Technical Service Bulletins
- A/C Compressor
- Accessories Control Systems
- Air Bag, SRS
- CLOCKSPRING Replacement Due To Airbag Warning Lamp Illumination (X41) Warranty Extension (08-013-17 REV. A)
- CLOCKSPRING Replacement Due To Airbag Warning Lamp Illumination X41 (10 Year Or 150,000 Mile (240,000 Kilometers) Warranty Extension) (08-119-15)
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Anti-Theft Systems
- Automatic Trans
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Flash: Diagnostic Trouble Code DTC P0740 Or P1798 And Automatic Transmission Shift Improvements 1-2 Or 2-3 Cold Shift Improvements (21-018-08 REV. A)
- Flash: Torque Converter Shudder Or 1-2, 2-3 Or 3-4 Upshift Bumps (21-002-07 REV. E)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Flash Powertrain Control Module (Pcm) Mil/Battery Light Illumination (18-036-06)
- Body Interior
- Brakes Control Systems
- Charging Systems
- Collision/Avoidance
- Communication Devices
- Cooling System (Mechanical)
- Cruise Control Systems
- Differentials & Drive Axles
- Engine Control Systems
- Entertainment Systems
- Flash: REW Or REX Radio Software Enhancements (08-026-12)
- RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
- Radio Locks Up (08-014-10)
- Radio Video Disable Update (08-004-10)
- MYGIG Radio Hard Drive Recovery/Update Disc (08-024-08 REV. A)
- Flash: Radio - Temperature Display In Cluster Revert To U.S. Units Intermittently (08-032-07)
- Flash Intermittent Radio Cut Out While Driving (08-053-06)
- Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Cowl Trim Panel Fastener Water Leak (23-034-14 REV. A)
- Premature Fuel Shut Off When Filling Tank (14-004-13)
- Replacing Door, Hood And/Or Tailgate Hinges (23-025-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Repair Procedures For Front Fender Supports (Aka Fender Closure, Front Upper HYDROFORM And Shotguns) (31-006-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
- Oil Canning, Popping, Or Thumping-Like Sound From Front Passenger Area During Body Twist (23-008-07)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Premature Fuel Shut Off When Filling Tank (14-004-13)
- Fuel Spit Back During Refueling (X47 Lifetime Warranty Extension) (14-001-13)
- Fuel Spit Back During Refueling (X32 Warranty Extension Unlimited Time And Mileage) (14-003-12)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
- Gauges & Instrument Panels
- Headlights
- Identification
- Ignition Switch/Steering Lock
- Infotainment
- Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Cowl Trim Panel Fastener Water Leak (23-034-14 REV. A)
- Low Gloss Interior Trim (23-036-07)
- Wind-Like Sound At A-Pillar Of Windshield Frame (23-044-06)
- Water Leak At A-Pillar Due To Windshield Header Seal Adhesive (23-016-07)
- Yes Essentials(R) Stain, Odor, & Static Resistant Fabric Care (23-021-06 REV.A)
- Lubrication System
- Manual Steering
- Mechanical
- Mechanical - Hydraulic
- Paint & Coatings
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Paint Repair - Etching (23-046-07)
- Transit Film Removal (23-043-04)
- Parking Brake System
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Starter
- Steering Column
- Steering Control Systems
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Flash DTC'S C121A / C2205 - Steering Angle Sensor - Not Initialized / Internal (08-010-07)
- STARSCAN(R) Displays A Red "X" For The Steering Angle Sensor (SAS) Module (08-034-06 REV.A)
- STARSCAN(R)/STARMOBILE(tm) ABORT RECOVERY PROCEDURES (18-001-06 REV.A)
- Steering Gear
- Steering Linkage
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Steering Shimmy (02-003-10 REV.A)
- Leak At Steering Damper Due To Orientation Of Damper Rod To Vehicle (19-003-07 REV. A)
- Sun Roof/T-Top/Convertible Top
- Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks (23-037-16)
- Cracked Vinyl Soft Top Window (23-038-15)
- Soft Top Rear Window Zipper Will Not Disengage (23-001-13)
- Hard Top/Soft Top Water Leak Diagnosis (23-041-07)
- Soft Top - Wind Like Sound At Header (23-010-09 REV. A)
- Wind-Like Sound At Outer Ends Of The SUNRIDER Soft Top Windshield Header (23-003-08)
- Rear Lower Corner Of Soft Top May Not Stay Tucked To Rail Retainer On Body (23-037-07)
- Difficulty Releasing Soft Top Plastic Edge Retainers From B-Pillar Area Of Door Frame (23-014-07)
- Modular Hard Top Freedom Panel WATERLEAKS (23-001-07)
- Soft Top Slaps Against Speaker Bar (23-046-06)
- Suspension Control Systems
- System
- Transmission Control Systems
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
- Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
- Window Motors & Regulators
- Whistle-Like Sound Due To Gap Between Leading Edge Of Header Seal And Windshield Frame (23-030-07 REV.A)
- Windshield Frame Header Seal - Butyl Adhesive Squeeze-Out At Top Corners (23-026-07 REV. A)
- Wind-Like Sound At A-Pillar Of Windshield Frame (23-044-06)
- Water Leak At A-Pillar Due To Windshield Header Seal Adhesive (23-016-07)
- Cracked Windshield (23-047-06)
- Wiper/Washer Systems