Technical Service Bulletins: Other Variant
WARNING: This page is about the Millenia S, which is a different variant/trim than selected.
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Wind Noise Around Doors (S018/98)
- Rear Console Surface Cracked (S013/97)
- Rattle Noise From Rear Seat Back (S005/97)
- Key Replacement Program/Ordering Information (AD001/97)
- Anti-Theft Alarm Malfunctions (T019/96)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Door Lock Switch Letters Rub Off (MT 0596-04)
- Door Trim Removal/Installation - Manual Incorrect (S017/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Key Cylinder Replacement - REKEY Cylinders To Match (MT 0995-10)
- Poor A/T Performance - Check Aftermarket Alarm (MT 05-04)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Automatic Trans
- ATF Leak / Abnormal Shifting / Shift Shock - Reseal (K013/98)
- Service Part Availability Auto Transaxle Bushing (K004/98)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Torque CONVERTOR/Bolt Replacement Information (MT 1295-09)
- A/T Oil Cooler Flushing Equipment Guideline (CAT. J, NO. 96-01)
- Recommended A/T Cooler Line Flushing Equipment (CAT. ST, NO. 009/95)
- A/T Throttle Cable Adjustment (MT 05-06)
- Auxiliary Emission Control Systems
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- PCV SYS. Modification At Partial Engine Replacement (CAT. B, NO. 004/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- Data Link Connector Terminal Location LABLE DISCONT (T018/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Fuel Vapor Valve - Correct Installation (MT 0596-01)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
- Room Fuse Installation - With Ignition Key Off (MT 0995-09)
- Axle Shafts
- Body Interior
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Blower Motor Inoperative/Fan Speed Incorrect (T002/97)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- TCS And TCS Off Light Illuminate DTC 83 / 84 (P002/98)
- Traction Control Lights Illuminate (MT 1197-04)
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Data Link Connector Terminal Location LABLE DISCONT (T018/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
- Entertainment Systems
- Exterior Body Panels
- Service Bumper Specification Change (09-022/09)
- Difficulty Installing Fuel Pump Into New Fuel Tank (01-016/01)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Fuel/Trunk Opener Switch Loose - New Switch & Nut (CAT. T, NO. 009/98)
- Creaking/Knocking Noise From Rear Of Vehicle- Braces (S014/96)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Water Leak - Undercarriage Drain Plug Holes (MT 0598-13)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Rear Bumper Installation Method (S042/96)
- Creaking/Knocking Noise From Rear Of Vehicle- Braces (S014/96)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
- Front Suspension
- Fuel System
- Multiple Models - Fuel Injector(S) Replacement Guidelines (01-013/02)
- Multiple Models - Fuel Pump Assembly And Related Component Replacement Guidelines (01-006/02)
- Difficulty Installing Fuel Pump Into New Fuel Tank (01-016/01)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Fuses & Circuit Breakers
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Spare Fuse Location - Fill Receptacle 25 (T003/97)
- Checking Points For Dead Battery - Dark Current Draw (G003/96)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Tach Needle Stuck On Wrong Side Of Stopper Pin (T012/97)
- Center Panel Service Parts Availability (S010/98)
- Rear Console Surface Cracked (S013/97)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Glove Box Lid Does Not Fit Flush With Dash Board (S041/96 REV.)
- Heater Control Auto Knob Removal (S004/96)
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- A/C Odor & Blower Noise Due To Foreign Substance (U011/97)
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Heater Hose/Core Connector Dealer Hint (MT 0597-09)
- Blower Motor Inoperative/Fan Speed Incorrect (T002/97)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- Intermittent A/C Operation (U006/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Heater Control Auto Knob Removal (S004/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- Identification
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Water Leak - Undercarriage Drain Plug Holes (MT 0598-13)
- Leather Seat Trim Availability - Smooth Grain (S006/97)
- Center Arm Rest Lid Sticks (S051/96)
- Glove Box Lid Does Not Fit Flush With Dash Board (S041/96 REV.)
- Unable OT Operate Ventilator/Or Loose Grill (S018/96)
- Heater Control Auto Knob Removal (S004/96)
- Rattle Noise From Rear Package Tray (S012/96)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Interior/Illumination Lights
- Lubrication System
- Manual Steering
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 1995-2002 MILLENIA S - Camshaft Installation Information (01-016/02)
- Piston Standardization Left & Right Bank REPLACEMANT (CAT. 01, NO. 015/99)
- Camshaft Friction Gear Noise - Modified REPL Process (B005/98)
- Smell/Misfire/Oil Consumption - Valve Cover Oil Leak (B007/97)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Tapping Noise When Engine Is Cold (B001/97)
- Oil Leaking From Under The Timing Belt Cover (D001/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Lower Cylinder Block Bolt Length Change (B004/96)
- Front Engine Oil Leak Under Timing Belt Cover (MT 0596-07)
- No. 1 Engine Mount Modification (B001/96)
- Cylinder Heads Not Interchangeable (MT 1095-05)
- Knock Sensor Cover Eliminated (MT 06-05)
- Mechanical - Hydraulic
- Memory Modules
- Mirrors
- Rear View Mirror Loose - New Set Screw/Mirror (S002/98)
- Fuel/Trunk Opener Switch Loose - New Switch & Nut (CAT. T, NO. 009/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Power Door Lock Switch Lettering Rubs Off/Fades (S026/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Paint & Coatings
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Environmental Fallout Repair Procedure (MT 0797-07)
- Sun Roof Lower Panel Cover Loose (S049/96)
- Center Arm Rest Lid Sticks (S051/96)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
- Paint Damage - Iron Particles / Industrial Fallout / Acid Rain (09-025/04)
- Procedures
- Rear Suspension
- Restraints Control Systems
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Seats
- Fuel/Trunk Opener Switch Loose - New Switch & Nut (CAT. T, NO. 009/98)
- Seat Belt Extenders Description/Ordering Info (S005/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Leather Seat Trim Availability - Smooth Grain (S006/97)
- Rattle Noise From Rear Seat Back (S005/97)
- Rattle Noise From Rear Seat Back (CAT. S, NO. 055/96)
- Seat Belt Extender Description/Ordering Info (CAT. S, NO. 032/96)
- Front Seat Belt Caution Label Pulls Out Of Sleeve (S050/96)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Front Seat Back Clip Availability (S036/96)
- Power Seats Will Not Move Forward (S035/96)
- Dirt On Seat Belt And Anchor (CAT. S, NO. 028/96)
- Power Door Lock Switch Lettering Rubs Off/Fades (S026/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Starter
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- Grinding Noise During Engine Cranking (G002/97)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
- Steering Column
- Steering Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- NGS System Message - Data Link Error (MT 06-02)
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- System
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Spark Plug Wire Resistance Specifications (G006/97)
- Smell/Misfire/Oil Consumption - Valve Cover Oil Leak (B007/97)
- Check Spark Plug Wire Resistance (MT 1097-04)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- PCV SYS. Modification At Partial Engine Replacement (CAT. B, NO. 004/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- Data Link Connector Terminal Location LABLE DISCONT (T018/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Fuel Vapor Valve - Correct Installation (MT 0596-01)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
- Room Fuse Installation - With Ignition Key Off (MT 0995-09)
- Towing
- Transmission Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Torque CONVERTOR/Bolt Replacement Information (MT 1295-09)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- Window Motors & Regulators
- Fuel/Trunk Opener Switch Loose - New Switch & Nut (CAT. T, NO. 009/98)
- Wind Noise Around Doors (S018/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Residue On Glass (MT 0797-02)
- Windshield Fog Or Film (MT 0397-04)
- Hood Material Changed From Aluminum To Steel (S047/96)
- Windshield Stone Chipping Inspection (S037/96)
- Power Door Lock Switch Lettering Rubs Off/Fades (S026/96)
- Film Or Residue On Glass - Removal (MT 05-05)
- Vanity Mirror Bulb Replacement (MT 08-09)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)