99-08-44-006)
  • 1998 DELCO Radio Exchange Reference (72-01-01)
• Exhaust
  • Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
  • New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
  • Exhaust System Rumble/Rattle Noise (Replace Exhaust Pipe Seals & Modify Exhaust Pipe Ring Flanges) (01-06-05-006)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
• Exterior Body Panels
  • Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
  • Metal Panel Bonding (02-08-98-001C)
  • Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
  • Usage of E85 Fuels in GM Vehicles (05-06-04-035)
  • Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
  • Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
  • Auxiliary Fuel Tank Removal Procedure (86-63-19)
  • Fuel Transfer Pump Inoperative (Replace Fuel Transfer Module) (01-06-04-037B)
  • New CNG High Pressure Lock-Off (HPL) Procedures (99-06-04-054)
  • UPFITTER Bulletin - Fuel Tank Removal/Loosening (SVIE 10)
• Exterior Lights
  • Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
  • Exterior Lamp Condensation And Replacement Guideline (63-82-06A)
• Frames, Subframes & Crossmembers
  • Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
  • Information on Repair of Polypropylene Energy Absorbers (63-20-02)
• Front Suspension
  • The Importance of Chassis Lubrication (00-00-90-001)
  • Alignment Specifications (83-31-09)
• Fuel System
  • Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
  • Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
  • Information on Low Fuel Lubricity and Fuel System Metal Contamination (99-06-04-047D)
  • Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
  • Information on Low Fuel Lubricity and Fuel System Metal Contamination (99-06-04-047C)
  • Information On Ultra Low Sulfur Diesel Fuel and Warning Labels Found On Fuel Station Pumps - Applicable to All Light and Medium Duty Diesel Engines with RPO codes LBZ, LB7, LH6, LLY, LMM, LL4, LQM, LQN, L49, L56, L57, L65, LG4, 1C3, 1C2, 1L5 (06-06-04-041)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • Usage of E85 Fuels in GM Vehicles (05-06-04-035)
  • Fuel Injection Pump Exchange Program (99-06-04-041C)
  • Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
  • Rough Idle After Start, And/Or A Service Engine Soon (SES) Light (Unstick And Clean Central Sequential Fuel Injection (CSFI) Poppet Valves Or Convert To MFI) (87-65-07)
  • ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
  • Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
  • Fuel Transfer Pump Inoperative (Replace Fuel Transfer Module) (01-06-04-037B)
  • 7.4L - Mil On With DTC P0446 Set - Reprogram Pcm (00-06-04-042)
  • New CNG High Pressure Lock-Off (HPL) Procedures (99-06-04-054)
  • UPFITTER Bulletin - Hard To Re-Start Diesel Engines (UI 20)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • UPFITTER Bulletin - Fuel Tank Removal/Loosening (SVIE 10)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
• Fuses & Circuit Breakers
  • Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
  • Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
  • Accessory Receptacle/Cigar Lighter Is Inoperative (99-08-45-005)
  • Park/Neutral Switch Connector Cannot Be Removed (83-71-10A)
• Gauges & Instrument Panels
  • Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
  • Verifying Odometer Accuracy (PIC3100G)
  • Information On Speedometer Accuracy (08-08-49-011B)
  • Information On Speedometer Accuracy (08-08-49-011)
  • PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
  • Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
  • Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
  • Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • Instrument Cluster Identification (99-08-49-002)
  • Park/Neutral Switch Connector Cannot Be Removed (83-71-10A)
• General Servicing
  • Information On Refrigerant (R1234YF) For A/C Service (12-01-37-001G)
  • PUREGUARD 2 Operating Alert (73-12-13)
• Headlights
  • Exterior Lamp Condensation And Replacement Guideline (63-82-06A)
• Heated Glass/Defoggers
  • Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
• HVAC Control Systems
  • Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
  • Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
  • 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
  • Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
  • Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
  • J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
  • A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
  • Essential Tool J 43600 ACR 2000 (00-01-38-006)
  • Diagnostic Procedure For A/C Refrigerant Leak (73-12-12A)
  • PUREGUARD 2 Operating Alert (73-12-13)
• Identification
  • Battery Specification Label (04-06-03-016)
  • Instrument Cluster Identification (99-08-49-002)
• Ignition Switch/Steering Lock
  • Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
  • Key Code Information (99-00-89-011E)
  • SMU - Revised Ignition Lock Cylinder Replacement (02-02-35-001)
• Ignition System
  • Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • Correct Solvent For CSFI Poppet Cleaning Procedure (99-06-04-006)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
  • Injection Pump Exchange Program Cancellation (57-63-04D)
  • Diesel Engine Hesitation, White Smoke/Rough Idle (87-63-03)
• Infotainment
  • Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
  • Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
  • OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
  • Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
• Interior/Exterior Trim
  • Information On Proper Use Of Floor Mats (10-08-110-001L)
  • Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
  • Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
  • Plastic Wheel Nut Covers Missing and/or Loose (Replace Missing Covers and Add Sealant to All Covers) (01-03-10-009A)
  • HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
  • Procedure For Aligning Rear Side Replacement Door (99-08-64-028)
  • Noisy/Binding Front Doors/Hard To/Won't Stay Open (99-08-64-024)
• Interior/Illumination Lights
  • Exterior Lamp Condensation And Replacement Guideline (63-82-06A)
• Lubrication System
  • Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
  • Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
  • Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
  • Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
  • 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
  • Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
  • Injection Pump Exchange Program Cancellation (57-63-04D)
  • Diesel Engine Hesitation, White Smoke/Rough Idle (87-63-03)
  • Engine Oil Consumption Guidelines (76-60-04)
• Manual Steering
  • Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
  • Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
  • Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
  • Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
  • Guidelines For Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
  • Revised Flushing Procedure for Contaminated Power Steering Reservoirs (99-02-32-006)
  • Info - Essential Tool J43485 Power Steering Bleeder Adapter (83-32-09)
• Manual Trans
  • Information On Driveline Clunk Noise (99-04-20-002O)
  • Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
  • Recommended Axle Lubricant (76-02-02A)
• Mechanical
  • Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
  • Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
  • Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
  • Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
  • Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
  • GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
  • Revised Mass Air Flow Core Return Requirements (06-06-04-057)
  • Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
  • Powertrain Quality Center For Performance Parts Engine Replacements (03-06-01-006)
  • Engine Identification Information (02-06-01-026)
  • 7.4L - Mil On With DTC P0446 Set - Reprogram Pcm (00-06-04-042)
  • Rod Bearing Clearance Checking Tool J 43690 (00-06-01-007)
  • 5.0L/5.7L Eng Bearing Knock Noise - Re-Support Crank (99-06-01-003)
  • Correct Solvent For CSFI Poppet Cleaning Procedure (99-06-04-006)
  • 4.3,5.0,5.7L Engines Gen 1E New Product Service (87-61-32)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
  • Injection Pump Exchange Program Cancellation (57-63-04D)
  • Diesel Engine Hesitation, White Smoke/Rough Idle (87-63-03)
  • Premature Main Bearing Fails -OVERTIGHTENED Manifold (87-61-22)
  • Engine Oil Consumption Guidelines (76-60-04)
  • Engine Tick/Knock/Rattle Noise - Normal Condition (77-61-21)
• Mechanical - Hydraulic
  • On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
  • SMU - Revised Drum Brakes Component Specifications (02-05-24-001)
  • Brake Fluid Level & Filling Recommendations (00-05-22-004)
  • Brake Lead/Pull & Front Brake Wear - REPL Pads/Shoes (99-05-24-001A)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • Brake Lead/Pull & Front Brake Wear (86-50-20)
  • Recall 98009 - Brake Rotor/Hub Fatigue (98009)
• Memory Modules
  • HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
• Mirrors
  • Information On Curb Park Assist And Memory Related Issues On Outside Rearview Mirrors (07-08-64-022B)
  • Outside Rear View Mirror Housing Turns Chalky/Dull (00-08-51-001)
• Overdrive Unit
  • Revised DTC Tables For P0716 And P0717 (00-07-30-015)
  • New Solenoid Testing Kit From KENT MOORE (99-07-30-021)
  • Service Engine Soon Light/DTC P1810 Set - PFP Switch (99-07-30-013)
  • 4L60E Trans New Calibrations (87-71-69)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
• Paint & Coatings
  • Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
  • Application Of Anti-Corrosion Materials (01-08-51-003E)
  • Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
  • Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
  • Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
  • Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
• Passive Restraints
  • Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
• Procedures
  • Website For AFIT, TPM, Gr8, MIT And PICO Scope Updates (PIP4723H)
  • January 2000 Labor Time Guide Updates (99-00-89-023)
  • December 1998 Labor Time Guide Updates (83-05-10)
  • November 1998 Labor Time Guide Updates (83-05-09)
• Rear Suspension
  • Unnecessary Leaf Spring Clip Replacement (04-03-08-011D)
  • The Importance of Chassis Lubrication (00-00-90-001)
  • Alignment Specifications (83-31-09)
• Restraints Control Systems
  • No/Hard/Slow Start Noise During Cranking DTC P0338 (00-06-04-014)
  • Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
• Schedule
  • Recommended Axle Lubricant (76-02-02A)
• Seats
  • Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
  • Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
  • Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
• Starter
  • Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
  • GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
  • Battery and Charging System Electrical Diagnostics (99-06-03-012)
  • Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • Battery Specification Label (04-06-03-016)
  • Battery Parasitic Drain (02-06-03-010A)
  • Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
  • UPFITTER Bulletin - PASSLOCK Disablement For Vehicle Remote Start Capability (UI 26)
  • Battery Insulator Replacement (99-06-03-002)
  • Correct Solvent For CSFI Poppet Cleaning Procedure (99-06-04-006)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • Injection Pump Exchange Program Cancellation (57-63-04D)
  • Diesel Engine Hesitation, White Smoke/Rough Idle (87-63-03)
  • Manual Update - Auxiliary Battery Schematic (76-82-09)
• Steering Column
  • Campaign - Steering Shaft To Gear Pinch Bolt Loose (97048)
• Steering Control Systems
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
• Steering Gear
  • Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
  • Info - Essential Tool J43485 Power Steering Bleeder Adapter (83-32-09)
  • Campaign - Steering Shaft To Gear Pinch Bolt Loose (97048)
• Steering Linkage
  • The Importance of Chassis Lubrication (00-00-90-001)
  • Recall 98009 - Brake Rotor/Hub Fatigue (98009)
  • Campaign - Steering Shaft To Gear Pinch Bolt Loose (97048)
• Sun Roof/T-Top/Convertible Top
  • Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
  • GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
  • Procedure For Aligning Rear Side Replacement Door (99-08-64-028)
  • Noisy/Binding Front Doors/Hard To/Won't Stay Open (99-08-64-024)
• Suspension Control Systems
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
• System
  • Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
  • Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
  • Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
  • Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
  • Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
  • Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
  • Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
  • Rough Idle After Start, And/Or A Service Engine Soon (SES) Light (Unstick And Clean Central Sequential Fuel Injection (CSFI) Poppet Valves Or Convert To MFI) (87-65-07)
  • ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
  • Exhaust System Rumble/Rattle Noise (Replace Exhaust Pipe Seals & Modify Exhaust Pipe Ring Flanges) (01-06-05-006)
  • Test Guidelines For Use Of Essential Tool J 41413-200 Evaporative System Tester (01-06-04-044)
  • Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
  • Fuel Transfer Pump Inoperative (Replace Fuel Transfer Module) (01-06-04-037B)
  • SMU - Revised Diagnostic Trouble Codes (DTCS) P0404, P0405, P1404 (01-06-04-043)
  • 7.4L - Mil On With DTC P0446 Set - Reprogram Pcm (00-06-04-042)
  • Powertrain Control Module Product Feedback Program (00-06-04-026)
  • No/Hard/Slow Start Noise During Cranking DTC P0338 (00-06-04-014)
  • Evaporative Emissions Testing On Vehicles (00-06-04-001)
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
  • New CNG High Pressure Lock-Off (HPL) Procedures (99-06-04-054)
  • On Board Diagnostic SYS Improvements - Reprogram Pcm (99-06-04-037)
  • 7.4L Eng Tick/Knock/Rattle Noise - Reprogram VCM (99-06-04-014)
  • 7.4L Eng Noise From A.I.R. Valves On Start-Up - REPL (99-06-04-002)
  • Correct Solvent For CSFI Poppet Cleaning Procedure (99-06-04-006)
  • UPFITTER Bulletin - Hard To Re-Start Diesel Engines (UI 20)
  • SMU - Section 0B - New Crankcase Vent System Service (83-02-01)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • 4.3/5.0/5.7/7.0L Eng OBD II DTC P1404 - REFLASH VCM (86-65-03)
  • UPFITTER Bulletin - Fuel Tank Removal/Loosening (SVIE 10)
  • Bi-Fuel CNG Mass Sensor/Mix Control Valve, Tank, ECM (76-63-08A)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
  • Hard/No Start, DTC 13/P0215 -Elect. Shutoff Solenoid (87-63-04)
  • Injection Pump Exchange Program Cancellation (57-63-04D)
  • Diesel Engine Hesitation, White Smoke/Rough Idle (87-63-03)
  • Excessive Ticking Noise In Ambient Temperature (87-63-02)
  • Engine High Idle/Flare When Shifting Gears (76-65-07)
  • Engine Oil Consumption Guidelines (76-60-04)
• Towing
  • Recreational (Dinghy) Towing (00-00-89-008F)
• Transfer Case
  • Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
  • Updated Transfer Case Connector Service Kit Now Available For Transfer Case Speed Sensor Wire Harness Connector that Comes Loose Or Connector Retainer Clip Breaks (06-04-21-001)
  • Release Of New Tool J 45380 - Rear Output Shaft Bushing Remover And Installer (02-04-21-007)
  • Bump/Clunk Upon Acceleration - Transfer Case Fluid (86-74-03)
  • NVG 136/246 Auto 4WD Transfer Case/Encoder/Module (76-74-01A)
  • Recommended Axle Lubricant (76-02-02A)
• Transmission Control Systems
  • Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
  • Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
  • Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
  • Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
  • Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
  • Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
  • Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
  • ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
  • Park/Neutral Position Switch Connector Cannot Be Removed (Replace Switch And Connectors) (01-07-30-021)
  • Revised DTC Tables For P0716 And P0717 (00-07-30-015)
  • Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
  • New Solenoid Testing Kit From KENT MOORE (99-07-30-021)
  • New Tech 2 TCC Test - Component Slipping/DTC P1870 (99-07-30-023)
  • 6.5 Diesel No Start Stall, DTC 35 Or P1216 (77-63-06A)
  • Stall/Surge At Stop Or When Shifted To Drive/Reverse (87-71-63)
  • NVG 136/246 Auto 4WD Transfer Case/Encoder/Module (76-74-01A)
• Wheel Hubs
  • Recall 98009 - Brake Rotor/Hub Fatigue (98009)
• Wheels & Tire System
  • Information On Proper Tire Pressure (00-00-90-002M)
  • General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
  • Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
  • Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
  • Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
  • Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
  • Information on Replacement Wheel Weights (09-03-10-017)
  • Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
  • Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
  • Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
  • Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
  • Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
  • Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
  • Original Equipment Chrome Plated Aluminum WEEEL Id (99-03-10-102)
  • UPFITTER Bulletin - 1998 Wheel Offset Specifications (SVIE 07)
  • Recall 98009 - Brake Rotor/Hub Fatigue (98009)
• Window Motors & Regulators
  • Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
  • Procedure For Aligning Rear Side Replacement Door (99-08-64-028)
  • Noisy/Binding Front Doors/Hard To/Won't Stay Open (99-08-64-024)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
  • UPFITTER Bulletin - PASSLOCK Disablement For Vehicle Remote Start Capability (UI 26)
  • Park/Neutral Switch Connector Cannot Be Removed (83-71-10A)