Technical Service Bulletins

• A/C Compressor
  • Air Conditioning Not Cooling / Leak Test Using Fluorescent Dye (LI83.00-P-045023)
  • Factory Approved Service Products (S-0473-08B)
  • Remanufactured NIPPONDENSO A/C Compressors & Clutch (83/53)
  • Factory Approved Service Products (00/53)
• Accessories & Equipment
  • DAS/XD Add-On 2013-09-02-3031 For Passenger Cars (GI58.40-P-057249)
  • DAS/XD Add-On 2013-09-02-3032 For Passenger Cars (GI58.40-P-057260)
  • DAS/XD Add-On 2013-09-02-3033 For Passenger Cars (GI58.40-P-057262)
  • DAS/XD Add-On 2013-03-25-2735 For Passenger Cars (GI58.40-P-056101)
  • DAS/XD Add-On 2013-04-22-2773 For Passenger Cars (GI58.40-P-056268)
  • DAS/XD Add-On 2013-07-29-2938 For Passenger Cars (GI58.40-P-056954)
  • DAS/XD Add-On 2013-07-29-2939 For Passenger Cars (GI58.40-P-056956)
  • DAS/XD Add-On 2013-08-05-2955 For Passenger Cars (GI58.40-P-056990)
  • DAS/XD Add-On 2013-08-05-2956 For Passenger Cars (GI58.40-P-056985)
  • DAS/XD Add-On 2013-08-12-2968 For Passenger Cars (GI58.40-P-057091)
  • Handling Lead-Free Filling Solder (60.00/22)
  • DAS/XD Add-On 2012-08-03-2448 For Passenger Cars (GI58.40-P-054485)
  • DAS/XD Add-On 2012-07-16-2412 For Passenger Cars (GI58.40-P-054318)
  • DAS/XD Add-On 2012-07-16-2413 For Passenger Cars (GI58.40-P-054322)
  • DAS/XD Add-On 2012-07-23-2428 For Passenger Cars (GI58.40-P-054325)
  • DAS/XD Add-On 2012-07-26-2427 For Passenger Cars (GI58.40-P-054324)
  • DAS/XD Add-On 2012-03-05-2215 For Passenger Cars (GI58.40-P-053392)
  • Multi-Grade Metal Grease (00.45/94)
  • DAS/XD Add-On 2010-05-03-1455 For Passenger Cars (LI58.40-P-050035)
  • DAS/XD Add-On 2010-05-20-1476 For Passenger Cars (LI58.40-P-050043)
  • DAS/XD Add-On 2010-05-25-1480 For Passenger Cars (LI58.40-P-050045)
  • Original, Approved Protective Covers For Fenders, Seats, And Front And Rear Fascia (58/93A)
• Accessories Control Systems
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • DAS/XD Add-On 2010-05-03-1455 For Passenger Cars (LI58.40-P-050035)
  • DAS/XD Add-On 2010-05-25-1480 For Passenger Cars (LI58.40-P-050045)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Fluke Digital MULTIMETER Operation Safety Notice (58.30/105)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
  • Erroneous Diagnostic Codes (00/48)
• Air Bag, SRS
  • Repair And Diagnosis Of Airbag Wiring Harnesses (91.60/195A)
  • Code 9077 "VIN'S In Control Modules N2/7 And N73 Are Not Identical" Current And Stored After Installing New Ab Module (TT 01/11-J)
  • Airbag Durability And Reliability (91.60/193)
  • Technicians Using Star Diagnosis Systems During A Road Test (91.00/47)
  • Replacement Of Airbag Control Module (DTB 16/01; MB-NET 142)
  • Airbag Unit Replacement Label And Replacement Date Label Inserts (91/48A)
  • The Passenger Airbag In Every USA MERCEDES-BENZ Is Installed To Comply With Federal Motor Vehicle Safety Standard 208 (DTB 14/96-2; MB-NET 273)
  • Child Protection Warning Label For Airbag Models (91/28)
• Anti-Lock Brakes
  • DAS/XD Add-On 2010-05-25-1480 For Passenger Cars (LI58.40-P-050045)
• Anti-Theft Systems
  • Warranty Key Returns (LI80.35-P-045746)
  • All Outer Door Panels Being Replaced By Door Shell (72/10)
  • Replacement Of Door Interior Trim Panel Components (72/55)
  • Up Grade To Alarm Tester 924 589 00 21 00 (58/98)
  • ATA Tester Limitations (DTB 38/97-6; MB-NET 510)
  • Lubricating Hood Latches & Hinges (00/139)
  • PRELOADING Doors After Replacement (72/52)
• Automatic Trans
  • Lubricating Oil Analysis Information (LI01.00-P-068886)
  • P060C00 And P282212 Stored In Transmission 9G-TRONIC VGS Control Unit (LI27.60-P-064292)
  • Compatibility Of Transmission Fluids "Gold," "Red," & "Blue" (TT 07/14-C)
  • Factory Approved Service Products (S-0473-08B)
  • Transmission Kick-Down And Air Conditioning Become Non-Functional After Replacement Of The Over Voltage Protection Module (27.19/79)
  • Preliminary Approval Of The Following DEXRON III Automatic Transmission Fluids (DTB 25/95-2; MB-NET 470)
  • Fixture For B-1 Piston R & I - Auto Trans.722.3/4/5 (58/84)
  • Exchange Transmission - Modified Piston Seal Ring (27/96)
  • Installation & Use Of Self-Tapping Fasteners (00/126)
  • 722.3/4/5 - Technical Innovations & Modifications (27/95)
  • 722.3/4/5 - Sealing Plugs For Vacuum Actuators (27/94)
  • Factory Approved Service Products (00/53)
  • 722.3/4/5 - Modified Automatic Trans. Fluid Dipstick (27/92)
• Auxiliary Emission Control Systems
  • I/M 240 Emissions Testing On Dynamometer (14.00/31)
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • DAS/XD Add-On 2010-05-03-1455 For Passenger Cars (LI58.40-P-050035)
  • Engine Performance (07.00/19)
  • Replacement Emission Control Labels And VIN Tags For Vehicles (00.00/72)
  • Vehicles Inadvertently Failing On-Board Diagnostic Inspections In State Operated Testing Lanes (14.00/14)
  • Diagnosing Activated Check Engine Light Or Stored DTC(S) (DTB 50/00; MB-NET 406)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Connector For Intake Air Temperature Sensor (B17) Damaged (DTB 19/00; MB-NET 145)
  • HERMANN Electronics Diagnostic Engine Analyzers (58.40/104)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Fluke Digital MULTIMETER Operation Safety Notice (58.30/105)
  • I/M 240 Emission Testing On Dynamometer (14/12A)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Dual Distributor Adapter (DDA) With V-12 Capability (58/57A)
  • Enhanced State Emission Inspection Programs (DTB 01/95-4; MB-NET 554)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
  • Ea/Cc/ISC Actuator HARNRSS Routing (30/11A)
  • Erroneous Diagnostic Codes (00/48)
• Axle Shafts
  • Cleaning Axle Hubs When Installing Brake Discs (42.10/123A)
  • Pulling Rear Hub With New Removal/Installation Tool (35/76)
• Blowers, Superchargers & Turbochargers
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
• Body Electrical
  • Wiring Damage On More Than 10 Wires (LI54.18-P-072022)
  • Repair And Diagnosis Of Airbag Wiring Harnesses (91.60/195A)
  • Repair Of Damaged Audio/COMAND Wiring Harnesses (82.00/701)
  • Wiring Harness Repair Kit (58.20/118B)
  • Wiring Harness Repair Kit (58.20/118A)
• Body Interior
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • DAS/XD Add-On 2010-05-03-1455 For Passenger Cars (LI58.40-P-050035)
  • DAS/XD Add-On 2010-05-25-1480 For Passenger Cars (LI58.40-P-050045)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Fluke Digital MULTIMETER Operation Safety Notice (58.30/105)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
  • Erroneous Diagnostic Codes (00/48)
• Brakes Control Systems
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • DAS/XD Add-On 2010-05-25-1480 For Passenger Cars (LI58.40-P-050045)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
• Charging Systems
  • Transmission Kick-Down And Air Conditioning Become Non-Functional After Replacement Of The Over Voltage Protection Module (27.19/79)
  • Wiring Harness Repair Kit (58.20/118A)
• Communication Devices
  • Telephone Calls Being Cut Off Or Dropped (LI82.70-P-046814)
  • C- And E-Class Cellular Telephone / Dropped Calls When Placing Handset Into Cradle (DTB 07/96-4; MB-NET 175)
  • Cellular Telephone System Installation (82/70A)
• Cooling System (Mechanical)
  • Factory Approved Service Products (S-0473-08B)
  • Subsequent Installation Of Engine Block Heater (20/12A)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
• Cruise Control Systems
  • Cruise Control Inoperative (30.30/61)
• Differentials & Drive Axles
  • Lubricating Oil Analysis Information (LI01.00-P-068886)
  • Factory Approved Service Products (S-0473-08B)
  • Factory Approved Service Products (00/53)
• Driveshaft & Universal Joints
  • Humming/Howling/Droning Noise From Drivetrain (LI28.00-P-060078)
  • Checking & Adjusting Overall Drive Shaft Alignment (41/17)
• Engine Control Systems
  • Use Of E10 Fuel (47.00/61)
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • Return Delivery Of Fuel System Parts (47.00/58)
  • DAS/XD Add-On 2010-05-03-1455 For Passenger Cars (LI58.40-P-050035)
  • Factory Approved Service Products (S-0473-08B)
  • Engine Performance (07.00/19)
  • Diagnosing Activated Check Engine Light Or Stored DTC(S) (DTB 50/00; MB-NET 406)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Connector For Intake Air Temperature Sensor (B17) Damaged (DTB 19/00; MB-NET 145)
  • Mass Air Flow Sensors Damaged By Particles (DTB 40/99-2, MB-NET 486)
  • Fuel Filter Must Be Visually Checked For Damage (DTB 39/99-2; MB-NET 479)
  • HERMANN Electronics Diagnostic Engine Analyzers (58.40/104)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Fluke Digital MULTIMETER Operation Safety Notice (58.30/105)
  • Use Of Portable DEFUELER/REFUELER Tanker (58/99)
  • HHT/ Incorrect Pin Display (DTB 22/97-2; MB-NET 262)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Dual Distributor Adapter (DDA) With V-12 Capability (58/57A)
  • Reformulated Gasoline (DTB 01/95-2)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
  • Reformulated Gasoline (01/95-2)
  • 9-Pole Diagnostic Connector & TDC Sensor Eliminated (58/74)
  • Ea/Cc/ISC Actuator HARNRSS Routing (30/11A)
  • Erroneous Diagnostic Codes (00/48)
• Entertainment Systems
  • MBUX Multimedia System (A26/17) - SIRIUSXM "My Favorites" Category Lost After Bus Sleep (LI82.60-P-075292)
  • Repair Of Damaged Audio/COMAND Wiring Harnesses (82.00/701)
  • Cd Changer Skipping During Playback, Radio Not Recognizing Magazine Insertion (82.62/169B)
  • Use Of Non Commercial Compact Discs In MBUSA Cd Changers And Cd Players (DTB 32/01; MB-NET 203)
  • Cellular Telephone System Diagnosis & Return Form (82/108)
  • Cd Changer - Installation & Compatibility (82/97)
  • Audio System Diagnosis & Return Form (82/92)
  • Radios, Volume Control Knobs (DTB 18/95-2; MB-NET 352)
  • BECKER Radio Diagnostic Information (82/78)
  • Cd Changer Installation - Procedure/Warranty Info (82/69B)
• Exhaust
  • Humming/Howling/Droning Noise From Drivetrain (LI28.00-P-060078)
  • The Care Of Chrome Tail Pipe Finishers (49.10/11)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
• Exterior Body Panels
  • Fuel Filler Door Difficult To Open (VERSION 4)
  • Introduction Of Two-Component Epoxy Body Filler (60.00/23)
  • Dedicated Straightening Equipment For Collision Repair (60/04E)
  • Multi-Grade Metal Grease (00.45/94)
  • Original, Approved Protective Covers For Fenders, Seats, And Front And Rear Fascia (58/93A)
  • Approved PAINTLESS Dent Repair (PDR) (60.00/13)
  • All Outer Door Panels Being Replaced By Door Shell (72/10)
  • MULTISPOT M83 Resistance Spot Welder (60.00/08B)
  • MULTISPOT M20 Resistance Welder (60.00/12)
  • Use Of Portable DEFUELER/REFUELER Tanker (58/99)
• Exterior Lights
  • Headlamps/Front Fog Lamps Leaking Or Fogged (LI82.10-P-050139)
  • Daytime Running Lights Do Not Switch Off When The Engine Is Off (LI82.10-P-049638)
  • Bonding Headlamp LENSE To Housing (82/81)
  • Correct Bulb Usage - Overheated Bulb Socket (82/75)
• Frames, Subframes & Crossmembers
  • Dedicated Straightening Equipment For Collision Repair (60/04E)
  • Corrosion Protection Without Hexavalent Chromium VI (97.30/05)
  • MULTISPOT M83 Resistance Spot Welder (60.00/08B)
  • MULTISPOT M20 Resistance Welder (60.00/12)
• Front Suspension
  • Shock Absorber Replacement (32.25/82C)
  • Assembly Of Suspension Struts And Shock Absorbers (32.25/83)
  • Replacement Procedure Of Shock Absorbers And Suspension Struts (LI32.25-P-045461)
  • Corrosion Protection Without Hexavalent Chromium VI (97.30/05)
  • Vehicle Wheel Alignment Equipment Compliance (58.30/45A)
  • Vehicle Alignment Specifications Available On Software Cd (58.00/130E)
  • Checking Lower Front Axle Ball Joint (33/34)
  • New 3-Lug Spring Compressor (58/54A)
• Fuel System
  • Use Of E10 Fuel (47.00/61)
  • Return Delivery Of Fuel System Parts (47.00/58)
  • Factory Approved Service Products (S-0473-08B)
  • Mass Air Flow Sensors Damaged By Particles (DTB 40/99-2, MB-NET 486)
  • Fuel Filter Must Be Visually Checked For Damage (DTB 39/99-2; MB-NET 479)
  • Use Of Portable DEFUELER/REFUELER Tanker (58/99)
  • HHT/ Incorrect Pin Display (DTB 22/97-2; MB-NET 262)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
  • Reformulated Gasoline (DTB 01/95-2)
  • Reformulated Gasoline (01/95-2)
  • 9-Pole Diagnostic Connector & TDC Sensor Eliminated (58/74)
• Fuses & Circuit Breakers
  • Wiring Damage On More Than 10 Wires (LI54.18-P-072022)
  • Wiring Harness Repair Kit (58.20/118B)
  • Wiring Harness Repair Kit (58.20/118A)
  • Wiring Harness Damage (58.20/127A)
  • Wiring Harness Repair Kit (58.20/118)
  • SRS Wiring Harness Repair/Ordering Procedure (91.60/37)
  • Campaign 95-0223 - Metal Footrest Cuts Wiring (95-0223)
  • Ea/Cc/ISC Actuator HARNRSS Routing (30/11A)
• Gauges & Instrument Panels
  • Switches In Center Console Loose (68/5A)
• Hazardous Waste Material
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
• Headlights
  • Headlamps/Front Fog Lamps Leaking Or Fogged (LI82.10-P-050139)
  • Daytime Running Lights Do Not Switch Off When The Engine Is Off (LI82.10-P-049638)
  • Bonding Headlamp LENSE To Housing (82/81)
  • Correct Bulb Usage - Overheated Bulb Socket (82/75)
• Hoist/Jack
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
• HVAC Control Systems
  • Air Conditioning Not Cooling / Leak Test Using Fluorescent Dye (LI83.00-P-045023)
  • Factory Approved Service Products (S-0473-08B)
  • Transmission Kick-Down And Air Conditioning Become Non-Functional After Replacement Of The Over Voltage Protection Module (27.19/79)
  • Remanufactured NIPPONDENSO A/C Compressors & Clutch (83/53)
  • Factory Approved Service Products (00/53)
• Identification
  • Replacement Emission Control Labels And VIN Tags For Vehicles (00.00/72)
  • Airbag Unit Replacement Label And Replacement Date Label Inserts (91/48A)
  • Child Protection Warning Label For Airbag Models (91/28)
• Ignition System
  • Spark Plug Connector Grease (15.10/74)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
• Infotainment
  • MBUX Multimedia System (A26/17) - SIRIUSXM "My Favorites" Category Lost After Bus Sleep (LI82.60-P-075292)
  • Repair Of Damaged Audio/COMAND Wiring Harnesses (82.00/701)
  • Poor Radio Reception (DTB 05/00; MB-NET 021)
• Interior/Exterior Trim
  • Water Ingress At A-Pillar (LI77.00-P-063165)
  • Multi-Grade Metal Grease (00.45/94)
  • Original, Approved Protective Covers For Fenders, Seats, And Front And Rear Fascia (58/93A)
  • The Care Of Chrome Tail Pipe Finishers (49.10/11)
  • Service Kit For Rectifying Squeaking, Creaking And Tearing Noises (00.45/77)
  • Replacement Of Door Interior Trim Panel Components (72/55)
  • Lubricating Hood Latches & Hinges (00/139)
  • Armrest Lid Travel Restriction Straps (DTB 28/95-3; MB-NET 512)
  • Installation & Use Of Self-Tapping Fasteners (00/126)
  • 6-Hole Wheel Covers For 15 Inch Wheels (40/127)
• Interior/Illumination Lights
  • Bonding Headlamp LENSE To Housing (82/81)
  • Correct Bulb Usage - Overheated Bulb Socket (82/75)
• Lubrication System
  • Lubricating Oil Analysis Information (LI01.00-P-068886)
  • Factory Approved Service Products (S-0473-08B)
  • Oil SLUDGING In Gasoline Engines (18.00/16A)
  • Excessive Oil Consumption Complaints (18.00/13)
  • Approved Oil Evacuation Equipment (58.00/118)
  • Oil Extraction Equipment Explanation/Ordering Info (58/95)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
  • Engine Oil Level - Do Not Overfill (00/57A)
  • Engines 104/119/120/603 Oil Consumption Test Sheets (18/43A)
  • Factory Approved Service Products (00/53)
• Manual Steering
  • Evaluating Play In Rack-And-Pinion Steering (LI46.20-P-071904)
  • Approved Hydraulic Fluids For Steering Systems (46.25/70A)
  • Approved Hydraulic Fluids For Steering Systems (46.25/70)
  • Factory Approved Service Products (S-0473-08B)
  • Replacing Feed Hose Between Reservoir & P/S Pump (46/03)
• Manual Trans
  • Factory Approved Service Products (S-0473-08B)
  • Factory Approved Service Products (00/53)
• Mechanical
  • Humming/Howling/Droning Noise From Drivetrain (LI28.00-P-060078)
  • Engine Diagnosis (TT 02/11-A)
  • Engine HYDROLOCK Repairs / Diagnosis (TT 02/11-B)
  • Factory Approved Service Products (S-0473-08B)
  • Reminder - Use Of BORESCOPE Or FIBERSCOPE As Workshop Equipment (DTB 16/97-2, MB-NET 195)
  • Service Information Regarding The Assessment Of Cylinder Walls Of Engines With Aluminum Alloy Crankcase (01/30)
  • Oil SLUDGING In Gasoline Engines (18.00/16A)
  • Special Tool Kit For Removing And Installing Valve Springs (58/91)
  • Excessive Oil Consumption Complaints (18.00/13)
  • Approved Oil Evacuation Equipment (58.00/118)
  • Mass Air Flow Sensors Damaged By Particles (DTB 40/99-2, MB-NET 486)
  • Oil Extraction Equipment Explanation/Ordering Info (58/95)
  • Rebuilding Light-Alloy Engine With ALLUMINUM Sleeves (01/9B)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
  • Om603 Short Block (DTB 15/95-2; MB-NET 322)
  • Anti-Corrosion Coating For Engine Compartment (98/48)
  • Replacement Of Ca MSHAFT Freeze Plugs (05/9)
  • Installation & Use Of Self-Tapping Fasteners (00/126)
  • Coding Of Crankshaft Main Bearing Shells & Tolerance (03/4A)
  • Engine Block In Open Deck Design/New Cam Bearing Cap (01/29A)
• Mechanical - Hydraulic
  • Vibration Or Noise When Braking (LI42.10-P-061801)
  • Diagnosing Complaints Of Brake Pulsation (TT 06/15-O)
  • Cleaning Axle Hubs When Installing Brake Discs (42.10/123A)
  • Brake Lining Installation Instructions (42.10/117A)
  • Brake Pad Paste Usage (42.10/110)
  • Self-Locking Brake Caliper Bolt Replacement (42.10/111)
  • Corrosion Of Brake Components (42.10/109)
  • Factory Approved Service Products (S-0473-08B)
  • Using Brake Disc Caliper/Gauge: MB Special Tool 140 589 00 19 00 (58.00/002)
  • REMACHINING Brake Discs (DTB 18/96-4; MB-NET 329)
  • Brake Lathe Approved For Standard Equipment Program (58/85)
  • Revised Anti-Corrosion Coating On Brake Discs (42/127)
  • Factory Approved Service Products (00/53)
• Memory Modules
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
• Mirrors
  • Power Window Motor Assembly (72/12)
• Paint & Coatings
  • Introduction Of Two-Component Epoxy Body Filler (60.00/23)
  • MBUSA Approved Refinishing Products (98.00/13V)
  • Factory Approved Service Products (S-0473-08B)
  • Approved PAINTLESS Dent Repair (PDR) (60.00/13)
  • MBNA Approved Refinishing Products (98/13C)
  • Paint Warranty/Suppliers (98/12B)
  • Water-Borne Paint Application Identification (98/54)
  • Vehicle Paint Damage Due To Environmental Fallout (98/11)
• Passive Restraints
  • Repair And Diagnosis Of Airbag Wiring Harnesses (91.60/195A)
  • Dirty Seats (LI91.18-P-045700)
  • Original, Approved Protective Covers For Fenders, Seats, And Front And Rear Fascia (58/93A)
  • Repairs For Noise Complaints Regarding Seats (91.00/37)
• Rear Suspension
  • Shock Absorber Replacement (32.25/82C)
  • Assembly Of Suspension Struts And Shock Absorbers (32.25/83)
  • Repairing Self-Locking Threaded Axle Mount Connections (35.00/08)
  • Replacement Procedure Of Shock Absorbers And Suspension Struts (LI32.25-P-045461)
  • Corrosion Protection Without Hexavalent Chromium VI (97.30/05)
  • Vehicle Alignment Specifications Available On Software Cd (58.00/130E)
  • Checking Lower Front Axle Ball Joint (33/34)
  • New 3-Lug Spring Compressor (58/54A)
  • Pulling Rear Hub With New Removal/Installation Tool (35/76)
• Restraints Control Systems
  • Repair And Diagnosis Of Airbag Wiring Harnesses (91.60/195A)
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • Code 9077 "VIN'S In Control Modules N2/7 And N73 Are Not Identical" Current And Stored After Installing New Ab Module (TT 01/11-J)
  • Airbag Durability And Reliability (91.60/193)
  • Technicians Using Star Diagnosis Systems During A Road Test (91.00/47)
  • Replacement Of Airbag Control Module (DTB 16/01; MB-NET 142)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Fluke Digital MULTIMETER Operation Safety Notice (58.30/105)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
  • Erroneous Diagnostic Codes (00/48)
• Seats
  • Dirty Seats (LI91.18-P-045700)
  • Original, Approved Protective Covers For Fenders, Seats, And Front And Rear Fascia (58/93A)
  • Repairs For Noise Complaints Regarding Seats (91.00/37)
  • SRS Wiring Harness Repair/Ordering Procedure (91.60/37)
  • Front Seat Head Restraints With Reduced Post Length (91/53)
  • Power Window Motor Assembly (72/12)
• Starter
  • Charge Battery (54.10/255)
  • New Required Replacement MIDTRONICS Battery Tester; Special Tool: 165-Exp 717 Kit (58.20/155)
  • MIDTRONICS Battery Charger 165-PSC-550KIT (58.40/148)
  • Upgrade Program For The MBUSA Special Tool: 900 589 09 21 00; MIDTRONICS Battery Tester (MRC 717) (58.20/146A)
  • New Battery Test Procedure, Using MIDTRONICS MCR 717 Battery (58.00/124A)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
  • Battery Jump-Starting And Charging (54/40A)
  • Battery Care - Service Information (54/38)
• Steering Control Systems
  • Approved Hydraulic Fluids For Steering Systems (46.25/70A)
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • Approved Hydraulic Fluids For Steering Systems (46.25/70)
  • Factory Approved Service Products (S-0473-08B)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
• Steering Gear
  • Approved Hydraulic Fluids For Steering Systems (46.25/70A)
  • Approved Hydraulic Fluids For Steering Systems (46.25/70)
  • Factory Approved Service Products (S-0473-08B)
  • Replacing Steering Gear After An Accident (46/57)
• Steering Linkage
  • Vehicle Wheel Alignment Equipment Compliance (58.30/45A)
  • Vehicle Alignment Specifications Available On Software Cd (58.00/130E)
  • Replacing Steering Gear After An Accident (46/57)
  • Pulling Rear Hub With New Removal/Installation Tool (35/76)
• Sun Roof/T-Top/Convertible Top
  • Water Ingress At A-Pillar (LI77.00-P-063165)
  • Lubricating Hood Latches & Hinges (00/139)
• Suspension Control Systems
  • Assembly Of Suspension Struts And Shock Absorbers (32.25/83)
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • Replacement Procedure Of Shock Absorbers And Suspension Struts (LI32.25-P-045461)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
• System
  • Spark Plug Connector Grease (15.10/74)
  • Use Of E10 Fuel (47.00/61)
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • Return Delivery Of Fuel System Parts (47.00/58)
  • DAS/XD Add-On 2010-05-03-1455 For Passenger Cars (LI58.40-P-050035)
  • Factory Approved Service Products (S-0473-08B)
  • Engine Performance (07.00/19)
  • Replacement Emission Control Labels And VIN Tags For Vehicles (00.00/72)
  • Vehicles Inadvertently Failing On-Board Diagnostic Inspections In State Operated Testing Lanes (14.00/14)
  • Diagnosing Activated Check Engine Light Or Stored DTC(S) (DTB 50/00; MB-NET 406)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Connector For Intake Air Temperature Sensor (B17) Damaged (DTB 19/00; MB-NET 145)
  • Mass Air Flow Sensors Damaged By Particles (DTB 40/99-2, MB-NET 486)
  • Fuel Filter Must Be Visually Checked For Damage (DTB 39/99-2; MB-NET 479)
  • HERMANN Electronics Diagnostic Engine Analyzers (58.40/104)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Fluke Digital MULTIMETER Operation Safety Notice (58.30/105)
  • Use Of Portable DEFUELER/REFUELER Tanker (58/99)
  • I/M 240 Emission Testing On Dynamometer (14/12A)
  • HHT/ Incorrect Pin Display (DTB 22/97-2; MB-NET 262)
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Dual Distributor Adapter (DDA) With V-12 Capability (58/57A)
  • Enhanced State Emission Inspection Programs (DTB 01/95-4; MB-NET 554)
  • Reformulated Gasoline (DTB 01/95-2)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
  • Reformulated Gasoline (01/95-2)
  • 9-Pole Diagnostic Connector & TDC Sensor Eliminated (58/74)
  • Ea/Cc/ISC Actuator HARNRSS Routing (30/11A)
  • Erroneous Diagnostic Codes (00/48)
• Towing
  • Fluke Meter Approved For Standard Equipment Program (58/87A)
• Transfer Case
  • Factory Approved Service Products (S-0473-08B)
  • Factory Approved Service Products (00/53)
• Transmission Control Systems
  • P060C00 And P282212 Stored In Transmission 9G-TRONIC VGS Control Unit (LI27.60-P-064292)
  • Preventing Damage To Electronic Components Due To Electrostatic Discharge (54.00/238)
  • DAS/XD Add-On 2010-05-20-1476 For Passenger Cars (LI58.40-P-050043)
  • DAS/XD Add-On 2010-05-25-1480 For Passenger Cars (LI58.40-P-050045)
  • Transmission Kick-Down And Air Conditioning Become Non-Functional After Replacement Of The Over Voltage Protection Module (27.19/79)
  • Improved Diagnostic Plug Connector Housing For Star Diagnosis (58.40/112)
  • Year 2000 Problem And Its Impact On Vehicle Software (00.00/68)
  • Fluke Digital MULTIMETER Operation Safety Notice (58.30/105)
  • Multiplex Cable (965 589 00 40 XX) Pin Breakage (DTB 33/95-2; MB-NET 620)
  • Hand-Held Tester Module Updates - New 4 MBYTE Module (99/154B)
  • Hand-Held Tester Ordering Information (99/162A)
• Wheel Alignment
  • Vehicle Wheel Alignment Equipment Compliance (58.30/45A)
  • Vehicle Alignment Specifications Available On Software Cd (58.00/130E)
• Wheel Hubs
  • Cleaning Axle Hubs When Installing Brake Discs (42.10/123A)
  • Pulling Rear Hub With New Removal/Installation Tool (35/76)
• Wheels & Tire System
  • Center Caps On The Wheels May Have Surface Damage, Corrosion, Or Fading (LI40.10-P-068659)
  • Cleaning Axle Hubs When Installing Brake Discs (42.10/123A)
  • Checking Components For Bolted Wheel Connection (40.10/72)
  • Corrosion Of Brake Components (42.10/109)
  • Approved Alkaline MB Wheel Cleaner For Light Alloy Disk Wheel (40.10/66)
  • Nitrogen Use In Tire Inflation (40.10/60)
  • Chrome Plating Of MERCEDES-BENZ Light Alloy Wheels (40/18)
  • MICHELIN Pilot Sport A/S Tires (40.10/43A)
  • New & Updated Wheel Balancer Flange Plate & Centering Adapters (58/82A)
  • Tires - Proper Maintenance And Inspection (40.10/36)
  • Storage Of Vehicles Equipped With High Performance Tires (40.10/34)
  • Factory-Approved Summer/All-Season/Winter Tires (40/20M)
  • Centering Adapters For Wheel Balancers (58/82UP)
  • Installation Of AMG Light Alloy Accessory Wheels (40/25A)
  • Drivetrain Noise & Vibration (41/18)
  • E-Class Limited Edition Models Have A Unique, 6-Hole Alloy Wheel (DTB 05/95-2; MB-NET 148)
  • Pulling Rear Hub With New Removal/Installation Tool (35/76)
  • 6-Hole Wheel Covers For 15 Inch Wheels (40/127)
  • 8-Hole Wheel Rim Installation (40/21D)
  • Model Year 1994 Vehicle Stopping Distances (42/14)
• Window Motors & Regulators
  • Introduction Of Improved Single-Component Windshield/Window Bonding System (67.10/27)
  • New Window Glazing One-Component Adhesive Repair Kit (67.00/25)
  • Damage To Laminated Glass Due To Chips Or Cracks (67/02)
  • Poor Radio Reception (DTB 05/00; MB-NET 021)
  • New MB Windshield Washer Concentrate (82.35/113A)
  • Lubricating Hood Latches & Hinges (00/139)
  • Power Window Motor Assembly (72/12)
• Wiper/Washer Systems
  • Windshield Washer System: Maintaining Wiping Quality And Controlling Noise (82.35/621A)
  • Factory Approved Service Products (S-0473-08B)
  • Replacement Windshield Wiper Inserts (DTB 26/98-2; MB-NET 523)
  • New MB Windshield Washer Concentrate To Improve Windshield Cleaning (DTB 23/98-2; MB-NET 478)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Repair And Diagnosis Of Airbag Wiring Harnesses (91.60/195A)
  • Repair Of Damaged Audio/COMAND Wiring Harnesses (82.00/701)
  • Wiring Harness Repair Kit (58.20/118B)
  • Wiring Harness Repair Kit (58.20/118A)
  • Wiring Harness Damage (58.20/127A)
  • Wiring Harness Repair Kit (58.20/118)
  • SRS Wiring Harness Repair/Ordering Procedure (91.60/37)
  • Campaign 95-0223 - Metal Footrest Cuts Wiring (95-0223)
  • Ea/Cc/ISC Actuator HARNRSS Routing (30/11A)