Technical Service Bulletins

• A/C Compressor
  • A/C System Additives (24-003-03)
  • A/C System Leak Detection (24-009-02)
  • A/C Evaporator Freeze Up (24-13-99)
• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
• Air Bag, SRS
  • Airbag On-Off Switches (08-37-99)
  • Driver Airbag Trim Cover Service (19-009-01)
  • Airbag/Clock Spring Service (08-010-01)
  • Non-Deployed Airbag Handling Procedures (08-27-00)
  • Erratic I/P Operation Intermittent Air Bag Light On (08-15-99)
  • NHTSA Authorized Airbag Deactivation For Medical (08-32-97)
• Anti-Lock Brakes
  • Abs 25 Way Connector Repair (08-19-98)
• Anti-Theft Systems
  • Steering Column Mounted Sentry Anti-Theft Devices (08-05-98)
  • Door Latch Adjustment - INOP Door Locks, Lock Binds (23-03-98)
• Automatic Trans
  • Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
  • Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
  • Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
  • RTV Use On Corporate Axle (03-08-00)
  • Buzz/Whine/Moan From Cold Trans. When In Reverse (21-08-99)
  • Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
  • Universal Joint Noise (03-05-98)
  • 8 1/4 - 9 1/4 Axle Lubricant & Sealing Requirements (03-02-98)
  • 4.0L Eng. - Driveline Vibration, Speeds Over 60 Mph (03-01-98)
  • Aw-4 Trans - Speedometer Gear Adapter Alignment (08-01-98)
  • Service Manual Revisions - November, 1997 (26-11-97)
• Auxiliary Emission Control Systems
  • Evaporative Systems Service (25-001-04)
  • Flash Programming Failure Recovery (18-32-98)
  • Additional Diagnostics For DTC'S Caused By An Evaporative System Leak (25-004-01)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • Engine Spark Knock During Acceleration (18-05-00 REV. G)
  • Misdiagnosed Leak Detection Pump System (18-01-00)
  • DRB III Leak Detection Pump (LDP) Monitor Test (18-17-97)
  • Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
  • Erroneous Mil Illumination With DTC $24 (P0107) (18-08-00)
  • Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
  • Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
  • OBDII Misfire Monitor - Code & Diagnosis (18-31-97)
  • Pcm Service Caution - Charging System Set To 0 Volts (18-21-98)
  • DTC $B7 Leak Detection Pump Solenoid Circuit (18-36-97)
  • Service Manual Revisions (26-12-97)
• Axle Shafts
  • RTV Use On Corporate Axle (03-08-00)
  • Rear Brake Clunk/Thump When Brakes Are Applied (05-05-00)
  • Universal Joint Noise (03-05-98)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Flash Programming Failure Recovery (18-32-98)
  • A/C Evaporator Freeze Up (24-13-99)
• Brakes Control Systems
  • Abs 25 Way Connector Repair (08-19-98)
• Clutch
  • Universal Joint Noise (03-05-98)
• Cooling Fan
  • Service Manual Revisions - November, 1997 (26-11-97)
• Cooling System (Mechanical)
  • 4.0L Engines - Fan Viscous Drive Contacts Radiator (07-03-98)
• Differentials & Drive Axles
  • RTV Use On Corporate Axle (03-08-00)
  • Rear Brake Clunk/Thump When Brakes Are Applied (05-05-00)
  • Universal Joint Noise (03-05-98)
  • 8 1/4 - 9 1/4 Axle Lubricant & Sealing Requirements (03-02-98)
• Driveshaft & Universal Joints
  • RTV Use On Corporate Axle (03-08-00)
  • Rear Brake Clunk/Thump When Brakes Are Applied (05-05-00)
  • Universal Joint Noise (03-05-98)
• Electronic Steering
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
  • Front Shock Absorber Rattle/Knock (02-08-99)
• Electronic Suspension
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
  • Front Shock Absorber Rattle/Knock (02-08-99)
• Engine Control Systems
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Flash Programming Failure Recovery (18-32-98)
  • Generic Scan Tool (GST) (18-012-01)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • Engine Spark Knock During Acceleration (18-05-00 REV. G)
  • Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
  • Erroneous Mil Illumination With DTC $24 (P0107) (18-08-00)
  • Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
  • Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
  • OBDII Misfire Monitor - Code & Diagnosis (18-31-97)
  • Pcm Service Caution - Charging System Set To 0 Volts (18-21-98)
  • Fuel Pressure Gauge Adapter Usage (14-03-98)
  • DTC $B7 Leak Detection Pump Solenoid Circuit (18-36-97)
  • Service Manual Revisions (26-12-97)
  • Service Manual Revisions - November, 1997 (26-11-97)
• Entertainment Systems
  • Recordable Compact Disc Used In Automotive Cd Player (08-11-00)
• Exhaust
  • 2.5L - Outer Exhaust Manifold Studs Breaking (11-07-98 REV. A)
  • Exhaust Squeak - Replace Exhaust Hanger/Clamp (11-04-98)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Floor Plan Corrosion (23-026-02)
  • Fuel Tank Rattling/Gurgling Between 3/4 & Full (14-06-98)
  • Service Manual Revisions - November, 1997 (26-11-97)
• Exterior Lights
  • Headlamp Flicker When Cooling Fan Or A/C Cycles On (08-34-99)
  • Service Manual Revisions - November, 1997 (26-11-97)
• Frames, Subframes & Crossmembers
  • Floor Plan Corrosion (23-026-02)
• Front Suspension
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
  • Front Shock Absorber Rattle/Knock (02-08-99)
  • Rear Suspension - New Leaf Spring Retainer Clamp (02-03-99)
• Fuel System
  • Fuel Pressure Gauge Adapter Usage (14-03-98)
• Fuses & Circuit Breakers
  • Wire Splice Repairs (08-06-00)
  • Power Distribution Center Service (08-07-99)
• Gauges & Instrument Panels
  • Erratic I/P Operation Intermittent Air Bag Light On (08-15-99)
  • Aw-4 Trans - Speedometer Gear Adapter Alignment (08-01-98)
• Headlights
  • Headlamp Flicker When Cooling Fan Or A/C Cycles On (08-34-99)
  • Service Manual Revisions - November, 1997 (26-11-97)
• HVAC Control Systems
  • A/C System Additives (24-003-03)
  • A/C System Leak Detection (24-009-02)
  • A/C Evaporator Freeze Up (24-13-99)
  • 2.5L/4.0L Eng: A/C Refrigerant Leaks - Information (24-13-97)
  • Air Conditioning Ducts Emit Odor (24-11-97)
• Ignition System
  • Poor DRIVEABILITY With High DRIVEABILITY Index Fuel (14-08-97)
• Interior/Exterior Trim
  • Driver Airbag Trim Cover Service (19-009-01)
  • Engine Compartment Noise Air/Water Leak (23-66-97)
• Interior/Illumination Lights
  • Headlamp Flicker When Cooling Fan Or A/C Cycles On (08-34-99)
• Locking Hubs
  • Front Shock Absorber Rattle/Knock (02-08-99)
  • Universal Joint Noise (03-05-98)
• Lubrication System
  • Service Manual Revisions - November, 1997 (26-11-97)
• Manual Steering
  • Front Shock Absorber Rattle/Knock (02-08-99)
  • Service Manual Revisions - November, 1997 (26-11-97)
• Manual Trans
  • RTV Use On Corporate Axle (03-08-00)
  • Universal Joint Noise (03-05-98)
  • 8 1/4 - 9 1/4 Axle Lubricant & Sealing Requirements (03-02-98)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • 2.5L - Outer Exhaust Manifold Studs Breaking (11-07-98 REV. A)
  • OBDII Misfire Monitor - Code & Diagnosis (18-31-97)
  • Poor DRIVEABILITY With High DRIVEABILITY Index Fuel (14-08-97)
  • Service Manual Revisions - November, 1997 (26-11-97)
• Mechanical - Hydraulic
  • Disc Brake Rotor Pulsation (05-03-98 REV. A)
  • Brake Click After Direction Change - New Brake Pad (05-02-98)
• Mirrors
  • Outside Rearview Mirror Glass Replacement (23-34-00)
• Paint & Coatings
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Floor Plan Corrosion (23-026-02)
• Passive Restraints
  • Child Seat Tether Anchor Installation (23-35-99 REV.A)
  • Front Shock Absorber Rattle/Knock (02-08-99)
• Rear Suspension
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
  • Front Shock Absorber Rattle/Knock (02-08-99)
  • Rear Suspension - New Leaf Spring Retainer Clamp (02-03-99)
• Restraints Control Systems
  • Airbag On-Off Switches (08-37-99)
  • Erratic I/P Operation Intermittent Air Bag Light On (08-15-99)
• Schedule
  • Service Manual Revisions - November, 1997 (26-11-97)
• Seats
  • Child Seat Tether Anchor Installation (23-35-99 REV.A)
  • Front Seat Squeak - Isolator & Seat Lubrication (23-21-98)
• Starter
  • Poor DRIVEABILITY With High DRIVEABILITY Index Fuel (14-08-97)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
  • Front Shock Absorber Rattle/Knock (02-08-99)
• Steering Gear
  • Front Shock Absorber Rattle/Knock (02-08-99)
• Steering Linkage
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
  • Front Shock Absorber Rattle/Knock (02-08-99)
• Suspension Control Systems
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• System
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Flash Programming Failure Recovery (18-32-98)
  • Generic Scan Tool (GST) (18-012-01)
  • Additional Diagnostics For DTC'S Caused By An Evaporative System Leak (25-004-01)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • Engine Spark Knock During Acceleration (18-05-00 REV. G)
  • Misdiagnosed Leak Detection Pump System (18-01-00)
  • DRB III Leak Detection Pump (LDP) Monitor Test (18-17-97)
  • Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
  • Erroneous Mil Illumination With DTC $24 (P0107) (18-08-00)
  • Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
  • Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
  • OBDII Misfire Monitor - Code & Diagnosis (18-31-97)
  • Pcm Service Caution - Charging System Set To 0 Volts (18-21-98)
  • Fuel Pressure Gauge Adapter Usage (14-03-98)
  • DTC $B7 Leak Detection Pump Solenoid Circuit (18-36-97)
  • Service Manual Revisions (26-12-97)
  • Poor DRIVEABILITY With High DRIVEABILITY Index Fuel (14-08-97)
  • Service Manual Revisions - November, 1997 (26-11-97)
• Transfer Case
  • RTV Use On Corporate Axle (03-08-00)
  • Transfer Case Shifter Noise (21-09-98)
  • Universal Joint Noise (03-05-98)
  • 8 1/4 - 9 1/4 Axle Lubricant & Sealing Requirements (03-02-98)
• Transmission Control Systems
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Flash Programming Failure Recovery (18-32-98)
  • Service Manual Revisions - November, 1997 (26-11-97)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Front Shock Absorber Rattle/Knock (02-08-99)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Wire Splice Repairs (08-06-00)