| Water leaks from sunroof |
Deteriorated roof lid weatherstrip |
Replace |
| Excessive roof lid-to-body clearance and improperly fitted weatherstrip |
Adjust |
| Wind noise around sunroof |
Loose or deformed deflector, gaps in body work |
Retighten adjust or replace |
| Noise created by moving sunroof lid |
Foreign particles lodged in guide rail |
Check drive cable and guide rails for foreign particles |
| Loose guide rails and lid |
Retighten |
| Motor runs but sunroof does not move or moves only partially |
Foreign particles lodged in guide rail |
Adjust or replace |
| Incorrect engagement of motor pinion with drive cable |
| Decrease in motor's clutch slipping force |
| Increased sunroof sliding resistance or interference of sunroof with drive cables, weatherstrip, etc. due to abnormal adjustment of sunroof |
| Noise in motor (clutch slipping noise from motor when sunroof is fully opened or closed) is considered as normal |
Incorrect engagement of motor pinion with drive cable |
Check pinion installation and Re-tighten motor |
| Worn out or damaged motor pinion bearing |
Replace motor assembly |
| Worn out or deformed drive cable |
Replace |
| Door glass fails to operate up and down |
Incorrect window glass installation |
Adjust position |
| Damaged or faulty regulator arm or regulator |
Correct or replace |
| Door does not open or close completely |
Incorrect door installation |
Adjust position |
| Defective door check assembly |
Correct or replace |
| Door hinge requires grease |
Apply grease |
| Hood does not open or close completely |
Striker and latch not properly aligned |
Adjust |
| Incorrectly installed hood |
Adjust |
| Incorrect hood bumper height |
Adjust |
| Water leaks through windshield and rear window |
Defective seal |
Fill with sealant |
| Defective flange |
Correct |