Technical Service Bulletins

• Accessories & Equipment
  • All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
  • Availability Of Non-Required Tools - April 2007 (ST-003/07)
  • Special Tool Shipment - February 2006 (ST-001/06)
  • WDS PTU Battery Warranty And Order Information (ST-001/05)
  • Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
  • Special Tool Shipment June 2003 (SST) (ST002/03)
  • All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
• Accessories Control Systems
  • Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
  • Display Shows Inaccurate Ambient Temperature (09-023/14)
  • Precautions For Module Reprogramming (01-030/08)
  • Dome Lamp Flashing And / Or Clicking Sound From Rear Doors (09-007/04)
  • Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
• Air Bag, SRS
  • Standard Deployment/Two-Step Deployment For Air Bag System (MT-003/18)
  • Stopper Plates For Air Bag Module Connectors Have Been Established As New Service Parts (SA-068/17)
  • Driver Side Air Bag Rattle (08-004/04)
  • Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
• Anti-Lock Brakes
  • Clunk/Bang/Buzz Noise During First Forward Movement After Sitting (04-009/06)
• Anti-Theft Systems
  • Keyless Entry Remote Transmitter (Key Fob) Battery Replacement Caution (09-041/10)
  • Dome Lamp Flashing And / Or Clicking Sound From Rear Doors (09-007/04)
  • Security Access Procedure Change For Coded Access Pats And Advanced Keyless System - Service Tip (09-003/06)
• Automatic Trans
  • Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
• Auxiliary Emission Control Systems
  • Mil On With DTC P2004 (01-014/07)
  • Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
  • Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
  • Mil With DTC P0128 And / Or P0456 (01-024/03)
• Axle Shafts
  • Clunk Noise From Drive Shaft (03-002/10)
  • Special Service Tool Shipment - June 2007 (ST-004/07)
• Body Interior
  • As-Built Data Search On Ms3 (00-001/10)
  • Dome Lamp Flashing And / Or Clicking Sound From Rear Doors (09-007/04)
• Brakes Control Systems
  • Clunk/Bang/Buzz Noise During First Forward Movement After Sitting (04-009/06)
  • As-Built Data Search On Ms3 (00-001/10)
  • Precautions For Module Reprogramming (01-030/08)
• Charging Systems
  • Special Service Tool Shipment - October 2011 (ST-002/11)
  • Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
• Clutch
  • Manual Transmission - Clutch Hard To Disengage (05-004/06)
• Cooling System (Mechanical)
  • Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
  • Coolant Level Warning Light Comes On (01-040/10)
  • Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
• Differentials & Drive Axles
  • Differential Oil (03-004/03)
• Engine Control Systems
  • Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
  • As-Built Data Search On Ms3 (00-001/10)
  • Coolant Level Warning Light Comes On (01-040/10)
  • Mil On With DTC P2004 (01-014/07)
  • No COMMS Recovery Procedure For Blanked Module (5876)
  • Precautions For Module Reprogramming (01-030/08)
  • Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
  • Mil With DTC P0128 And / Or P0456 (01-024/03)
  • Format Change Of As-Built Data For M-MDS - Service Tip (01-045/06)
  • Low Oil Level Warning Light Comes On When Level Is Not Low (01-027/03)
  • Mil Illumination With DTC P2107, P2108 Or P2109 (01-010/04)
• Entertainment Systems
  • Audio/Infotainment System Service Information (09-074/09)
  • Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
• Exhaust
  • Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
  • Replacing Engine Check Intake And Exhaust Debris (6758)
• Exterior Body Panels
  • Service Bumper Specification Change (09-022/09)
  • Interference Between Trunk, Rear Combination Lamps And/Or Rear Bumper (09-028/04)
• Exterior Lights
  • Condensation/Fog In Front And Rear Combination Lamps (Headlamp And TAILLAMP Assemblies) (09-049/14)
  • Condensation/Fog In Front And Rear Combination Lights (09-057/10)
  • Water In Rear Combination Light (09-005/09)
  • Water In Rear Combination Light (09-014/07)
  • Interference Between Trunk, Rear Combination Lamps And/Or Rear Bumper (09-028/04)
  • Solvent Cracks Appear On Rear Combination Light Lens And / Or Front Side Marker Light Lens (09-021/04)
• Frames, Subframes & Crossmembers
  • Service Bumper Specification Change (09-022/09)
  • Front License Plate Frame Mounting Instructions - Service Tip (09-015/03)
  • Interference Between Trunk, Rear Combination Lamps And/Or Rear Bumper (09-028/04)
• Front Suspension
  • Noise From Front Of Vehicle / Stabilizer Control Link Broken (02-005/08)
  • Snapping Noise When Turning At Low Speed - 18" Wheels (02-002/04)
• Fuel System
  • Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
  • Auxiliary Port Valve (APV) Removal Caution (01-034/11)
  • Special Service Tool Shipment - October 2011 (ST-002/11)
  • CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
  • Fuel Distributor Insulator - Removal / Installation Cautions - Service Tip (01-031/05)
  • Mil Illumination With DTC P2107, P2108 Or P2109 (01-010/04)
• Fuses & Circuit Breakers
  • Room Fuse Removal / Installation Caution (09-023/04)
• Gauges & Instrument Panels
  • Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
  • Display Shows Inaccurate Ambient Temperature (09-023/14)
  • Dash Center Panel (Audio, Radio, Climate Control) Removal - Service Tip (09-013/03)
  • Instrument Panel Noise - Driver Side (09-023/06)
  • Mil With DTC(S) P0126, P0420, P0456, P2404, Engine Quit, Oil Level Warning Lamp On (01-007/05)
• Headlights
  • Condensation/Fog In Front And Rear Combination Lamps (Headlamp And TAILLAMP Assemblies) (09-049/14)
  • Headlight Plastic Lens Maintenance Caution (09-035/09)
  • Condensation/Fog In Front And Rear Combination Lights (09-057/10)
  • Headlight Auto-Leveling Malfunction Indicator Light Illuminates (09-008/07)
• Heated Glass/Defoggers
  • Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
• HVAC Control Systems
  • Poor Blower Performance / Wet Passenger Floor (5768)
  • A/C Air Temperature Fluctuation And / Or Lack Of Cooling (07-002/04)
  • Temperature Control Dial And / Or Fan Control Dial Break Or Come Off (07-003/03)
  • Use Of A/C Tracer Dye (U-008/97)
• Identification
  • Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
• Ignition System
  • Ignition Coil Inspection (01-016/07)
  • Engine Misfire Diagnostic Procedures - Service Tip (01-002/06)
  • Spark Plug Installation / Removal Caution (01-036/06)
• Infotainment
  • Audio/Infotainment System Service Information (09-074/09)
  • Navigation Display Standard For Failed Pixels (09-081/09)
  • Reprogramming The "Home" Address (6156)
  • Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
  • Room Fuse Removal / Installation Caution (09-023/04)
• Interior/Exterior Trim
  • Proper Usage Of Driver's Floor Mat (09-027/14)
  • Exterior Trim Heat Damage (MT-038/16)
  • Headlight Plastic Lens Maintenance Caution (09-035/09)
  • Dashboard Upper Surface Poor Appearance (09-038/12)
  • SUNVISOR Pivot Broken (09-002/07)
  • Contact Marks On Center Of Side Sill (09-001/05)
  • Interior Tire House Trim Lifting Over Both Rear Wheel Housings (09-004/04)
  • Overhead Console Lid Hard To Open (09-019/06)
  • Shift Panel Removal Caution - Service Tip (09-010/06)
• Interior/Illumination Lights
  • Dome Lamp Flashing And / Or Clicking Sound From Rear Doors (09-007/04)
• Lubrication System
  • Do Not Use Synthetic Or Semi-Synthetic Oil In The Rotary Engine (MT-007/17)
  • Engine Oil Flushing Procedure (01-041/10)
  • Low Oil Level Warning Light Comes On When Level Is Not Low (01-027/03)
  • Milky Substance On Oil Level Gauge (Dipstick) (01-050/06)
• Mechanical
  • Replacement Engine Assembly Failure (MT-014/16)
  • Do Not Use Synthetic Or Semi-Synthetic Oil In The Rotary Engine (MT-007/17)
  • Hydraulic Versus Mechanical TENSIONERS (TT001-13)
  • Auxiliary Port Valve (APV) Removal Caution (01-034/11)
  • Special Service Tool Shipment - October 2011 (ST-002/11)
  • Rattle/Chatter Noise From Intake Manifold (01-043/10)
  • Front Oil Seal Removal / Installation Procedure Update (01-025/10)
  • Availability Of Non-Required Tool - March 2010 (ST-001/10)
  • Hesitation/Idle Vibration Due To Cracked Engine Mount (01-021/06)
  • Engine Compartment Shroud Panel Poor Appearance (09-034/09)
  • High Oil Consumption Due To Wrong Air Intake Hose Service Parts (01-030/09)
  • Replacing Engine Check Intake And Exhaust Debris (6758)
  • Special Service Tool Shipment - June 2007 (ST-004/07)
  • Engine Cover Grommets Missing (01-001/04)
  • Low Oil Level Warning Light Comes On When Level Is Not Low (01-027/03)
  • Mil Illumination With DTC P2107, P2108 Or P2109 (01-010/04)
• Mechanical - Hydraulic
  • Brake Noise, Judder And Dragging Diagnosis And Servicing (04-007/11)
  • On-Car Brake Lathe (ST-001/11)
  • Squeal Noise From Front Brakes During Braking (04-001/06)
  • Snapping Noise When Turning At Low Speed - 18" Wheels (02-002/04)
  • Squeal Noise From Front Brakes During Braking (04-006/04)
• Mirrors
  • Side Mirror Glass Moves Freely (5910)
• Parking Brake System
  • Broken Parking Brake Lever Cover (04-002/06)
• Passive Restraints
  • Chips And Scratches On Front Seatback Cover - Leather Seats (09-034/04)
• Procedures
  • MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
  • Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
• Restraints Control Systems
  • As-Built Data Search On Ms3 (00-001/10)
  • AIRBAG (SAS UNIT) REPLACEMENT CAUTION - DTCs B1342 / B2477 (08-002/06)
  • Airbag Warning Light Illuminated - DTC B1994 And / Or B1998 Set (08-008/05)
• Schedule
  • MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
• Seats
  • Chattering Noise/Unable To Adjust Driver-Side Manual Seat Lift (09-059/09)
  • Seat Shakes Back And Forth / Makes Noise When Braking (09-025/12)
  • Squeaking Noise From Seat Back Due To Frame And Seat Back Pad Contact (09-069/09)
  • Squeaking Noise From Seat Back Due To Frame And Spring Contact (09-064/09)
  • Squeaking Noise From Under Driver Seat Lifter Link (09-065/09)
  • Clunk Noise From Seat When Braking (09-060/09)
  • Seat Shakes Back And Forth/Makes Noise When Braking (09-061/09)
  • Squeaking Noise From Leather Seats (09-062/09)
  • Chips And Scratches On Front Seatback Cover - Leather Seats (09-034/04)
• Starter
  • 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
  • Battery Maintenance (01-029/06)
  • All Models - Use Gr8 Battery Charger When Reprogramming Modules (MT-014/17)
  • Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
  • Special Service Equipment Distribution - November 2010 (ST-002/10)
  • JIS/BCI Standard To CCA Conversion Chart (01-010/10)
  • JIS/BCI Standard To CCA Conversion Chart (00-003/09)
  • Engine Cranks No Start (01-048/06)
  • Battery Charging Cautions (CAT. 01, NO. 012/99)
  • Battery Replacement - Service Tip (01-042/04)
  • Room Fuse Removal / Installation Caution (09-023/04)
• Steering Column
  • Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
  • Driver Side Air Bag Rattle (08-004/04)
• Steering Control Systems
  • Precautions For Module Reprogramming (01-030/08)
  • MAZDA MODULAR DIAGNOSTIC SYSTEM (M-MDS) STEERING WHEEL ANGLE SENSOR MODULE SELF TEST SHOWS "Fail" (01-039/06)
• Sun Roof/T-Top/Convertible Top
  • Squeaking Noise From Sunroof (09-029/06)
• Suspension Control Systems
  • Precautions For Module Reprogramming (01-030/08)
  • TPMS (Tire Pressure Monitoring System) Warning Lamp Illuminated And A Warning Buzzer - No DTCS - Service Tip (02-004/04)
• System
  • Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
  • Mil On With DTC P2004 (01-014/07)
  • No COMMS Recovery Procedure For Blanked Module (5876)
  • Engine Lack Of Power (01-014/08)
  • Mil On - P2070 Set (01-019/08)
  • Clearing Eccentric Shaft Plate Profile Memory From Pcm (01-030/05)
  • Mil On With P0456 - Leaking Fuel Filler Cap (01-026/07)
  • Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
  • Mil With DTC P0128 And / Or P0456 (01-024/03)
  • DTC P0336 During Engine Start - Service Tip (01-017/05)
  • Engine Misfire Diagnostic Procedures - Service Tip (01-002/06)
  • Engine No Start, Lack Of Power, DTCS P2107, P2108, P2402 Or P0420 - Powertrain Control Module (Pcm) REFLASH (01-022/04)
  • Low Oil Level Warning Light Comes On When Level Is Not Low (01-027/03)
  • Mil Illumination With DTC P2107, P2108 Or P2109 (01-010/04)
  • Mil With DTC(S) P0126, P0420, P0456, P2404, Engine Quit, Oil Level Warning Lamp On (01-007/05)
  • Room Fuse Removal / Installation Caution (09-023/04)
  • Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
• Transmission Control Systems
  • As-Built Data Search On Ms3 (00-001/10)
  • Precautions For Module Reprogramming (01-030/08)
  • Front Cover Modification - Eccentric Shaft Sensor (5698)
• Wheels & Tire System
  • Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
  • Body Vibration Or Steering Wheel Shimmy (MT-012/18)
  • Service Caution For TPMS (02-007/09)
  • TPMS Cannot Be Turned Off Or Reprogrammed (5754)
  • Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
  • MAZDA Wheel Lock Installation - Service Tip (02-001/06)
  • TPMS (Tire Pressure Monitoring System) Warning Lamp Illuminated And A Warning Buzzer - No DTCS - Service Tip (02-004/04)
• Window Motors & Regulators
  • Diagnostic Tips For Windshield Flaws/Scratches/Cracks Caused By External Factors (09-002/10)
  • Power Window Inoperative (09-035/04)
  • Rear Quarter Window Glass Lock Becomes Loose (09-011/04)
  • Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
• Wiper/Washer Systems
  • Multi-Model - Wiper Rubber Insert Replacement (09-009/10)
  • Windshield Wiper Blade Maintenance And Cleaning (09-006/06)