Technical Service Bulletins

• Accessories Control Systems
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Driver And Passenger HVAC Blower Air Temperatures Are Not The Same When "Sync" Setting Mode Is Selected And Headlamps Always Stay On. (24-002-14)
  • RHR Radio Software Enhancements (08-027-14)
  • RHR RHW Or RHP Radio Navigation Map Enhancements (08-070-13 REV. C)
  • Flash: Park Assist Setup Display Doesn't Match Option (08-051-13)
  • Flash: Power Liftgate May Not Power Open Or Close (08-005-13)
  • Flash: Secret Key Transfer Results In Negative Response 0X22 Error (08-051-12)
• Accessory Drive Belts
  • Idler Pulley Noise During Cold Start (07-002-15 REV. A)
• Air Bag, SRS
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Anti-Theft Systems
  • Flash: Vehicle Theft Alarm Intermittently Sounds (08-033-12)
  • Flash: Secret Key Transfer Results In Negative Response 0X22 Error (08-051-12)
  • Flash: Intermittent No Start (08-022-12)
• Automatic Trans
  • Fluid Flushing Requirements (26-004-12)
  • Failure Code Change (04-001-17)
  • Flash: ELSD Module Enhancements (21-001-14)
  • Noise Heard When Shifting The Transmission From Drive To Neutral (21-010-12)
• Auxiliary Emission Control Systems
  • Flash: Loss Of Power On Acceleration From Idle And Mil Illumination P0299 Or P049D (18-019-12)
• Body Interior
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Flash: Park Assist Setup Display Doesn't Match Option (08-051-13)
  • Flash: Power Folding Mirrors Unfold While Cranking (08-011-13)
  • Flash: Power Liftgate May Not Power Open Or Close (08-005-13)
• Collision/Avoidance
  • RHR RHW Or RHP Radio Navigation Map Enhancements (08-070-13 REV. C)
  • Flash: Park Assist Setup Display Doesn't Match Option (08-051-13)
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Communication Devices
  • RHR Radio Software Enhancements (08-027-14)
  • RHR RHW Or RHP Radio Navigation Map Enhancements (08-070-13 REV. C)
  • Flash: Hands Free Module Prompts Begin To Play Without Pressing The Phone Or Voice Recognition Button (08-050-12 REV. A)
• Cooling System (Mechanical)
  • Service Bulletin/RRT 07-003-14/14-057 Superseded By Customer Satisfaction Notification (CSN) P49 (07-004-13)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
• Cruise Control Systems
  • Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
• Engine Control Systems
  • Failure Code Change (04-001-17)
  • Flash: Powertrain Diagnostic And System Enhancements (18-110-16)
  • Mil Illumination: P0300, P0302, P0304 Or P0306 (X56 Warranty Extension) (09-009/12)
  • Flash: Transmission Performance Enhancements (21-006-13)
  • Flash: Loss Of Power On Acceleration From Idle And Mil Illumination P0299 Or P049D (18-019-12)
• Entertainment Systems
  • RBZ Or RHB Radio Enhancements (08-086-14 REV. A)
  • RHW RHP Radio Software Enhancements (08-066-13)
  • RHR Radio Software Enhancements (08-027-14)
  • RHW RHP Radio Software Enhancements (08-024-14)
  • RHR RHW Or RHP Radio Navigation Map Enhancements (08-070-13 REV. C)
  • Flash: Vehicle Theft Alarm Intermittently Sounds (08-033-12)
  • RHR Navigation Map Enhancements (08-065-12)
  • Flash: Hard Start, No Start, Long Crank, Drained Battery, RB2 Radio Waking Up And Causing Battery Drain (08-025-12)
• Exterior Body Panels
  • Scan Tool Support Before And After Collision Repair (31-002-16)
  • Blending CLEARCOAT During The Refinish Process (31-002-13)
  • OVERSPRAY Removal (31-001-13)
  • Knocking Sound From Instrument Panel Area Near The A-Pillar (23-022-12 REV. A)
  • Welded Sheet Metal Repairs And Replacements (31-007-12)
  • Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
  • Repair Parts Used For Structural Repairs (31-002-11)
  • Use Of Heat To Straighten Damaged Components (31-001-11)
• Exterior Lights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Driver And Passenger HVAC Blower Air Temperatures Are Not The Same When "Sync" Setting Mode Is Selected And Headlamps Always Stay On. (24-002-14)
• Frames, Subframes & Crossmembers
  • Approved Use Of Weld Through Primers (31-001-22)
  • Repair Parts Used For Structural Repairs (31-002-11)
• Front Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Flash: Service Air Suspension Message And/Or U0415-00 And/Or C159E-15 Set (08-034-12)
• Fuel System
  • Mil Illumination: P0300, P0302, P0304 Or P0306 (X56 Warranty Extension) (09-009/12)
• Gauges & Instrument Panels
  • Leather Instrument Panel (IP) Cover Delaminating - X81 Warranty Extension (23-036-19)
• General Servicing
  • A/C Systems Contain Fluorescent Leak Check Dye In Factory Fill (24-008-18)
• Headlights
  • Exterior Lamp Condensation And Fogging (08-091-14)
  • Driver And Passenger HVAC Blower Air Temperatures Are Not The Same When "Sync" Setting Mode Is Selected And Headlamps Always Stay On. (24-002-14)
• HVAC Control Systems
  • A/C Systems Contain Fluorescent Leak Check Dye In Factory Fill (24-008-18)
• Identification
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Incorrect Registration Code Printed On Registration Certificate (26-003-12)
• Ignition System
  • Flash: Intermittent No Start (08-022-12)
• Infotainment
  • RBZ Or RHB Radio Enhancements (08-086-14 REV. A)
  • RHR Radio Software Enhancements (08-027-14)
  • RHW RHP Radio Software Enhancements (08-024-14)
  • RHR RHW Or RHP Radio Navigation Map Enhancements (08-070-13 REV. C)
  • Flash: Park Assist Setup Display Doesn't Match Option (08-051-13)
  • RHR Navigation Map Enhancements (08-065-12)
  • Navigation Losing Satellite Signal (08-046-12)
• Interior/Exterior Trim
  • Leather Instrument Panel (IP) Cover Delaminating - X81 Warranty Extension (23-036-19)
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
  • Knocking Sound From Instrument Panel Area Near The A-Pillar (23-022-12 REV. A)
• Lubrication System
  • Engine Oil Consumption Guideline (09-007-18 REV. A)
  • Fluid Flushing Requirements (26-004-12)
  • Oil Filter Adapter (OFA) - Pressure Relief Valve Replacement (09-009-18)
  • PENTASTAR Engine Oil Filter Application Reference (09-003-13)
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
• Manual Steering
  • Fluid Flushing Requirements (26-004-12)
• Mechanical
  • Engine Oil Consumption Guideline (09-007-18 REV. A)
  • Oil Filter Adapter (OFA) - Pressure Relief Valve Replacement (09-009-18)
  • Idler Pulley Noise During Cold Start (07-002-15 REV. A)
  • Blue Smoke From Exhaust On Initial Start-Up When Parked Facing Uphill On An Incline (09-002-13)
  • Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Replace Engine (09-006-11)
• Mechanical - Hydraulic
  • Fluid Flushing Requirements (26-004-12)
  • Brake Booster Corrosion - X74 Warranty Extension (05-001-18)
  • Front Brake Squeak/Squeal Noise (05-002-15)
  • Squeal Noise From Front Of Vehicle When Braking (05-005-13)
  • Thumping Noise From Front Wheels When Braking (05-006-12)
• Mirrors
  • Flash: Power Folding Mirrors Unfold While Cranking (08-011-13)
• Rear Suspension
  • Shock Strut Weeping Condition Identification (02-001-15)
  • Rear Shock Absorber Low Speed Rattle Chuckle Noise (17-002-14)
  • Rattle And/Or Clunk Noise From Rear Of The Vehicle Equipped With Load Leveling Suspension (17-005-13)
  • Cleaning Of Rear Air Suspension At Every Engine Oil Change (17-004-13)
  • Squeak And/Or Creak Noise Coming From Rear Of Vehicle (17-002-13)
  • Low Speed Rattle And/Or Chuckle From Rear Of Vehicle Over Uneven Surfaces (17-001-12 REV. A)
  • Flash: Service Air Suspension Message And/Or U0415-00 And/Or C159E-15 Set (08-034-12)
• Restraints Control Systems
  • Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
• Schedule
  • Fluid Flushing Requirements (26-004-12)
• Seats
  • Chirping Or Squeaking Coming From The Second Row Headrest (23-016-16)
  • Replacement Seat Covers And Seat Cover Repairs (31-004-11)
• Starter
  • Flash: Hard Start, No Start, Long Crank, Drained Battery, RB2 Radio Waking Up And Causing Battery Drain (08-025-12)
• Steering Column
  • Steering Wheel Not Centered (02-002-15)
• Steering Linkage
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Sun Roof/T-Top/Convertible Top
  • Creak Or Click Noise From Dual Pane Sunroof (23-013-13)
• Suspension Control Systems
  • Flash: Service Air Suspension Message And/Or U0415-00 And/Or C159E-15 Set (08-034-12)
• System
  • Failure Code Change (04-001-17)
  • Flash: Powertrain Diagnostic And System Enhancements (18-110-16)
  • Mil Illumination: P0300, P0302, P0304 Or P0306 (X56 Warranty Extension) (09-009/12)
  • Flash: Mil Illumination For P0730 And Transmission Shift Enhancements (21-033-14)
  • Flash: Transmission Performance Enhancements (21-006-13)
  • Flash: Service Air Suspension Message And/Or U0415-00 And/Or C159E-15 Set (08-034-12)
  • Flash: Intermittent No Start (08-022-12)
• Transfer Case
  • Flash: ELSD Module Enhancements (21-001-14)
  • Flash: Drivetrain Control Module (DCTM) - Transfer Case Operational Enhancements (21-003-13)
• Transmission Control Systems
  • Failure Code Change (04-001-17)
  • Flash: Mil Illumination For P0730 And Transmission Shift Enhancements (21-033-14)
  • Flash: ELSD Module Enhancements (21-001-14)
  • Flash: Transmission Performance Enhancements (21-006-13)
  • Flash: Drivetrain Control Module (DCTM) - Transfer Case Operational Enhancements (21-003-13)
• Wheel Alignment
  • Steering Wheel Not Centered (02-002-15)
  • Vehicle Pulls Or Leads Right Or Left (02-003-15)
  • Vehicle Leads Or Drifts To The Right (02-003-14)
• Wheel Hubs
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
• Wheels & Tire System
  • Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
  • Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
  • Tire Flat Spotting Identification, Prevention And Resolution (22-002-14 REV. A)
  • Steering Wheel Vibration At Highway Speeds (22-002-13)
  • Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
  • Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
  • Reconditioned Wheel Usage (31-005-11)
• Wiper/Washer Systems
  • Windshield Wiper Blade/Element Maintenance (23-037-15)