Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Loss Of A/C Cooling Hot/Humid - New Condenser/Line (92-2-4)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- 5.0L Eng A/C Compressor Moan - Diagnostic List (90-18-8)
- A/C "O" Ring Usage Table (90-14-8)
- 5.0/5.8L Eng A/C Moan - Diagnostic List (89-10T-7)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- 5.0L Eng A/C Compressor Moan Hot Day - Diag List (89-20-4)
- A/C Spring Lock Connectors Redundant Clip R & I (89-6T-10)
- Accessories Control Systems
- Anti-Lock Brakes
- Anti-Theft Systems
- False Anti-Theft Alarm - New Trunk Lock Cylinder (92-21-1)
- Lubrication Power Seat Tracks (92-2-3)
- Hood Burn Spots Damage: Replacements (91-4-3)
- No Crank - Low State Of Battery Charge (91-10-8)
- Latches - Door - Replacement Required (91-8-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Bent Trunk Cylinder Tab May Falsely Activate Alarm (89-15-2)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Transmission Fluid Usage Chart (98-8-8)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
- AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
- AOD Trans Delay 3-4/4-3 Shift/O'Drive Repeat Repair (91-5-6)
- A4LD/AOD/C6/E40D Trans Harsh/Rough 3-4/4-3 Shift (91-11-14)
- Buzz At Idle/Throttle Tip-In Noise - New Gasket Kit (89-23-6)
- AXOD Trans Extended 3/4 Shift - Separator Plate (89-21-9)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- AOD Trans Change - Use 1989 Main Control Assembly (88-24-3)
- Anti-Theft VIN Identification Labels (88-7-2)
- AOD Trans 3/4 Shift Accumulator No Longer Required (89-4-6)
- AOD Trans Extended 3-4 Shift No Overdrive (90-2-7)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Auxiliary Emission Control Systems
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- 5.0L Eng No/Hard Start/Stalls In Below Freezing Temp (91-11-5)
- 5.0L Eng High Idle/Mil Flashes Intermittently (91-10-6)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Axle Shafts
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Latches - Door - Replacement Required (91-8-4)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Radio "Pop" Noise When Brakes Applied:Brake Circuit (89-16-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Brakes Control Systems
- Charging Systems
- Clutch
- Cooling Fan
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Cooling System - Proper Fluid Concentrations (93-1-10)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Cooling System - Use Of Recycled Engine Coolant (90-4-10)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- 5.0L Eng Spark Knock On ACCEL. - New Timing Specs (92-8-8)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- 5.0L Eng No/Hard Start/Stalls In Below Freezing Temp (91-11-5)
- 5.0L Eng High Idle/Mil Flashes Intermittently (91-10-6)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Entertainment Systems
- No Crank - Low State Of Battery Charge (91-10-8)
- Radio Distortion From Speakers - New Subwoofer (91-8-16)
- Inoperative/Intermittent Front Door Speakers (89-10T-12)
- Radio "Pop" Noise When Brakes Applied:Brake Circuit (89-16-10)
- Inoperative/Intermittent Front Door Speakers (89-19-7)
- Interference On Am Radio Band - Poor Antenna Ground (89-16-11)
- Radio Controls Lock Up When Tape Is Inserted (89-14-12)
- Radio/Tape Lock-Up - Clearing Occasional Occurrence (89-7T-21)
- Exterior Body Panels
- WINDNOISE At Front Door Glass And/Or Outside Mirror (93-20-2)
- Lubrication Power Seat Tracks (92-2-3)
- Hood Burn Spots Damage: Replacements (91-4-3)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Anti-Theft VIN Identification Labels (88-7-2)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Bumper ISOLATER And Bracket Replacement Guidelines (94-8-1)
- WINDNOISE At Front Door Glass And/Or Outside Mirror (93-20-2)
- Hood Burn Spots Damage: Replacements (91-4-3)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Anti-Theft VIN Identification Labels (88-7-2)
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Wiring Diagram Symbols Explanation (85-11-5)
- Gauges & Instrument Panels
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- WINDNOISE At Front Door Glass And/Or Outside Mirror (93-20-2)
- Electronic Fuel Gauge Wrong/Reads "Co" - Diagnosis (91-13-4)
- ELEC Fuel GUAGE Increases/Shows Co - New Pump Sender (90-7-11)
- Fuel Tank Sending Unit Wiring Damaged - New Wiring (89-14-6)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Damaged Fuel Tank Sending Unit Connector Repair (89-7T-14)
- Hazardous Waste Material
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Loss Of A/C Cooling Hot/Humid - New Condenser/Line (92-2-4)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- 5.0L Eng A/C Compressor Moan - Diagnostic List (90-18-8)
- A/C "O" Ring Usage Table (90-14-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Intermittent A/C Loss - New A/C Suction Accumulator (89-25-11)
- 5.0/5.8L Eng A/C Moan - Diagnostic List (89-10T-7)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- 5.0L Eng A/C Compressor Moan Hot Day - Diag List (89-20-4)
- A/C Spring Lock Connector Redundant Clip Info (89-11-7)
- A/C Spring Lock Connectors Redundant Clip R & I (89-6T-10)
- Heater Core Leak Test Procedure (89-14-9)
- Ignition Switch/Steering Lock
- Ignition System
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- 5.0L Eng Spark Knock On ACCEL. - New Timing Specs (92-8-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- TFI/ECM Intermittent Ignition Testing Correction (89-25-10)
- New Ignition Switch Replacement Procedure (89-10T-5)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Interior/Exterior Trim
- WINDNOISE At Front Door Glass And/Or Outside Mirror (93-20-2)
- Hood Burn Spots Damage: Replacements (91-4-3)
- WINDNOISE Diagnosis & Service Tips (91-6-3)
- Wind Noise - Passenger Compartment Sealing (91-4-2)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Grille Whistle/Wind Noise - Modify Grille Bars Shape (88-19-1)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Locking Hubs
- Lubrication System
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Consumption Information (89-9-10)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Normal Oil Consumption Information (89-5T-13)
- Manual Steering
- Manual Trans
- Mechanical
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 5.0L - New Torque-To-YEILD Cylinder Head Bolts (95-3-10)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
- 5.0L Eng Spark Knock On ACCEL. - New Timing Specs (92-8-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- 5.0L Eng Excess Oil Consumption - Inspection/Repair (90-1-9)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Consumption Information (89-9-10)
- Anti-Theft VIN Identification Labels (88-7-2)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Normal Oil Consumption Information (89-5T-13)
- Mechanical - Hydraulic
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- Intermittent Brake Squeal/Noise - Normal (90-22-6)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Mirrors
- Paint & Coatings
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- Hood Burn Spots Damage: Replacements (91-4-3)
- Exterior Paint Comprehensive Repair Procedures (91-18-1)
- WINDNOISE Diagnosis & Service Tips (91-6-3)
- Wind Noise - Passenger Compartment Sealing (91-4-2)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Aftermarket Supplier Paint Cross-Reference List (89-12-1)
- Bumpers Cladding & Stripe Paint Color Information (89-9-1)
- Passive Restraints
- Procedures
- Rear Suspension
- Seats
- Leather Seat Cleaning Procedure - Service Tip (98-17-1)
- DECKLID Power Pull-Down Inoperative - Bad Switch (96-5-1)
- WINDNOISE At Front Door Glass And/Or Outside Mirror (93-20-2)
- Lubrication Power Seat Tracks (92-2-3)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Power Seat Slow/No Movement - Lubricate Seat Track (90-19-5)
- Sleeper
- Starter
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 5.0L Eng Spark Knock On ACCEL. - New Timing Specs (92-8-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- 5.0L Eng No/Hard Start/Stalls In Below Freezing Temp (91-11-5)
- No Crank - Low State Of Battery Charge (91-10-8)
- 5.0L Eng High Idle/Mil Flashes Intermittently (91-10-6)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- TFI/ECM Intermittent Ignition Testing Correction (89-25-10)
- New Ignition Switch Replacement Procedure (89-10T-5)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Wheel Weights/Aluminum Rims (90-13-2)
- Aluminum Rims Leak Air - Inspection/Hot Melt Sealant (89-17-3)
- Alum Wheel Leaks Air - Hot Melt Wheel Repair Info (89-9T-6)
- Aluminum Wheel Air Leak - Use Hot Melt-Stick On Leak (89-9T-6)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- DECKLID Power Pull-Down Inoperative - Bad Switch (96-5-1)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- WINDNOISE At Front Door Glass And/Or Outside Mirror (93-20-2)
- Lubrication Power Seat Tracks (92-2-3)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- WINDNOISE Diagnosis & Service Tips (91-6-3)
- Wind Noise - Passenger Compartment Sealing (91-4-2)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Radio "Pop" Noise When Brakes Applied:Brake Circuit (89-16-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Wiring Diagram Symbols Explanation (85-11-5)