Technical Service Bulletins

• A/C Compressor
  • Air Conditioning (A/C) Inoperative (JLRTB02109NAS1)
  • SANDEN 709 Compressor Refrigerant Leak - Seal Kit (SECTION 82, NO. 51)
  • R-134A Retrofit Kits (SECTION 82, NO. 39 REV.)
  • R-12 Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-46)
  • Climate Control Panel Vibrating/INTERMITTEN A/C (SECTION 82, NO. 38)
  • A/C Compressor Seal Remove/Replace Tool Availability (SECTION 01, NO. 48)
  • Refrigerant R-12 Phase Out Information (SECTION 06, NO. 27)
  • A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
  • FREON Recovery/Recycling Equipment - Requirement (SECTION TOL, NO. 35)
  • Special Tools - A/C Compressor/Steering Rack (SECTION TOL, NO. 28)
• Accessories Control Systems
  • Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
  • Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
• Anti-Lock Brakes
  • Abs Valve Block Assembly - Replace Separately (SECTION 70, NO. 27)
  • Abs Light/Code 61/Motor Pump Stuck On - Abs Switch (SECTION 70, NO. 15)
• Anti-Theft Systems
  • Trunk Latch - Modify - Install Using Short Screw (SECTION 86, NO. 177)
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Sunroof Limit Switch Inoperative:Diagnosis Procedure (SECTION 86, NO. 106)
  • Side Mirror Wind Noise - New Mirror Housing Assembly (SECTION 76, NO. 62)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
  • TIBBE Lock System Repair/Replacement (SECTION 76, NO. 64)
  • Improved Alarm System Transmitter Range (SECTION 86, NO. 81)
  • Vehicle Equipped With Alarm Start Up After Storage (SECTION 86, NO. 77)
  • Alarm Fault Code Diagnostic Procedure (SECTION 86, NO. 76)
• Automatic Trans
  • Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
  • ZF 4HP 24 E9 Automatic Transmission Shift Quality (SECTION 44, NO. 27)
  • ZF A/T Internal Damage Due To High Rpm In "P" Or "N" (SECTION 44, NO. 26)
  • ZF A/T Noise In Reverse Gear When Cold - Procedure (SECTION 44, NO. 25)
  • A/T Defaults To "Limp Mode" In Wet Weather-Procedure (SECTION 04, NO. 18)
  • Engine Stalls When Engaged In "R" Or "D" - Procedure (SECTION 44, NO. 23)
  • Engine Stall: Trans Fluid Level Low-Check Procedure (SECTION 18, NO. 31)
  • A/T KICKDOWN Switch Operation: Throttle Linkage Adj (SECTION 44, NO. 15)
  • Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
  • Trans Front Pump/Intermediate Plate Failure - R & R (SECTION 44, NO. 14)
  • ZF & Gm 400 Transmission Repair/Replacement (SECTION 44, NO. 12)
  • Poor/Harsh Shift - New Valve Body/Ecu (SECTION 44, NO. 11)
  • Use Of Gasohol (SECTION ENG, J83/36)
• Auxiliary Emission Control Systems
  • New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
  • Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
  • PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
  • Diagnostic Trouble Code 44: O2 Sensor Splash Shield (SECTION 18, NO. 30)
  • Fuel Fail Code 29 - Diagnosis/Repair (SECTION 18, NO. 22)
  • VCM Fuel Fail Code 69 - Diagnosis/Repair (SECTION 18, NO. 21)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
• Axle Shafts
  • Rear Hub Master Spacer/Bearing Tool Availability (SECTION 64, NO. 11)
  • Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
  • PROPSHAFT Vibration At 30-50 Mph - New PROPSHAFT (SECTION 47, NO. 5)
  • PROPSHAFT Vibration Unauthorized Repair Information (SECTION 57, NO. 9)
• Blowers, Superchargers & Turbochargers
  • Alternator Drive Belt Tension Adjustment (SECTION 86, NO. 97)
• Body Interior
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
  • Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Climate Control Panel Vibrating/INTERMITTEN A/C (SECTION 82, NO. 38)
  • A/C Ecu & Water Temp SW:Matched Pairs-Identification (SECTION 82, NO. 28)
  • A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
  • Ac Panel Malfunctions - REPL Ecu & Water Temp Switch (SECTION 82, NO. 22)
  • Erratic Climate Control/No FOOTWELL Heat - Aspirator (SECTION 82, NO. 21)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
• Brakes Control Systems
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Abs Valve Block Assembly - Replace Separately (SECTION 70, NO. 27)
  • Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
  • Abs Light/Code 61/Motor Pump Stuck On - Abs Switch (SECTION 70, NO. 15)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
• Charging Systems
  • Oil Leak From Generator Bracket Bolts - Use LOCTITE (SECTION 12, NO. 50)
  • Alternator Drive Belt Tension Adjustment (SECTION 86, NO. 97)
• Communication Devices
  • Rear Struts/Installing Non-Leveling Dampers/Repair (SECTION 64, NO. 14)
• Cooling System (Mechanical)
  • 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
  • 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
  • Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
  • 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
  • Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
  • Coolant Header Tank Cap Seal Leak: Lubricate Seal (SECTION 26, NO. 11)
  • Revised Water Pump: New Center Gasket (4.0L AJ6) (SECTION 26, NO. 10)
  • Coolant Header Tank Cap Seal Leak-Lubricate Seal (SECTION 26, NO. 12)
  • Coolant System Pressure Test ADAPTOR Usage (SECTION 01, NO. 54)
  • CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
  • CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
  • Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
  • Cooling System Leak - Add Sealant W/Antifreeze (SECTION 26, NO. 5)
• Cruise Control Systems
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Cruise Control Set Speed Varies: FREEPLAY Inspection (SECTION 19, NO. 18)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
• Differentials & Drive Axles
  • Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
  • Diff Noise At Various Speeds: Sound Insulation Pads (SECTION 51, NO. 2)
  • Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
  • PROPSHAFT Vibration At 30-50 Mph - New PROPSHAFT (SECTION 47, NO. 5)
  • PROPSHAFT Vibration Unauthorized Repair Information (SECTION 57, NO. 9)
  • Use Of Gasohol (SECTION ENG, J83/36)
• Driveshaft & Universal Joints
  • PROPSHAFT Vibration At 30-50 Mph - New PROPSHAFT (SECTION 47, NO. 5)
  • PROPSHAFT Vibration Unauthorized Repair Information (SECTION 57, NO. 9)
• Electronic Steering
  • Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
• Electronic Suspension
  • Ride Level System Not Functioning Properly - VAVLE (SECTION 66, NO. 22)
  • Rear Struts/Installing Non-Leveling Dampers/Repair (SECTION 64, NO. 14)
  • Ride Leveling Strut Replacement: Individually/Pairs (SECTION 64, NO. 13)
  • Ride Levelling: Deletion Of PWER HYD Up Solenoid (SECTION JDS, NO. 60)
  • Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
• Engine Control Systems
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
  • Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
  • New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
  • Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
  • Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
  • PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
  • Diagnostic Trouble Code 44: O2 Sensor Splash Shield (SECTION 18, NO. 30)
  • Fuel Fail Code 29 - Diagnosis/Repair (SECTION 18, NO. 22)
  • VCM Fuel Fail Code 69 - Diagnosis/Repair (SECTION 18, NO. 21)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • 1991 Motor Year - Available Required Tools (SECTION TOL, NO. 30)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
  • Fuel Injector Tester (SECTION TOL, NO. 27)
• Entertainment Systems
  • Alpine Radio/Cd Player - Repair (SECTION 3, NO. 59)
  • Radio Codes - Obtaining Codes Through DCS System (SECTION 6, NO. 40)
  • Poor Radio Bass Speaker Operation: New Rear Speakers (SECTION 86, NO. 115)
  • Cd Player Skips - Install Longer Mounting Screws (SECTION 86, NO. 84)
  • Alpine Radio Security Code Entry/Label Placement (SECTION 86, NO. 102)
  • Cassette Player Head Cleaning Procedure (SECTION 86, NO. 100)
  • Antenna Mast Seizure/Failure - Clean Or Replace (SECTION 86, NO. 93)
  • Cd Improper Operation - Diagnosis Procedure (SECTION 86, NO. 94)
  • Am Radio Tick Noise - Reroute Gearbox Harness (SECTION 86, NO. 92)
  • Cd Magazine Stuck In Changer - Emergency Ejecting (SECTION 86, NO. 90)
  • HEELBOARD Speaker Poor Sound - Check Wiring/Clips (SECTION 86, NO. 91)
  • Radio Failure/Water Entry - Condensation Shield (SECTION 86, NO. 85)
  • Radio Reception Poor - Am & Fm Operation (SECTION 86, NO. 87)
• Exhaust
  • Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
• Exterior Body Panels
  • Revised UNDERSCUTTLE & Mounting Method (SECTION 76, NO. 108)
  • Fuel Tank - Replacement Procedure (SECTION 19, NO. 29)
  • Faulty Fuel Filler Cap - Revised Part (SECTION 19, NO. 25)
  • Fuel Filler APERATURE Drain Blocked:Strainer Install (SECTION 19, NO. 21)
  • 1991 Motor Year - Available Required Tools (SECTION TOL, NO. 30)
• Exterior Lights
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
• Frames, Subframes & Crossmembers
  • Revised UNDERSCUTTLE & Mounting Method (SECTION 76, NO. 108)
• Front Suspension
  • Multimedia Training Software Update Version 2.0 (SECTION 6, NO. 62)
  • Steering Pull - Correction Procedure (SECTION 60, NO. 7)
  • Ride Level System Not Functioning Properly - VAVLE (SECTION 66, NO. 22)
  • Rear Struts/Installing Non-Leveling Dampers/Repair (SECTION 64, NO. 14)
  • Ride Leveling Strut Replacement: Individually/Pairs (SECTION 64, NO. 13)
  • Ride Levelling: Deletion Of PWER HYD Up Solenoid (SECTION JDS, NO. 60)
  • Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
• Fuel System
  • Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
  • Throttle Valve Clearance Adjustment Guidelines (SECTION 19, NO. 23)
  • Idle Knock - Replace Fuel Rail Feed Hose Assembly (SECTION 19, NO. 17)
  • VCM Fuel Fail Code 69 - Diagnosis/Repair (SECTION 18, NO. 21)
  • 1991 Motor Year - Available Required Tools (SECTION TOL, NO. 30)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
  • Fuel Injector Tester (SECTION TOL, NO. 27)
• Fuses & Circuit Breakers
  • Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
  • Elect Harness Fails:INTRFRCE W/Steering Col Sup BRKT (SECTION 86, NO. 107)
  • No "Circuit Failure" Illumination W/Blown Fuses (SECTION 86, NO. 105)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
  • 1991 Motor Year - Available Required Tools (SECTION TOL, NO. 30)
• Gauges & Instrument Panels
  • 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
  • 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
  • Climate Control Panel Vibrating/INTERMITTEN A/C (SECTION 82, NO. 38)
  • Passenger UNDERDASH Panel Special Replacement Tool (SECTION 76, NO. 77)
  • No "Circuit Failure" Illumination W/Blown Fuses (SECTION 86, NO. 105)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
• General Servicing
  • A/C Drain Hole Guide Bushing Set (SECTION TOL, NO. 31)
• Headlights
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
• HVAC Control Systems
  • SANDEN 709 Compressor Refrigerant Leak - Seal Kit (SECTION 82, NO. 51)
  • R-134A Retrofit Kits (SECTION 82, NO. 39 REV.)
  • A/C System Servicing - Preventing Entry Of Moisture (SECTION 82, NO. 50)
  • R-12 Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-46)
  • Climate Control Panel Vibrating/INTERMITTEN A/C (SECTION 82, NO. 38)
  • A/C Compressor Seal Remove/Replace Tool Availability (SECTION 01, NO. 48)
  • Noisy A/C Blower Motors: Revised Motor (SECTION 82, NO. 31)
  • Refrigerant R-12 Phase Out Information (SECTION 06, NO. 27)
  • A/C DEFRSTR Flap Interference W/Duct:Harness Repair (SECTION 82, NO. 29)
  • A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
  • Ac Panel Malfunctions - REPL Ecu & Water Temp Switch (SECTION 82, NO. 22)
  • Erratic Climate Control/No FOOTWELL Heat - Aspirator (SECTION 82, NO. 21)
  • A/C Erratic - Control Panel Micro Switch Testing (SECTION 86, NO. 101)
  • A/C Blower Motor Noise - Replacement Part Numbers (SECTION 82, NO. 25)
  • A/C Control Panel Lockup/Erratic Temp - Diagnosis (SECTION 82, NO. 23)
  • A/C Compressor Noise/Leak - Diagnosis/Repair (SECTION 82, NO. 24)
  • FREON Recovery/Recycling Equipment - Requirement (SECTION TOL, NO. 35)
  • A/C Drain Hole Guide Bushing Set (SECTION TOL, NO. 31)
  • Special Tools - A/C Compressor/Steering Rack (SECTION TOL, NO. 28)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
• Identification
  • VIN Plate - Use Caution When Replacing Windshield (SECTION 76, NO. 125)
  • Replacement Of Identification Labels (SECTION 06, NO. 39)
  • VIN & Certification Labels/Plate Replacement (WRKSHP ADM., NO. 19)
• Ignition Switch/Steering Lock
  • VCM Fuel Fail Code 69 - Diagnosis/Repair (SECTION 18, NO. 21)
  • TIBBE Lock System Repair/Replacement (SECTION 76, NO. 64)
• Ignition System
  • Spark Plug "Blow-By Stain"/Corona Stain - Spark Plug Function Not Affected - Replacement Unnecessary (SECTION 18, NO. 55)
  • Poor Running In Wet Or Hot Weather - Air Cleaner (SECTION 19, NO. 31)
  • Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
  • Distributor Body/Rotor Arm: Set Position Using Tool (SECTION 18, NO. 25)
  • Distributor Cap Material & Electrode Form Change (SECTION 18, NO. 26)
  • Distributor Setting Gauge Tool Availability (SECTION 01, NO. 49)
  • Idle Misfire - Oscilloscope Spark Plug Diagnosis (SECTION 18, NO. 20)
• Infotainment
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
• Interior/Exterior Trim
  • Approved Cleaning Products By AUTOGLYM (JAGA100-001)
  • Squeaking Interior Trim - KRYTOX Fluid Available (SECTION 76, NO. 127)
  • Wood Veneer Repair Program (A-01)
  • Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
  • Wood Veneer Panel Repair - Kit (SECTION TOL, NO. 34)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
• Interior/Illumination Lights
  • Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
• Lubrication System
  • Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
  • 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
  • Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
  • Revised Water Pump: New Center Gasket (4.0L AJ6) (SECTION 26, NO. 10)
  • Oil Filter ASSY: Replace W/Sandwich Plate Removed (SECTION 12, NO. 37)
  • CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
  • CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
  • Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
  • Use Of Gasohol (SECTION ENG, J83/36)
• Manual Steering
  • Hydraulic Valve Block Leaking: Port Plug Tightening (SECTION 66, NO. 19)
  • PS Pump Drive Dog Removal Tool Bolts Availability (SECTION 01, NO. 50)
  • Pas-Lack Of Power Assistance: Repair Procedure (SECTION 57, NO. 14)
  • Power Steering Rack Hydraulic Noise Diagnosis (SECTION 57, NO. 10)
  • Special Tools - A/C Compressor/Steering Rack (SECTION TOL, NO. 28)
  • Power Steering Pump Drive Dog Tool Damage Prevention (SECTION 57, NO. 7)
• Mechanical
  • Upper Chain Guide Bolts - Apply Locking Compound (SECTION 12, NO. 64)
  • Cylinder Head Bolts - Reuse Twice - Conditions (SECTION 12, NO. 62)
  • Main Bearing Cap Bolts - Reuse Twice - Conditions (SECTION 12, NO. 63)
  • Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
  • Rattle After Start/Upper Timing Chain/New TENSIONER (SECTION 12, NO. 61)
  • Poor Running In Wet Or Hot Weather - Air Cleaner (SECTION 19, NO. 31)
  • Oil Leak From Generator Bracket Bolts - Use LOCTITE (SECTION 12, NO. 50)
  • AJ6 Engines - Torque Specifications For Drain Plug (SECTION 12, NO. 52)
  • 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
  • Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
  • Revised Water Pump: New Center Gasket (4.0L AJ6) (SECTION 26, NO. 10)
  • CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
  • CYL Head Rebuild-Install Valve Guide Seals (SECTION 12, NO. 43)
  • CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
• Mechanical - Hydraulic
  • Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
  • Hydraulic Valve Block Leaking: Port Plug Tightening (SECTION 66, NO. 19)
  • Brake Fluid Replacement Intervals (SECTION 70, NO. 20)
  • Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
  • Disc Brake Rumble/Pulsation/Vibration - Diagnosis (SECTION 70, NO. 14)
  • Use Of Gasohol (SECTION ENG, J83/36)
• Memory Modules
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
• Mirrors
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Motorized Automatic Diagonal Seat Belts Warranty (SECTION 03, NO. 120)
  • Detached Door Mirror Chrome Cover Repair Procedure (SECTION 76, NO. 79)
  • Side Mirror Wind Noise - New Mirror Housing Assembly (SECTION 76, NO. 62)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
  • Vehicle Equipped With Alarm Start Up After Storage (SECTION 86, NO. 77)
  • Alarm Fault Code Diagnostic Procedure (SECTION 86, NO. 76)
• Overdrive Unit
  • A/T Defaults To "Limp Mode" In Wet Weather-Procedure (SECTION 04, NO. 18)
  • ZF & Gm 400 Transmission Repair/Replacement (SECTION 44, NO. 12)
• Paint & Coatings
  • Exterior Paint Issues Reporting Aid (XJ501-023)
  • Glass Bonding - Procedures & Materials (SECTION 76, NO. 126)
  • Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
  • Paint And Body Repair - Authorization Guidelines (SECTION 03, NO. 136)
  • Excess Body Panel Corrosion Protection Wax Removal (SECTION 76, NO. 70)
  • 1991 Jaguar Paint Formula Codes (SECTION 76, NO. 60)
• Parking Brake System
  • Parking Brake Does Not Release (JTB00044)
• Procedures
  • Lower Than Actual Compression Figures Using The K00825-0/JLR-4425 COMPRESSIOR Tester Kit (SSM75380)
  • Use Of Non Approved Jaguar Land Rover Anti Bacterial Fogging Agents (SSM75126)
• Rear Suspension
  • Steering Pull - Correction Procedure (SECTION 60, NO. 7)
  • Ride Level System Not Functioning Properly - VAVLE (SECTION 66, NO. 22)
  • Rear Struts/Installing Non-Leveling Dampers/Repair (SECTION 64, NO. 14)
  • Ride Leveling Strut Replacement: Individually/Pairs (SECTION 64, NO. 13)
  • Ride Levelling: Deletion Of PWER HYD Up Solenoid (SECTION JDS, NO. 60)
  • Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
  • 1991 Motor Year - Available Required Tools (SECTION TOL, NO. 30)
  • Special Tool - JD 176 Power Hydraulic Valve Block (SECTION TOL, NO. 29)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
• Restraints Control Systems
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
• Schedule
  • Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
• Seats
  • Approved Cleaning Products By AUTOGLYM (JAGA100-001)
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Climate Control Panel Vibrating/INTERMITTEN A/C (SECTION 82, NO. 38)
  • Front Seat Belts Rattle - Repair Procedure (SECTION 76, NO. 92)
  • Automatic Seat Belts - Fault Diagnosis (SECTION 76, NO. 91)
  • Motorized Automatic Diagonal Seat Belts Warranty (SECTION 03, NO. 120)
  • Passive Restraint MTR Winch "Lock-Up":New CTRL Panel (SECTION 76, NO. 83)
  • Passive Restraint Motor Winch Assembly Diagnosis (SECTION 76, NO. 61)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
  • Vehicle Equipped With Alarm Start Up After Storage (SECTION 86, NO. 77)
  • Alarm Fault Code Diagnostic Procedure (SECTION 86, NO. 76)
• Starter
  • Batteries - Use Of Interstate Batteries (SECTION 3, NO. 174)
  • Battery Discharge From Short Trips: Lg Battery Need (SECTION 86, NO. 119)
  • Battery Isolation Switch: Kit Installation/Use (SECTION 86, NO. 108)
  • Battery Checking/Charging/Specifications (SECTION 86, NO. 104)
  • New Battery Specifications Charts (SECTION 86, NO. 98)
  • Battery R & R - New Interstate Replacement Battery (SECTION 86, NO. 95)
• Steering Column
  • Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
  • Steering Column Lock Barrel Replacement (SECTION 57, NO. 12)
• Steering Control Systems
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Rear Struts/Installing Non-Leveling Dampers/Repair (SECTION 64, NO. 14)
  • Ride Levelling: Deletion Of PWER HYD Up Solenoid (SECTION JDS, NO. 60)
  • Ride Level Sensor System Faults Diagnosis (SECTION 66, NO. 16)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
• Steering Gear
  • Hydraulic Valve Block Leaking: Port Plug Tightening (SECTION 66, NO. 19)
  • Pas-Lack Of Power Assistance: Repair Procedure (SECTION 57, NO. 14)
  • Special Tools - A/C Compressor/Steering Rack (SECTION TOL, NO. 28)
• Steering Linkage
  • Steering Pull - Correction Procedure (SECTION 60, NO. 7)
  • Alignment Specifications Table (SECTION 60, NO. 5)
  • Front Suspension - Vehicle Pulls - Check Pull Index (SECTION 60, NO. 6)
  • Rear Hub Master Spacer/Bearing Tool Availability (SECTION 64, NO. 11)
  • Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
  • Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
• Sun Roof/T-Top/Convertible Top
  • Climate Control Panel Vibrating/INTERMITTEN A/C (SECTION 82, NO. 38)
  • Sunroof Limit Switch Inoperative:Diagnosis Procedure (SECTION 86, NO. 106)
• Suspension Control Systems
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Ride Level System Not Functioning Properly - VAVLE (SECTION 66, NO. 22)
  • Rear Struts/Installing Non-Leveling Dampers/Repair (SECTION 64, NO. 14)
  • Ride Leveling Strut Replacement: Individually/Pairs (SECTION 64, NO. 13)
  • Ride Levelling: Deletion Of PWER HYD Up Solenoid (SECTION JDS, NO. 60)
  • Ride Level Sensor System Faults Diagnosis (SECTION 66, NO. 16)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
• System
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
  • Spark Plug "Blow-By Stain"/Corona Stain - Spark Plug Function Not Affected - Replacement Unnecessary (SECTION 18, NO. 55)
  • New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
  • Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
  • Poor Running In Wet Or Hot Weather - Air Cleaner (SECTION 19, NO. 31)
  • 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
  • Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
  • Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
  • PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
  • Throttle Valve Clearance Adjustment Guidelines (SECTION 19, NO. 23)
  • Diagnostic Trouble Code 44: O2 Sensor Splash Shield (SECTION 18, NO. 30)
  • Revised Water Pump: New Center Gasket (4.0L AJ6) (SECTION 26, NO. 10)
  • Distributor Body/Rotor Arm: Set Position Using Tool (SECTION 18, NO. 25)
  • Distributor Setting Gauge Tool Availability (SECTION 01, NO. 49)
  • CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
  • CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
  • Idle Knock - Replace Fuel Rail Feed Hose Assembly (SECTION 19, NO. 17)
  • Fuel Fail Code 29 - Diagnosis/Repair (SECTION 18, NO. 22)
  • Idle Misfire - Oscilloscope Spark Plug Diagnosis (SECTION 18, NO. 20)
  • VCM Fuel Fail Code 69 - Diagnosis/Repair (SECTION 18, NO. 21)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • 1991 Motor Year - Available Required Tools (SECTION TOL, NO. 30)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
  • Fuel Injector Tester (SECTION TOL, NO. 27)
• Transmission Control Systems
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
  • New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
  • Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
  • JDS User Guide #4050 - Subsections And Supplements (SECTION JDS, NO. 39)
  • JDS Software Issue 4050 - New Software/Operations (SECTION JDS, NO. 57)
  • JDS Adapter Kit (SECTION JDS, NO. 55)
• Vacuum Pumps/Lines/Tanks/Water Trap
  • Hydraulic Valve Block Leaking: Port Plug Tightening (SECTION 66, NO. 19)
• Warning Systems
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
• Wheel Alignment
  • Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
• Wheel Hubs
  • Rear Hub Master Spacer/Bearing Tool Availability (SECTION 64, NO. 11)
  • Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
• Wheels & Tire System
  • PIRELLI P5 Discontinued - Replace With P4000 (SECTION 04, NO. 21)
  • Rear Hub Master Spacer/Bearing Tool Availability (SECTION 64, NO. 11)
  • Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
  • Tire Pressure Correction For Maximum Ride Comfort (SECTION 04, NO. 4)
• Window Motors & Regulators
  • Windshield Damage Diagnostic Aid (JAGA501-001)
  • Climate Control Panel Vibrating/INTERMITTEN A/C (SECTION 82, NO. 38)
  • Motorized Automatic Diagonal Seat Belts Warranty (SECTION 03, NO. 120)
  • Sunroof Limit Switch Inoperative:Diagnosis Procedure (SECTION 86, NO. 106)
  • 1991 Motor Year Vehicle Changes (SECTION 86, NO. 78)
  • Vehicle Equipped With Alarm Start Up After Storage (SECTION 86, NO. 77)
  • Alarm Fault Code Diagnostic Procedure (SECTION 86, NO. 76)
• Wiper/Washer Systems
  • Removing Transit Wiper Protection At PDI (XJ501-024)
  • Windshield Wiper Smearing -Use Jaguar Cleaning Paste (SECTION 84, NO. 11)
  • Windshield Wiper Streaking/Smearing: New Arm & Blade (SECTION 84, NO. 9)
  • New 7 Liter Washer Fluid Reservoir Installation (SECTION 84, NO. 8)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
  • A/T Defaults To "Limp Mode" In Wet Weather - Repair (SECTION 44, NO. 24)
  • Elect Harness Fails:INTRFRCE W/Steering Col Sup BRKT (SECTION 86, NO. 107)
  • Battery Discharge During Storage - Isolation Switch (SECTION 86, NO. 103)
  • 1991 Motor Year - Available Required Tools (SECTION TOL, NO. 30)