Section 203 (Climate Control System - General Information)
WARNING: This page is about a different car, the 2019 Lincoln MKC. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description And Operation
- Climate Control System - Component Location
- Climate Control System - Overview
- Climate Control System - System Operation and Component Description
- System Diagram
- Network Message Charts
- The Refrigerant Cycle
- Component Description
- FCIM - DATC
- Blower Motor
- Blower Motor Speed Control
- Cabin Heater Coolant Pump
- Evaporator Core
- Heater Core
- Climate Control Housing
- Door Actuator - Air Inlet
- Door Actuator - Defrost Vent
- Door Actuator - Footwell Vent/Register
- Temperature Door Actuator - Driver Side
- Temperature Door Actuator - Passenger Side
- A/C Pressure Transducer
- Ambient Air Temperature (AAT) Sensor
- Ambient Air Quality Sensor (if equipped)
- Evaporator Temperature Sensor
- In-Vehicle Temperature And Humidity Sensor
- Air Discharge Temperature Sensors
- Sunload Sensor
- A/C Compressor Clutch
- Externally Controlled Variable Displacement Compressor
- Thermostatic Expansion Valve (TXV)
- Condenser
- Receiver Drier
- Service Gauge Port Valves
- Refrigerant System Dye
- Diagnosis And Testing
- Climate Control System
- DTC Charts
- Symptom Charts
- Pinpoint Tests
- Pinpoint Test A : P0532, P0533
- Pinpoint Test B : P0645
- Pinpoint Test C : P06A0
- Pinpoint Test D : B105A:12, B105A:14, B1A61:11, B1A61:15, B1A69:11, B1A69:15
- Pinpoint Test E : B1B71:11, B1B71:15
- Pinpoint Test F : The Temperature Control Is Inoperative Or Does Not Operate Correctly - Passenger Side
- Pinpoint Test G : Unable To Duplicate The Customer Concern And No Diagnostic Trouble Codes (DTCS) Present
- Pinpoint Test H : The Air Inlet Door Is Inoperative
- Pinpoint Test I : Incorrect Or Erratic Direction Of Airflow From Outlets
- Pinpoint Test J : Insufficient, Erratic Or No Heat
- Pinpoint Test K : The A/C (Air Conditioning) Is Inoperative
- Pinpoint Test L : The A/C (Air Conditioning) Is Always On -- A/C (Air Conditioning) Mode Always Commanded On
- Pinpoint Test M : The Temperature Control Is Inoperative Or Does Not Operate Correctly - Driver Side
- Pinpoint Test N : The Blower Motor Is Inoperative
- Pinpoint Test O : The Blower Motor Does Not Operate Correctly
- Pinpoint Test P : B1A63:11, B1A63:15, B1A64:11, B1A64:15
- Pinpoint Test Q : B10B3:11, B10B3:15, B10B4:11, B10B4:15, B10B5:11, B10B5:15, B10B6:11, B10B6:15
- Pinpoint Test R : P193E
- Pinpoint Test S : B102E:11, B102E:15, B102E:92
- Pinpoint Test T : C1B14:11, C1B14:12
- Pinpoint Test U : Insufficient Heat In Auto Start-Stop Mode Only
- Climate Control System
- General Procedures
- Air Conditioning (A/C) Clutch Air Gap Adjustment
- Air Conditioning (A/C) Clutch and Air Conditioning (A/C) Clutch Field Coil
- Air Conditioning (A/C) Compressor Leak Detection
- Air Conditioning (A/C) Odor Treatment
- Air Conditioning (A/C) System Flushing
- Air Conditioning (A/C) System Recovery, Evacuation and Charging
- Condenser Core Leak Check
- Electronic Leak Detection
- Evaporator Core Leak Check
- Fluorescent Dye Leak Detection
- Heater Core Leak Check
- Refrigerant Identification Testing
- Refrigerant Oil Adding
- Refrigerant System Tests
- Removal And Installation
- Air Conditioning (A/C) Compressor
- Air Conditioning (A/C) Compressor Inlet Line
- Air Conditioning (A/C) Compressor Outlet Line
- Air Conditioning (A/C) Pressure Transducer
- Air Inlet Door Actuator
- Air Inlet Duct
- Ambient Air Temperature Sensor
- Blower Motor
- Blower Motor Speed Control
- Cabin Air Filter
- Cabin Heater Coolant Pump
- Center Register Air Discharge Temperature Sensor
- Center Registers
- Climate Control Housing
- Condenser
- Defrost Vent Door Actuator
- Driver Side Footwell Air Discharge Temperature Sensor
- Driver Side Register
- Driver Side Temperature Door Actuator
- Evaporator
- Evaporator Inlet and Outlet Manifold
- Evaporator Temperature Sensor
- Footwell Vent Register Door Actuator
- Heater Core
- Heating, Ventilation and Air Conditioning (HVAC) Control Module
- In-Vehicle Temperature and Humidity Sensor
- Passenger Side Footwell Air Discharge Temperature Sensor
- Passenger Side Register
- Passenger Side Temperature Door Actuator
- Receiver Drier
- Sunload Sensor
- Thermostatic Expansion Valve