Technical Service Bulletins

• Accessories Control Systems
  • Inoperative Or No Communication With Dual Climate Control Seat Module (DCSM) (08-23-11)
  • Climate Control Seat Function Inoperative - No Communication - DCSM - Vehicles Built Prior To 8/31/2007 (07-21-6)
• Air Bag, SRS
  • RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
• Anti-Theft Systems
  • Power Window Global Open Feature - Turning Feature Off (09-2-1)
• Automatic Trans
  • AISIN Transmission Harsh Shifting - No DTC Mileage Above 20,000 Miles (32,200 Km) (08-24-1)
  • Hesitation On Acceleration - Calibration Update (07-6-10)
• Auxiliary Emission Control Systems
  • 3.5L - Rough / Rolling Idle / Idle Speed Drops Below Specification (09-11-13)
  • Hesitation On Acceleration - Calibration Update (07-6-10)
• Axle Shafts
  • Single Wheel Stud Fracture On Rear Hub (12-2-9)
  • AWD - Driveline Vibration - Howl Noise At Highway Speeds In Cold Temperatures - Built On Or Before 8/13/2010 (11-2-14)
  • Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
• Body Electrical
  • Inoperative Or No Communication With Dual Climate Control Seat Module (DCSM) (08-23-11)
• Body Interior
  • Inoperative Or No Communication With Dual Climate Control Seat Module (DCSM) (08-23-11)
  • Climate Control Seat Function Inoperative - No Communication - DCSM - Vehicles Built Prior To 8/31/2007 (07-21-6)
• Charging Systems
  • Stuck High Voltage Charge Cord Information Sheet (G0000127)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
  • 3.5L - Reduced Heater Duct Discharge Temperature At Idle Built On Or Before 6/29/2007 (08-22-4)
  • Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
• Differentials & Drive Axles
  • AWD - Driveline Vibration - Howl Noise At Highway Speeds In Cold Temperatures - Built On Or Before 8/13/2010 (11-2-14)
  • Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
• Driveshaft & Universal Joints
  • AWD - Driveline Vibration - Howl Noise At Highway Speeds In Cold Temperatures - Built On Or Before 8/13/2010 (11-2-14)
  • Half Shafts - Ratcheting/Clicking/Creaking Noise - Cold (07-18-6)
• Engine Control Systems
  • Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
  • 3.5L / 3.7L Engine - VCT Codes P0011, P0012, P0016, P0018, P0021, P0022 - Runs Rough Or Misses - Vehicles Built On Or Before 12/15/2008 (11-6-1)
  • 3.5L - Rough / Rolling Idle / Idle Speed Drops Below Specification (09-11-13)
  • Hesitation On Acceleration - Calibration Update (07-6-10)
  • Ignition Diagnostics (06-18-15)
• Entertainment Systems
  • Pioneer Navigation Radio - Seek Function Inoperative - Service Tip (06-25-3)
  • Audio / Navigation Service And Ordering Procedures (06-21-7)
  • Poor Am / Fm Radio Reception With Rear Defrost On (06-21-9)
• Exhaust
  • Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
  • Rattle Noise Under Vehicle - Heat Shield Contact To Floor Pan - Vehicles Built On Or Before 8/7/2007 (07-17-7)
• Exterior Body Panels
  • Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
• Exterior Lights
  • Exterior Trim - Loose Reverse Lamp At Luggage Compartment (07-18-7)
• Front Suspension
  • Front Strut Noise (08-18-4)
• Heated Glass/Defoggers
  • Poor Am / Fm Radio Reception With Rear Defrost On (06-21-9)
• HVAC Control Systems
  • 3.5L - Reduced Heater Duct Discharge Temperature At Idle Built On Or Before 6/29/2007 (08-22-4)
  • Intermittent/High Blower Motor Operation - EMTC, DATC And/Or EATC Climate Control Systems (08-6-1)
  • Electronic Automatic Climate Control (EATC) Unintended Temperature Change And/Or Fan Speed (07-19-10)
  • Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
• Ignition System
  • Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
  • Ignition Diagnostics (06-18-15)
• Infotainment
  • Audio / Navigation Service And Ordering Procedures (06-21-7)
• Interior/Exterior Trim
  • Rattle Noise Under Vehicle - Heat Shield Contact To Floor Pan - Vehicles Built On Or Before 8/7/2007 (07-17-7)
• Manual Steering
  • Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
  • MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • 3.5L / 3.7L Engine - VCT Codes P0011, P0012, P0016, P0018, P0021, P0022 - Runs Rough Or Misses - Vehicles Built On Or Before 12/15/2008 (11-6-1)
• Mechanical - Hydraulic
  • Single Wheel Stud Fracture On Rear Hub (12-2-9)
• Mirrors
  • Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
  • Ford Interior Mirror Job Aid (G0000001)
• Passive Restraints
  • Inoperative Or No Communication With Dual Climate Control Seat Module (DCSM) (08-23-11)
  • Front Seats Squeak/Rattle (07-13-9)
• Restraints Control Systems
  • RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
• Seats
  • Inoperative Or No Communication With Dual Climate Control Seat Module (DCSM) (08-23-11)
  • Climate Control Seat Function Inoperative - No Communication - DCSM - Vehicles Built Prior To 8/31/2007 (07-21-6)
  • Front Seats Squeak/Rattle (07-13-9)
  • LINCOLN MKZ Climate Controlled Seats Inoperative (06-26-7)
  • Climate Controlled Seat Operation And Service Tips (06-24-9)
• Starter
  • Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
• Steering Column
  • Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
• Steering Control Systems
  • Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
  • MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
• Steering Gear
  • Power Steering Fluid Leaks From Steering Rack And Pump Attachment Joints (07-25-14)
  • MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
• Sun Roof/T-Top/Convertible Top
  • Power Window Global Open Feature - Turning Feature Off (09-2-1)
  • Water Leak - Roof Opening Panel Area - Built On Or Before 11/18/2006 (07-16-16)
• Suspension Control Systems
  • Front Strut Noise (08-18-4)
• System
  • Mil On With DTCS - P0351, P0352, P0353, P0354, P0355, And/Or P0356 - Built On Or Before 3/1/2008 (14-0059)
  • 3.5L / 3.7L Engine - VCT Codes P0011, P0012, P0016, P0018, P0021, P0022 - Runs Rough Or Misses - Vehicles Built On Or Before 12/15/2008 (11-6-1)
  • 3.5L - Rough / Rolling Idle / Idle Speed Drops Below Specification (09-11-13)
  • Hesitation On Acceleration - Calibration Update (07-6-10)
  • Ignition Diagnostics (06-18-15)
• Transmission Control Systems
  • AISIN Transmission Harsh Shifting - No DTC Mileage Above 20,000 Miles (32,200 Km) (08-24-1)
  • Hesitation On Acceleration - Calibration Update (07-6-10)
• Wheel Hubs
  • Single Wheel Stud Fracture On Rear Hub (12-2-9)
• Wheels & Tire System
  • Single Wheel Stud Fracture On Rear Hub (12-2-9)
• Window Motors & Regulators
  • Door Glass Slow Movement - Glass Scratches - Window Regulator Noise (09-12-4)
  • Power Window Global Open Feature - Turning Feature Off (09-2-1)
  • B-Pillar/Window Run Seal Wind Noise - Vehicles Built Before 12/1/2006 (07-5-10)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Inoperative Or No Communication With Dual Climate Control Seat Module (DCSM) (08-23-11)