Technical Service Bulletins

• A/C Compressor
  • A/C System Additives (24-003-03)
  • R-12 To R-134A A/C Adaptation Service Procedure (24-01-95 REV. A)
  • R-134A Refrigerant Leak Detection (24-13-94)
  • A/C Moan/Hum - R134A Systems: Refrigerant Recharging (24-09-94)
• Anti-Lock Brakes
  • Diagnostic Manual Revision - TEVES Brake Diagnostics (05-17-94)
  • Abs Pump Motor Circuit Fault: Replacement Abs Module (05-08-94)
  • Rough Engine Idle Vehicles With Abs (05-18-93)
• Anti-Theft Systems
  • Tailgate Hinge Corrodes/Binds:New Tailgate Hinge (23-68-95)
• Automatic Trans
  • Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
  • Automatic Transmission Fluid Usage ATF+4 (Type 9602) (21-16-99)
  • RWD - Automatic Trans Identification Procedures (21-20-95 REV. A)
  • Checking ATF Levels On RWD Vehicles (21-20-94)
  • Transmission Diagnostic Reference Supplement (21-17-94)
  • Delayed Trans Engagement/Torque Converter Drain Back (21-08-94)
  • Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
  • Engine Coolant Recommendations (07-05-93)
• Auxiliary Emission Control Systems
  • Flash Programming Failure Recovery (18-32-98)
  • Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
• Body Interior
  • Flash Programming Failure Recovery (18-32-98)
• Brakes Control Systems
  • Diagnostic Manual Revision - TEVES Brake Diagnostics (05-17-94)
  • Abs Pump Motor Circuit Fault: Replacement Abs Module (05-08-94)
  • Rough Engine Idle Vehicles With Abs (05-18-93)
• Clutch
  • Clutch Slips - Insufficient Slave Cylinder Clearance (06-03-94)
• Cooling System (Mechanical)
  • 2.5L & 4.0L Rear Main Oil Seal Service (09-04-96)
  • 2.5L Or 4.0L Valve Seal Identification (09-09-95)
  • Water INJESTION - Improved Water Fording Capability (14-07-94)
  • Engine Coolant Recommendations (07-05-93)
• Differentials & Drive Axles
  • Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
  • Engine Coolant Recommendations (07-05-93)
• Engine Control Systems
  • Flash Programming Failure Recovery (18-32-98)
  • Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
  • Diagnostic Manual Revision - Information Corrected (18-19-93)
• Exhaust
  • 2.5L - Outer Exhaust Manifold Studs Breaking (11-07-98 REV. A)
• Frames, Subframes & Crossmembers
  • Chalky Residue On Black Plastic Body Components (23-03-97)
• Fuel System
  • Diagnostic Manual Revision - Information Corrected (18-19-93)
• Fuses & Circuit Breakers
  • Wire Splice Repairs (08-06-00)
  • Use Of Brake Parts Cleaner On Electrical Connectors (08-11-94)
• HVAC Control Systems
  • A/C System Additives (24-003-03)
  • R-12 To R-134A A/C Adaptation Service Procedure (24-01-95 REV. A)
  • R-134A Refrigerant Leak Detection (24-13-94)
  • A/C Moan/Hum - R134A Systems: Refrigerant Recharging (24-09-94)
  • A/C Compressor Noise:Revised Valve Plate Assembly (24-27-93)
• Ignition System
  • Intermittent Engine Miss, Hard/No Start, Rough Idle (18-34-95)
  • Water INJESTION - Improved Water Fording Capability (14-07-94)
• Interior/Exterior Trim
  • Chalky Residue On Black Plastic Body Components (23-03-97)
  • Tailgate Hinge Corrodes/Binds:New Tailgate Hinge (23-68-95)
• Lubrication System
  • 2.5L & 4.0L Rear Main Oil Seal Service (09-04-96)
  • 2.5L Or 4.0L Valve Seal Identification (09-09-95)
  • Water INJESTION - Improved Water Fording Capability (14-07-94)
  • Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
  • Engine Coolant Recommendations (07-05-93)
• Mechanical
  • 2.5L - Outer Exhaust Manifold Studs Breaking (11-07-98 REV. A)
  • 2.5L & 4.0L Rear Main Oil Seal Service (09-04-96)
  • Intermittent Engine Miss, Hard/No Start, Rough Idle (18-34-95)
  • 2.5L Or 4.0L Valve Seal Identification (09-09-95)
  • Piston Knock At Idle: New Coated Pistons (09-08-94)
  • Water INJESTION - Improved Water Fording Capability (14-07-94)
  • Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
  • 2.5L & 4.0L New Coated Pistons (09-19-93)
• Mechanical - Hydraulic
  • Brake Noise Information Guide (05-09-96)
  • Front Disc Brake Pad Rattle: New Brake Pads (05-04-94 REV. A)
  • Carbon Buildup On Top Of Piston - Fuel INJ. Cleaner (09-21-93)
  • Engine Coolant Recommendations (07-05-93)
• Passive Restraints
  • Child Seat Tether Anchor Installation (23-35-99 REV.A)
• Seats
  • Child Seat Tether Anchor Installation (23-35-99 REV.A)
  • UNDERHOOD Rattle/Knocking Noise - Hood Support Rod (23-31-95)
• Starter
  • 2.5L Starter Motor Service: New Replacement Motors (08-36-94)
  • Water INJESTION - Improved Water Fording Capability (14-07-94)
• Sun Roof/T-Top/Convertible Top
  • Tailgate Hinge Corrodes/Binds:New Tailgate Hinge (23-68-95)
  • UNDERHOOD Rattle/Knocking Noise - Hood Support Rod (23-31-95)
  • Soft Top Appears Loose - New Spreader Bar (23-18-95)
• System
  • Flash Programming Failure Recovery (18-32-98)
  • Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
  • 2.5L & 4.0L Rear Main Oil Seal Service (09-04-96)
  • Intermittent Engine Miss, Hard/No Start, Rough Idle (18-34-95)
  • 2.5L Or 4.0L Valve Seal Identification (09-09-95)
  • Water INJESTION - Improved Water Fording Capability (14-07-94)
  • Diagnostic Manual Revision - Information Corrected (18-19-93)
• Transmission Control Systems
  • Flash Programming Failure Recovery (18-32-98)
  • Oil Seepage - New Speed Sensor/Speedo ADAPTOR Repair (21-08-95)
  • Transmission Diagnostic Reference Supplement (21-17-94)
  • Speed Sensor Oil Leakage - Speed Sensor Oil Leakage (21-14-94)
• Wheels & Tire System
  • Tire & Wheel RUNOUT - Specifications (22-01-97)
• Window Motors & Regulators
  • Tailgate Hinge Corrodes/Binds:New Tailgate Hinge (23-68-95)
  • UNDERHOOD Rattle/Knocking Noise - Hood Support Rod (23-31-95)
  • Excessive Door Window Effort (23-26-95)
  • Soft Top Appears Loose - New Spreader Bar (23-18-95)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Wire Splice Repairs (08-06-00)
  • Use Of Brake Parts Cleaner On Electrical Connectors (08-11-94)