Technical Service Bulletins

• A/C Compressor
  • Fluid Flushing Requirements (26-003-07)
• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Anti-Theft Systems
  • No Engine Crank Or No Engine Start Due To Electronic Lockup Of The WCM / SKREEM (08-007-08 REV. A)
• Automatic Trans
  • Fluid Flushing Requirements (26-004-12)
  • Extended Warranty - Transmission Oil Cooler Lines May Weep Transmission Fluid At The Hose To Tube Crimp Joints (7 Years Or 70,000 Miles Warranty Extension) (21-006-11)
  • Fluid Flushing Requirements (26-003-07)
  • Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
  • Flash: Diagnostic Trouble Code DTC P0740 Or P1798 And Automatic Transmission Shift Improvements 1-2 Or 2-3 Cold Shift Improvements (21-018-08 REV. A)
  • Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
• Clutch
  • Squeak-Like Sound Due To Manual Transmission Clutch Disc (06-004-07)
• Collision/Avoidance
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Communication Devices
  • Flash: REW Or REX Radio Software Enhancements (08-026-12)
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
• Cruise Control Systems
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Differentials & Drive Axles
  • A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
• Engine Control Systems
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
• Entertainment Systems
  • Flash: REW Or REX Radio Software Enhancements (08-026-12)
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
  • Radio Locks Up (08-014-10)
  • Radio Video Disable Update (08-004-10)
  • Flash: RES Radio Clock Lockup and SDARS Reset (08-006-09)
  • MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
  • MYGIG Radio Hard Drive Recovery/Update Disc (08-024-08 REV. A)
  • Flash: Radio - Cd Loses Last Played Track After A Ignition Switch Cycle (08-019-08)
  • Flash: Radio - Sound Mutes Intermittently When Radio Is In Sat (SIRIUS) Mode (08-008-08)
  • Flash: Audio Speaker Popping-Like Sound During Audio Play (08-030-07)
  • Flash: Radio - Temperature Display In Cluster Revert To U.S. Units Intermittently (08-032-07)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
  • Cowl Trim Panel Fastener Water Leak (23-034-14 REV. A)
  • Premature Fuel Shut Off When Filling Tank (14-004-13)
  • Replacing Door, Hood And/Or Tailgate Hinges (23-025-12)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Repair Procedures For Front Fender Supports (Aka Fender Closure, Front Upper HYDROFORM And Shotguns) (31-006-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Exterior Lamp - Lens Fogging (23-041-06)
• Frames, Subframes & Crossmembers
  • Repair Parts Used For Structural Repairs (31-002-11)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
• Fuel System
  • Premature Fuel Shut Off When Filling Tank (14-004-13)
  • Fuel Spit Back During Refueling (X47 Lifetime Warranty Extension) (14-001-13)
  • Fuel Spit Back During Refueling (X32 Warranty Extension Unlimited Time And Mileage) (14-003-12)
  • Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
• Fuses & Circuit Breakers
  • MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
• Gauges & Instrument Panels
  • Flash: Oil Change Monitor Alerts Prematurely (08-013-08 REV. A)
  • Flash: Radio - Temperature Display In Cluster Revert To U.S. Units Intermittently (08-032-07)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Exterior Lamp - Lens Fogging (23-041-06)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
• Ignition Switch/Steering Lock
  • No Engine Crank Or No Engine Start Due To Electronic Lockup Of The WCM / SKREEM (08-007-08 REV. A)
• Infotainment
  • Radio Video Disable Update (08-004-10)
• Interior/Exterior Trim
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Cowl Trim Panel Fastener Water Leak (23-034-14 REV. A)
  • Center Console Opens When Locked (23-018-09)
  • Low Gloss Interior Trim (23-036-07)
• Lubrication System
  • Fluid Flushing Requirements (26-004-12)
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Fluid Flushing Requirements (26-003-07)
  • 3.8L Engine Oil Seepage Due To Front Timing Cover Surface Porosity (09-008-07)
• Manual Steering
  • Fluid Flushing Requirements (26-004-12)
  • Steering Shimmy (02-003-10 REV.A)
• Mechanical
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Fluid Flushing Requirements (26-003-07)
• Mechanical - Hydraulic
  • Fluid Flushing Requirements (26-004-12)
  • Front Brake Caliper Hose Leak (X71 Warranty Extension) (05-022-17)
  • Fluid Flushing Requirements (26-003-07)
• Paint & Coatings
  • Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Paint Repair - Etching (23-046-07)
• Parking Brake System
  • Add Parking Brake Adjustment To The 30 Month, 30 K Miles Or 50 KKM Service Interval (26-002-08)
• Rear Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Schedule
  • Fluid Flushing Requirements (26-004-12)
• Seats
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Scraping, Clicking Or Squeal Sound From Seat Track (23-003-09)
• Starter
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
  • MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
  • Hard Start/No Start Due To Weak Battery (08-003-08)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
• Steering Control Systems
  • A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
• Steering Gear
  • Steering Shimmy (02-003-10 REV.A)
• Steering Linkage
  • A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Steering Shimmy (02-003-10 REV.A)
• Sun Roof/T-Top/Convertible Top
  • Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks (23-037-16)
  • Cracked Vinyl Soft Top Window (23-038-15)
  • Soft Top Rear Window Zipper Will Not Disengage (23-001-13)
  • Hard Top/Soft Top Water Leak Diagnosis (23-041-07)
  • Soft Top - Wind Like Sound At Header (23-010-09 REV. A)
  • Wind-Like Sound At Outer Ends Of The SUNRIDER Soft Top Windshield Header (23-003-08)
  • Water Leak - Modular Hard Top Freedom Panel (23-050-07)
• System
  • Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
  • Flash: Inability To Data Record (08-018-08)
  • Long Engine Crank Time And/Or Mil Illumination Due To DTC P0340 / P0344 (08-001-08 REV. A)
• Transmission Control Systems
  • Flash: Diagnostic Trouble Code DTC P0740 Or P1798 And Automatic Transmission Shift Improvements 1-2 Or 2-3 Cold Shift Improvements (21-018-08 REV. A)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
• Window Motors & Regulators
  • Whistle-Like Sound Due To Gap Between Leading Edge Of Header Seal And Windshield Frame (23-030-07 REV.A)
  • Windshield Frame Header Seal - Butyl Adhesive Squeeze-Out At Top Corners (23-026-07 REV. A)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)