Technical Service Bulletins

• A/C Compressor
  • A/C System Additives (24-003-03)
  • A/C System Leak Detection (24-009-02)
  • SANDEN Air Conditioning Compressor Service Tools (24-22-99)
• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
• Accessory Drive Belts
  • 1700-2400 Rpm Exhaust Drone (11-01-00 REV. A)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
  • Airbag On-Off Switches (08-37-99)
  • Driver Airbag Trim Cover Service (19-009-01)
  • Airbag/Clock Spring Service (08-010-01)
  • Non-Deployed Airbag Handling Procedures (08-27-00)
• Anti-Theft Systems
  • Powertrain Control Module Initialization (08-030-06 REV.A)
  • Remote Keyless Entry (RKE) Programming Procedures (08-007-02)
  • Inoperative Remote Keyless Entry Transmitter (08-16-99 REV. A)
  • Vehicle Start & Stall Or Vehicle No-Start (08-14-99)
• Automatic Trans
  • Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
  • Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
  • Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
  • High Shift Effort When Shifting Out Of A Gear (21-003-01 REV. A)
  • Partial Engagement Of First And/Or Second Gear (21-005-01)
  • RTV Use On Corporate Axle (03-08-00)
• Auxiliary Emission Control Systems
  • Evaporative Systems Service (25-001-04)
  • Flash Programming Failure Recovery (18-32-98)
  • Additional Diagnostics For DTC'S Caused By An Evaporative System Leak (25-004-01)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • Misdiagnosed Leak Detection Pump System (18-01-00)
  • Communications Stop Between JTEC Pcm & Generic Scan (08-39-99)
  • Catalyst Monitor Doesn't Light Mil Or Set Fault Code (25-02-99)
• Axle Shafts
  • RTV Use On Corporate Axle (03-08-00)
• Blowers, Superchargers & Turbochargers
  • 1700-2400 Rpm Exhaust Drone (11-01-00 REV. A)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Flash Programming Failure Recovery (18-32-98)
• Communication Devices
  • Installation Of Radio Transmitting Equipment (08-31-94)
• Cooling Fan
  • 1700-2400 Rpm Exhaust Drone (11-01-00 REV. A)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
  • 1700-2400 Rpm Exhaust Drone (11-01-00 REV. A)
  • Service Publication Updates - March, 2000 (26-03-00)
• Differentials & Drive Axles
  • RTV Use On Corporate Axle (03-08-00)
• Driveshaft & Universal Joints
  • RTV Use On Corporate Axle (03-08-00)
• Electronic Steering
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• Electronic Suspension
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• Engine Control Systems
  • Powertrain Control Module Initialization (08-030-06 REV.A)
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Powertrain Control Module Initialization (08-015-05)
  • 4.0L Multiple Cylinder Misfire (09-003-03)
  • Flash Programming Failure Recovery (18-32-98)
  • Rough Idle At Cold Temperatures (18-013-01)
  • Generic Scan Tool (GST) (18-012-01)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • Service Publication Updates - March, 2000 (26-03-00)
  • Communications Stop Between JTEC Pcm & Generic Scan (08-39-99)
  • Catalyst Monitor Doesn't Light Mil Or Set Fault Code (25-02-99)
• Entertainment Systems
  • Recordable Compact Disc Used In Automotive Cd Player (08-11-00)
• Exhaust
  • Service Publication Updates - March, 2000 (26-03-00)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
  • Revised Fuel Cap Tether (14-003-02)
  • Floor Plan Corrosion (23-026-02)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
• Frames, Subframes & Crossmembers
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Floor Plan Corrosion (23-026-02)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Front End Shimmy After Striking A Bump Or Pothole (02-003-03)
  • Service Publication Updates - March, 2000 (26-03-00)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• Fuel System
  • Revised Fuel Cap Tether (14-003-02)
  • Service Publication Updates - March, 2000 (26-03-00)
• Fuses & Circuit Breakers
  • Wire Splice Repairs (08-06-00)
• Gauges & Instrument Panels
  • Instrument Cluster Gauge Pointers On Wrong Side (08-33-99)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
• HVAC Control Systems
  • A/C System Additives (24-003-03)
  • A/C System Leak Detection (24-009-02)
  • SANDEN Air Conditioning Compressor Service Tools (24-22-99)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Service Publication Updates - March, 2000 (26-03-00)
• Ignition Switch/Steering Lock
  • Ignition Lock Cylinder Service (19-02-00 REV. A)
• Interior/Exterior Trim
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Driver Airbag Trim Cover Service (19-009-01)
• Manual Steering
  • Service Publication Updates - March, 2000 (26-03-00)
• Manual Trans
  • High Shift Effort When Shifting Out Of A Gear (21-003-01 REV. A)
  • Partial Engagement Of First And/Or Second Gear (21-005-01)
  • RTV Use On Corporate Axle (03-08-00)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • 4.0L Multiple Cylinder Misfire (09-003-03)
  • 1700-2400 Rpm Exhaust Drone (11-01-00 REV. A)
• Mechanical - Hydraulic
  • Disc Brake Rotor Pulsation (05-004-01)
• Mirrors
  • Outside Rearview Mirror Glass Replacement (23-34-00)
• Paint & Coatings
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Floor Plan Corrosion (23-026-02)
• Passive Restraints
  • Child Seat Tether Anchor Installation (23-35-99 REV.A)
• Rear Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
  • Airbag On-Off Switches (08-37-99)
• Seats
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Child Seat Tether Anchor Installation (23-35-99 REV.A)
• Starter
  • 1700-2400 Rpm Exhaust Drone (11-01-00 REV. A)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• Steering Linkage
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• Suspension Control Systems
  • Front End Shimmy After Striking A Bump Or Pothole (02-003-03)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• System
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • 4.0L Multiple Cylinder Misfire (09-003-03)
  • Flash Programming Failure Recovery (18-32-98)
  • Rough Idle At Cold Temperatures (18-013-01)
  • Generic Scan Tool (GST) (18-012-01)
  • Additional Diagnostics For DTC'S Caused By An Evaporative System Leak (25-004-01)
  • Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
  • Service Publication Updates - March, 2000 (26-03-00)
  • Misdiagnosed Leak Detection Pump System (18-01-00)
  • Communications Stop Between JTEC Pcm & Generic Scan (08-39-99)
  • Catalyst Monitor Doesn't Light Mil Or Set Fault Code (25-02-99)
• Transfer Case
  • GEARTRAIN Sound Entering Passenger Compartment (21-008-01)
  • RTV Use On Corporate Axle (03-08-00)
• Transmission Control Systems
  • Co-Pilot Support And Correct Cable Usage (18-029-05)
  • Flash Programming Failure Recovery (18-32-98)
• Vacuum Pumps/Lines/Tanks/Water Trap
  • 1700-2400 Rpm Exhaust Drone (11-01-00 REV. A)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
  • Service Publication Updates - March, 2000 (26-03-00)
  • Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Wire Splice Repairs (08-06-00)