Technical Service Bulletins

• A/C Compressor
  • Fluid Flushing Requirements (26-003-07)
• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Clock In The Radio Loses Time (08-058-14)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Anti-Theft Systems
  • Flash: Vehicle Theft Alarm Intermittently Sounds, No Start (08-061-11)
• Automatic Trans
  • Fluid Flushing Requirements (26-004-12)
  • Extended Warranty - Transmission Oil Cooler Lines May Weep Transmission Fluid At The Hose To Tube Crimp Joints (7 Years Or 70,000 Miles Warranty Extension) (21-006-11)
  • Fluid Flushing Requirements (26-003-07)
• Auxiliary Emission Control Systems
  • Exhaust Rattle At Idle Speeds (11-002-14)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
• Collision/Avoidance
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Communication Devices
  • Flash: REW Or REX Radio Software Enhancements (08-026-12)
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
• Cruise Control Systems
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Differentials & Drive Axles
  • A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
• Engine Control Systems
  • Flash: Powertrain Diagnostic And System Improvements (18-024-16 REV. B)
  • Exhaust Rattle At Idle Speeds (11-002-14)
  • Flash: Pcm For OBD Readiness For Downstream O2 Slow Response Monitor (18-027-10)
  • Flash: Oil Change Monitor Alerts Prematurely On International Vehicles (08-012-10)
  • Flash: Improper Illumination Of Fuel Saver Indicator Light (FSI) For Manual Transmission Vehicles (08-009-10)
  • Flash: Mil Illumination P1696 - EEPROM Memory Write Denied/Invalid (18-004-10)
• Entertainment Systems
  • Clock In The Radio Loses Time (08-058-14)
  • Flash: REW Or REX Radio Software Enhancements (08-026-12)
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
  • Radio Locks Up (08-014-10)
  • Radio Video Disable Update (08-004-10)
• Exhaust
  • Exhaust Rattle At Idle Speeds (11-002-14)
  • Supplemental Exhaust Shield For Extreme Desert Duty Cycles Off Road (11-002-12)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
  • Cowl Trim Panel Fastener Water Leak (23-034-14 REV. A)
  • Premature Fuel Shut Off When Filling Tank (14-004-13)
  • Replacing Door, Hood And/Or Tailgate Hinges (23-025-12)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Repair Procedures For Front Fender Supports (Aka Fender Closure, Front Upper HYDROFORM And Shotguns) (31-006-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
• Frames, Subframes & Crossmembers
  • Repair Parts Used For Structural Repairs (31-002-11)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
• Fuel System
  • Possible DRIVEABILITY Issues Due To The Winter-Blend Fuel Into The Warmer Season (18-039-20)
  • Premature Fuel Shut Off When Filling Tank (14-004-13)
• Gauges & Instrument Panels
  • Clock In The Radio Loses Time (08-058-14)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
• Infotainment
  • Radio Video Disable Update (08-004-10)
• Interior/Exterior Trim
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Cowl Trim Panel Fastener Water Leak (23-034-14 REV. A)
• Lubrication System
  • Fluid Flushing Requirements (26-004-12)
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Flash: Oil Change Monitor Alerts Prematurely On International Vehicles (08-012-10)
  • Fluid Flushing Requirements (26-003-07)
• Manual Steering
  • Fluid Flushing Requirements (26-004-12)
• Mechanical
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Fluid Flushing Requirements (26-003-07)
• Mechanical - Hydraulic
  • Fluid Flushing Requirements (26-004-12)
  • Front Brake Caliper Hose Leak (X71 Warranty Extension) (05-022-17)
  • Fluid Flushing Requirements (26-003-07)
• Paint & Coatings
  • Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Light To Moderate Paint Surface Imperfections On Factory Applied Paint Finish (23-003-12)
• Rear Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Schedule
  • Fluid Flushing Requirements (26-004-12)
• Seats
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
• Starter
  • RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
• Steering Control Systems
  • A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
• Steering Linkage
  • A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Sun Roof/T-Top/Convertible Top
  • Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks (23-037-16)
  • Cracked Vinyl Soft Top Window (23-038-15)
  • Soft Top Rear Window Zipper Will Not Disengage (23-001-13)
  • Soft Top WINDNOISE At Header (23-004-11)
  • Freedom Top WINDNOISE (23-001-10)
• System
  • Flash: Powertrain Diagnostic And System Improvements (18-024-16 REV. B)
  • Flash: Pcm For OBD Readiness For Downstream O2 Slow Response Monitor (18-027-10)
  • Flash: Mil Illumination P1696 - EEPROM Memory Write Denied/Invalid (18-004-10)
• Transmission Control Systems
  • Flash: Transmission Remains In "Default" Mode After An Engine Start With No DTC (21-007-09 REV. A)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)