Technical Service Bulletins

• A/C Compressor
  • Air Conditioning (A/C) Inoperative (JLRTB02109NAS1)
• Accessories Control Systems
  • SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
  • I-View Update Instructions V4 (SSM71383)
  • Fuel Sender Unit Fault - Incorrect Diagnosis (SSM51357)
  • Using The Data Refresh Button On VSOH Screen Produces Unexpected Results (SSM71986)
  • Mongoose Update Instructions (SSM71399)
  • Vehicle Communication Device Fails To Communicate To A Vehicle After Update (SSM70058)
  • Buzzing/Knocking Noise After Start Or With Ignition On - Adaptive Speed Control Module - Repair Procedure (SECTION 100, NO. 24)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
  • New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
  • New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
• Accessory Drive Belts
  • Chirping Noise From Accessory Drive Belt - Misaligned Belt - Replace FEAD TENSIONER (303-59)
  • Possible Alternator Mounting Bracket Contact - Replace Front Auxiliary Drive Belt - Service Action S490 (SECTION 303, NO. S490)
• Air Bag, SRS
  • Counterfeit Airbags - Essential Vigilance In All Jaguar Land Rover Networks (LAB 00050)
  • Counterfeit Airbags - Essential Vigilance In All Jaguar Land Rover Networks (JAB00044)
• Anti-Lock Brakes
  • SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
• Anti-Theft Systems
  • Unable To Lock Vehicle With Remote Key Fob - Repair Procedure (JTB00106)
  • Door Latch Issues - Door Ajar Switch Now Available Separately - Replacement Procedure (SECTION 501, NO. 54)
• Automatic Trans
  • Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
  • Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
  • I-View Update Instructions V4 (SSM71383)
  • DA-Dongle/DA-Vina J2534/St512 Update Instructions V5 (SSM71361)
  • Using The Data Refresh Button On VSOH Screen Produces Unexpected Results (SSM71986)
  • Unable To Communicate With Pcm On Legacy Jaguar Vehicles Using DVD133 (SSM63597)
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • Mongoose Update Instructions (SSM71399)
  • SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
  • Remanufactured W5A-580 Transmission - Harsh Shifts - Install Revised Valve Body (307-22)
• Auxiliary Emission Control Systems
  • A Vehicle Which Does Not Pass State Inspection In CALIFORNIA (SSM72805)
  • Vehicle Communication Device Fails To Communicate To A Vehicle After Update (SSM70058)
  • Fuel Smell Or DTC P0455 Stored - EVAP System - Repair Procedure (303-63)
  • Part-Load Engine Breather - Partial Blockage Of RESTRICTOR - Scheduled Cleaning - Service Action S474 (600-03)
  • Check Engine Mil Illuminated - DTC P0442, P0455, P0446 - Replace Canister Control Valve (SECTION 303, NO. 46)
  • Corroded Pipe For Canister Close Valve - Replace Pipe - Service Action S837 (SECTION 303, NO. S837)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
• Axle Shafts
  • Front Axle Shafts - Check Retention In CV Joint - Service Action S930 (XT205-S930)
• Body Interior
  • SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
  • Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Buzzing/Knocking Noise After Start Or With Ignition On - Adaptive Speed Control Module - Repair Procedure (SECTION 100, NO. 24)
• Brakes Control Systems
  • Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
  • I-View Update Instructions V4 (SSM71383)
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • Mongoose Update Instructions (SSM71399)
  • Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
  • New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
• Charging Systems
  • Mandatory Software Update For The JLR MIDTRONICS Exp-1080 Battery Tester (JAB00027)
  • Possible Alternator Mounting Bracket Contact - Replace Front Auxiliary Drive Belt - Service Action S490 (SECTION 303, NO. S490)
• Communication Devices
  • Vehicle Communication Device Fails To Communicate To A Vehicle After Update (SSM70058)
  • Jaguar Cellular Telephone - AUDIOTRONICS Technical Hotline (SECTION 419, NO. 02)
• Cooling System (Mechanical)
  • 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
  • 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
  • All Chain Driven Water Pumps (TT003-13)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
• Cruise Control Systems
  • Buzzing/Knocking Noise After Start Or With Ignition On - Adaptive Speed Control Module - Repair Procedure (SECTION 100, NO. 24)
• Differentials & Drive Axles
  • Shaft Protector - Tool No 205-272-01 (SECTION 1, NO. 116)
• Engine Control Systems
  • Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74982)
  • SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
  • Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
  • A Vehicle Which Does Not Pass State Inspection In CALIFORNIA (SSM72805)
  • Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
  • I-View Update Instructions V4 (SSM71383)
  • DA-Dongle/DA-Vina J2534/St512 Update Instructions V5 (SSM71361)
  • Using The Data Refresh Button On VSOH Screen Produces Unexpected Results (SSM71986)
  • Symptom Driven Diagnostics (SDD) Getting Started Guide (SSM71898)
  • Unable To Communicate With Pcm On Legacy Jaguar Vehicles Using DVD133 (SSM63597)
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • Mongoose Update Instructions (SSM71399)
  • Vehicle Communication Device Fails To Communicate To A Vehicle After Update (SSM70058)
  • SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
  • Ids DVD127 - New Diagnostic 'Session REWIND' Feature (SSM52017)
  • Vehicle Stall Questionnaire - Gasoline Models (SSM46817)
  • Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
  • Concerns About DTC Processing Using SDD (SSM48758)
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Background Download Icon 'Software Update Should Be PERFORMED' (SSM46877)
  • Legacy Jaguar Vehicles - Advice For Viewing DTC'S With SDD (SSM45956)
  • Windows XP Professional-Service Pack 2 & Internet Explorer V6.0 (SSM41093)
  • Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
  • Fuel Smell Or DTC P0455 Stored - EVAP System - Repair Procedure (303-63)
  • Buzzing/Knocking Noise After Start Or With Ignition On - Adaptive Speed Control Module - Repair Procedure (SECTION 100, NO. 24)
  • Hesitation When Cold - Supercharged AJ 27 Engines - REFLASH ECM (SECTION 303, NO. 53)
  • "Restricted Performance" Displayed On Message Center - AJ27 SC Engines (SECTION 303, NO. 49)
  • Check Engine Mil Illuminated - DTC P0442, P0455, P0446 - Replace Canister Control Valve (SECTION 303, NO. 46)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
  • New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
  • New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
• Entertainment Systems
  • Premium Sound System - Poor Mid-Range Speaker Performance - Incorrect Speakers Installed - Replace Speakers (415-09)
  • Audio System Repair - New Address Information (SECTION 3, NO. 165)
• Exhaust
  • Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
• Exterior Body Panels
  • Service Action: Fuel Filler Cap Difficult To Install/Check Engine Mil On - Revised Fuel Filler Cap (S509)
  • Fuel Vapor Odor In Interior - Convertible Models Only - Repair Procedure (303-61)
• Fuel System
  • Vehicle Stall Questionnaire - Gasoline Models (SSM46817)
  • Service Action: Fuel Filler Cap Difficult To Install/Check Engine Mil On - Revised Fuel Filler Cap (S509)
  • Loss Of Engine Performance - Intake Ducts Loose - Install Revised Parts (303-57)
• Gauges & Instrument Panels
  • 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
  • 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
  • Fuel Sender Unit Fault - Incorrect Diagnosis (SSM51357)
  • Door Latch Issues - Door Ajar Switch Now Available Separately - Replacement Procedure (SECTION 501, NO. 54)
• Headlights
  • Headlamp Internal Condensation - Acceptable Levels - Repair Guidelines (417-10)
  • Condensation Build-Up - Headlamp Assembly - Install Revised Lens (SECTION 417, NO. 06)
  • Headlamp Misting - Improve Ventilation - Repair Procedure (SECTION 417, NO. 05)
• Horns
  • Horns - Poor Sound Quality/Failure - Install Modified Horn And Bracket Assembly (413-06)
• HVAC Control Systems
  • Air Conditioning - Refrigerant Circuit - Leak Reporting (SECTION 3, NO. 170)
• Infotainment
  • Alpine Navigation System - DVD-Driven Diagnosis - Repair (419-11)
  • Navigation System Exchange Program - V8 XJ Series And XK Range (SECTION 6, NO. 97)
  • Alpine Navigation System - DVD-Driven Diagnosis - Repair (SECTION 419, NO. 11)
• Interior/Exterior Trim
  • Approved Cleaning Products By AUTOGLYM (JAGA100-001)
  • Door Trim Panel Loose Or Adrift - Upper Rear Retainer Clip Bracket - Repair (501-57)
  • Wood Veneer Repair Program (SECTION 3, NO. 158)
• Lubrication System
  • Oil Leaks From Oil Filter - Filter Loosens - Revised Tightening Method (SECTION 303, NO. 51)
• Manual Steering
  • Power Steering Reservoir Replacement (211-007)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • AJV6 / AJV8 Engines - Aluminum Component Thread Repair (JTB00136)
  • Start-Up And Idle Rattle - Primary Or Secondary Chain TENSIONER - Replace (303-68)
  • Oil Leaks From Oil Filter - Filter Loosens - Revised Tightening Method (SECTION 303, NO. 51)
  • Possible Alternator Mounting Bracket Contact - Replace Front Auxiliary Drive Belt - Service Action S490 (SECTION 303, NO. S490)
• Procedures
  • Calibration And As-Built Servers Requires Maintenance Which Will Involve The Server Being Offline (SSM75440)
  • Lower Than Actual Compression Figures Using The K00825-0/JLR-4425 COMPRESSIOR Tester Kit (SSM75380)
  • Use Of Non Approved Jaguar Land Rover Anti Bacterial Fogging Agents (SSM75126)
  • Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74982)
  • Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74881)
  • SDD Software Update Icon Is Displayed And When Trying To Update 'No Update AVAILABLE' Is Displayed (SSM74809)
  • SDD Software Update Icon Is Displayed And When Trying To Update 'No Update AVAILABLE' Is Displayed (SSM74805)
  • Required Internet Option Setting To Correct Security Update For JLR Server Access (SSM74720)
  • JLR VCI Fails To Complete The Firmware Update On SDD 159.01 (SSM74701)
  • Error Code 903 - 'Incorrect Service IDENTIFICATION' When Updating Vehicle Module Software Using SDD (SSM74542)
  • Unable To Log Into SDD And Pathfinder (SSM74324)
  • Unable To Install Or Update Pathfinder On Approved Diagnostic Equipment (SSM74010)
  • Unable To Update Approved Diagnostic Software Due To Lack Of Available Storage Space (SSM73696)
  • Unable To Install Or Update Pathfinder On Devices With 256GB Solid State Drive (SSM74010)
  • Installing Approved Diagnostic Software Applications (SSM74011)
  • Notice - Essential Maintenance For Calibration And As-Built Servers (SSM74002)
  • Unable To Login To Pathfinder (SSM73894)
  • Unable To Login To Symptom Driven Diagnostics (SDD) And Pathfinder (SSM73894)
  • SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
  • Use Of Inline Diagnostic Unit 2 (IDU2) And Noise, Vibration And Harness (NVH) Sensor (SSM73431)
• Restraints Control Systems
  • Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
  • I-View Update Instructions V4 (SSM71383)
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • Mongoose Update Instructions (SSM71399)
  • Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Occupancy Sensing System - Activation Procedure - Service Action T836 (501-T836)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
  • New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
• Schedule
  • Scheduled Maintenance Program - 2001 My Vehicles (SECTION 6, NO. 87)
• Seats
  • Electrical Seat Inoperative Or Operation Noise / Judder (JTB00027 (VERSION 2))
  • Approved Cleaning Products By AUTOGLYM (JAGA100-001)
  • Driver Or Passenger Seat Module (DSM/PSM) Lid - Damaged Or Loose - Lids Available Separately (419-17)
  • Occupancy Sensing System - Activation Procedure - Service Action T836 (501-T836)
• Starter
  • Mandatory Software Update For The JLR MIDTRONICS Exp-1080 Battery Tester (JAB00027)
  • Batteries - Use Of Interstate Batteries (SECTION 3, NO. 174)
  • Intermittently Discharged Battery - Diagnostic Procedure (SECTION 414, NO. 06)
  • Micro 490 Battery Tester - Jaguar Recommended (SECTION 1, NO. 112)
• Steering Column
  • Noise When Turning Steering Wheel (JTB00034 (VERSION 2))
• Steering Control Systems
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
• Suspension Control Systems
  • I-View Update Instructions V4 (SSM71383)
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • Mongoose Update Instructions (SSM71399)
  • Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
• System
  • SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
  • Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
  • A Vehicle Which Does Not Pass State Inspection In CALIFORNIA (SSM72805)
  • Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
  • I-View Update Instructions V4 (SSM71383)
  • DA-Dongle/DA-Vina J2534/St512 Update Instructions V5 (SSM71361)
  • Using The Data Refresh Button On VSOH Screen Produces Unexpected Results (SSM71986)
  • Symptom Driven Diagnostics (SDD) Getting Started Guide (SSM71898)
  • Unable To Communicate With Pcm On Legacy Jaguar Vehicles Using DVD133 (SSM63597)
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • Mongoose Update Instructions (SSM71399)
  • Ids DVD127 - New Diagnostic 'Session REWIND' Feature (SSM52017)
  • Vehicle Stall Questionnaire - Gasoline Models (SSM46817)
  • Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
  • Concerns About DTC Processing Using SDD (SSM48758)
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Background Download Icon 'Software Update Should Be PERFORMED' (SSM46877)
  • Legacy Jaguar Vehicles - Advice For Viewing DTC'S With SDD (SSM45956)
  • Windows XP Professional-Service Pack 2 & Internet Explorer V6.0 (SSM41093)
  • Service Action: Fuel Filler Cap Difficult To Install/Check Engine Mil On - Revised Fuel Filler Cap (S509)
  • Fuel Smell Or DTC P0455 Stored - EVAP System - Repair Procedure (303-63)
  • Buzzing/Knocking Noise After Start Or With Ignition On - Adaptive Speed Control Module - Repair Procedure (SECTION 100, NO. 24)
  • Fuel Vapor Odor In Interior - Convertible Models Only - Repair Procedure (303-61)
  • Hesitation When Cold - Supercharged AJ 27 Engines - REFLASH ECM (SECTION 303, NO. 53)
  • "Restricted Performance" Displayed On Message Center - AJ27 SC Engines (SECTION 303, NO. 49)
  • Check Engine Mil Illuminated - DTC P0442, P0455, P0446 - Replace Canister Control Valve (SECTION 303, NO. 46)
  • Corroded Pipe For Canister Close Valve - Replace Pipe - Service Action S837 (SECTION 303, NO. S837)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
  • New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
  • Micro 490 Battery Tester - Jaguar Recommended (SECTION 1, NO. 112)
  • New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
• Transmission Control Systems
  • Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
  • Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
  • I-View Update Instructions V4 (SSM71383)
  • DA-Dongle/DA-Vina J2534/St512 Update Instructions V5 (SSM71361)
  • Unable To Communicate With Pcm On Legacy Jaguar Vehicles Using DVD133 (SSM63597)
  • Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
  • Mongoose Update Instructions (SSM71399)
  • SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
  • Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
  • Concerns About DTC Processing Using SDD (SSM48758)
  • Changes To Calibration And As-Built Package V61 Or Greater. (SSM47397)
  • Legacy Jaguar Vehicles - Advice For Viewing DTC'S With SDD (SSM45956)
  • Shift Quality Issues/Harsh Engagement With Engine Cold - ZF 5HP26 - Install New Transmission Control Module (307-14)
  • New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
  • New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
  • New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
• Warning Systems
  • Door Latch Issues - Door Ajar Switch Now Available Separately - Replacement Procedure (SECTION 501, NO. 54)
• Wheels & Tire System
  • Vibration/Shimmy - Tire Radial Force Variation - Optimizing Wheel And Tires (SECTION 204, NO. 17)
  • Service Action S835 - PIRELLI 20-Inch Tire - Exchange Program (SECTION 204, NO. S835)
  • Use Of Aftermarket Wheels & Tires - No Recommended - Effect On Warranty (SECTION 6, NO. 88)
• Window Motors & Regulators
  • Windshield Damage Diagnostic Aid (JAGA501-001)
• Wiper/Washer Systems
  • Windshield Wiper - Streaking Or Juddering - Repair Policy (SECTION 501, NO. 27)