Technical Service Bulletins

• Accessories & Equipment
  • All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
  • Availability Of Non-Required Tools - April 2007 (ST-003/07)
  • WDS PTU Battery Warranty And Order Information (ST-001/05)
  • Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
  • All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
• Accessories Control Systems
  • Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Air Bag, SRS
  • Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
  • Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
• Anti-Lock Brakes
  • Brake Warning Light On Constantly (T005/98)
• Anti-Theft Systems
  • Keyless Remote Transmitter Battery Inspection PROC. (CAT. 09, NO. 010/00R)
  • Keyless Remote Transmitter Battery Inspection Procedure (010/00R)
  • Door Key Difficult To Insert &/Or Rotate (CAT. 09, NO. 013/99)
  • Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
  • Wind Noise Around Doors (S018/98)
  • Brake Warning Light On Constantly (T005/98)
• Automatic Trans
  • Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
  • A/T Selector Lever Hard To Operate - Selector Shaft (K009/98)
  • Fa4AEL Trans Light Throttle 1-2 Shift Shock (K014/98)
  • Shipment Of Special Tools (CAT. ST, NO. 004/98)
  • Erratic Shifting, O/D Off Light Flashes With Mil On (K010/98)
• Auxiliary Emission Control Systems
  • Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
  • Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
  • Year 2000 Compliance (01-018/99)
  • Mil On DTC P0170 After Restart In Cold Temperatures (01-007/99)
  • TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Axle Shafts
  • Special Service Tool Shipment - June 2007 (ST-004/07)
• Body Electrical
  • "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
• Body Interior
  • Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • Brake Warning Light On Constantly (T005/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Brakes Control Systems
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Charging Systems
  • Special Service Tool Shipment - October 2011 (ST-002/11)
  • Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
• Cooling System (Mechanical)
  • Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
  • Heater Not Working Or Engine Takes Too Long To Warm (E001/98)
• Cruise Control Systems
  • Brake Warning Light On Constantly (T005/98)
• Differentials & Drive Axles
  • Shipment Of Special Tools (CAT. ST, NO. 004/98)
• Electronic Steering
  • Thumping Noise From Rear Suspension Tower (R002/98)
• Electronic Suspension
  • Thumping Noise From Rear Suspension Tower (R002/98)
• Engine Control Systems
  • "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
  • Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
  • Year 2000 Compliance (01-018/99)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • Shipment Of Special Tools (CAT. ST, NO. 004/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Entertainment Systems
  • Multiple Models - Cd Module Malfunctions (CAT. 09, NO. 010/03)
  • Cigarette Lighter Does Not Work Properly (09-007/00)
  • FMS Or PANASONIC Audio Units Identification (CAT. T, NO. 003/98)
  • ETR Operation - Cassette Changes Before Tape Ends (MT 0297-05)
• Exhaust
  • Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
• Exterior Body Panels
  • Service Bumper Specification Change (09-022/09)
  • Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
• Exterior Lights
  • Brake Warning Light On Constantly (T005/98)
  • Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
  • Interior Light Does Not Illuminate - Door Switch (T009/97)
• Frames, Subframes & Crossmembers
  • Service Bumper Specification Change (09-022/09)
  • Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
  • Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
• Front Suspension
  • Camber Adjustment (CAT. R, NO. 002/97)
  • Thumping Noise From Rear Suspension Tower (R002/98)
• Fuel System
  • Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
  • Special Service Tool Shipment - October 2011 (ST-002/11)
  • CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
• Fuses & Circuit Breakers
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Gauges & Instrument Panels
  • Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
  • Tach Needle Stuck On Wrong Side Of Stopper Pin (T012/97)
  • Noise From Front Console - Adhesive Foam Pads (S020/98)
• Headlights
  • Brake Warning Light On Constantly (T005/98)
  • Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
  • Interior Light Does Not Illuminate - Door Switch (T009/97)
• HVAC Control Systems
  • Air Conditioning Musty/Mildew Odor (07-006/07)
  • Air Conditioning - Musty / Mildew Odor (CAT. 07, NO. 004/02)
  • Heater Hose/Core Connector Dealer Hint (MT 0597-09)
  • Use Of A/C Tracer Dye (U-008/97)
• Identification
  • Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
  • FMS Or PANASONIC Audio Units Identification (CAT. T, NO. 003/98)
• Ignition System
  • Spark Plug Installation / Removal Caution (01-036/06)
• Infotainment
  • Brake Warning Light On Constantly (T005/98)
• Interior/Exterior Trim
  • Proper Usage Of Driver's Floor Mat (09-027/14)
  • Door Key Difficult To Insert &/Or Rotate (CAT. 09, NO. 013/99)
  • Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
  • Door Mirror Vibrates (Manual Type) - Replace Mirror (S024/98)
• Interior/Illumination Lights
  • Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
  • Interior Light Does Not Illuminate - Door Switch (T009/97)
• Locking Hubs
  • Thumping Noise From Rear Suspension Tower (R002/98)
• Manual Steering
  • Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
• Mechanical
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Special Service Tool Shipment - October 2011 (ST-002/11)
  • Special Service Tool Shipment - June 2007 (ST-004/07)
  • Excessive Vibration At Idle, In Drive Or In Reverse (B006/98)
  • Poor Engine Performance - New Intake Valve (B002/98)
• Mechanical - Hydraulic
  • Popping Noise From Front Brakes Slow Speed Braking (04-002/99)
  • Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
  • Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
• Memory Modules
  • Brake Warning Light On Constantly (T005/98)
• Mirrors
  • Door Mirror Cracks In Freezing Temperatures (Manual) (S025/98)
  • Brake Warning Light On Constantly (T005/98)
  • Door Mirror Vibrates (Manual Type) - Replace Mirror (S024/98)
• Paint & Coatings
  • Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
  • Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
• Passive Restraints
  • Thumping Noise From Rear Suspension Tower (R002/98)
• Procedures
  • Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
• Rear Suspension
  • Camber Adjustment (CAT. R, NO. 002/97)
  • Thumping Noise From Rear Suspension Tower (R002/98)
• Restraints Control Systems
  • Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Seats
  • Seat Belt Extenders Description/Ordering Info (S005/98)
  • Brake Warning Light On Constantly (T005/98)
• Starter
  • 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
  • Battery Maintenance (01-029/06)
  • Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
  • Special Service Equipment Distribution - November 2010 (ST-002/10)
  • All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
  • Battery Charging Cautions (CAT. 01, NO. 012/99)
• Steering Column
  • Thumping Noise From Rear Suspension Tower (R002/98)
  • Steering Wheel Slightly Off Center (CAT. N, NO. 001/98)
• Steering Control Systems
  • A/C Inoperative / Mil "On" DTC P0550 (CAT. 01, NO. 011/99)
  • Year 2000 Compliance (01-018/99)
  • A/C Inoperative - P/S Press Switch Terminal CORODED (07-001/99)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Steering Gear
  • Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
• Steering Linkage
  • Thumping Noise From Rear Suspension Tower (R002/98)
• Sun Roof/T-Top/Convertible Top
  • Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
• Suspension Control Systems
  • Year 2000 Compliance (01-018/99)
  • A/C Inoperative - P/S Press Switch Terminal CORODED (07-001/99)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• System
  • "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
  • Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
  • Shipment Of MAZDA World Wide Diagnostic Tool During October 2000 (00-006/00)
  • Year 2000 Compliance (01-018/99)
  • Mil On DTC P0170 After Restart In Cold Temperatures (01-007/99)
  • TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • Shipment Of Special Tools (CAT. ST, NO. 004/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
  • Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
• Transmission Control Systems
  • Year 2000 Compliance (01-018/99)
  • Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
  • Shipment Of Special Tools (CAT. ST, NO. 004/98)
  • Erratic Shifting, O/D Off Light Flashes With Mil On (K010/98)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
• Warning Systems
  • Brake Warning Light On Constantly (T005/98)
• Wheels & Tire System
  • Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
  • MAZDA Wheel Lock Installation - Service Tip (02-001/06)
• Window Motors & Regulators
  • Wind Noise Around Doors (S018/98)
  • Windshield Fog Or Film (MT 0397-04)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • DTC Diagnostic Trouble Shooting Tips (MT 0597-07)