Section 12 (Climate Control System -- 118 Chassis)
WARNING: This page does not describe the selected car, but rather 12 other vehicles, including the 2023 Mercedes-Benz CLA45 AMG, 2023 Mercedes-Benz CLA35 AMG, 2023 Mercedes-Benz CLA250, 2022 Mercedes-Benz CLA45 AMG, and 2022 Mercedes-Benz CLA35 AMG. However, it is still accessible from the selected car via links, so may be relevant.
- Description & Operation
- General Information
- General Note On Operation Items And Work Scopes For Refrigerant Lines - AH83.00-P-0200-01A
- General Notes: Passenger Cars: Climate Control - AH83.00-Z-9999AZ
- Notes On Retrofitting An Air Conditioning System - AH83.30-P-0001-02A
- Notes On Handling Refrigerant R134A - AH83.30-P-0003-01KOA
- Notes On Handling Refrigerant R1234yf - AH83.30-P-0003-02A
- Procedure For A Damaged Or Leaky Air Conditioning System - AH83.30-P-0004-01KOA
- Protect Air Conditioning Circuit And Components From Moisture When Carrying Out Repair Work - AH83.30-P-0005-01KOA
- Repair Work For Defective Refrigerant Circuit - AH83.30-P-1782-01A
- Basic Knowledge
- Climate Control, Basic Function
- Basic Air Conditioning System Function - GF83.00-P-9902A
- Comfort Heaters Automatic Shutoff, Basic Function - GF83.20-P-1000A
- Heating Circuit, Basic Function - GF83.20-P-1002A
- (Electric Drive Heating Circuit, Basic Function - GF83.20-P-1003A)
- Comfort Heating, Basic Function - GF83.20-P-9900A
- Refrigerant Circuit, Basic Function - GF83.40-P-1001A
- Air-Recirculation Mode, Basic Function - GF83.40-P-1002A
- Operating Modes, Basic Function - GF83.40-P-1003A
- Air Distribution, Basic Function - GF83.40-P-1004A
- Air Conditioner Housing, Basic Function - GF83.40-P-2015A
- A/C Operating Unit, Basic Function - GF83.40-P-2016A
- Expansion Valve, Basic Function - GF83.40-P-2018A
- Outlet Air Temperature Sensor, Basic Function - GF83.40-P-2019A
- Circulation Pump, Basic Function - GF83.40-P-2020A
- Refrigerant Pressure Sensor, Basic Function - GF83.40-P-2021A
- Air Quality Sensor, Basic Function - GF83.40-P-2022A
- Fine Particle Sensor, Basic Function - GF83.40-P-2023A
- (Pre-Entry Climate Control, Basic Function - GF83.40-P-9900A)
- Electric Refrigerant Compressor, Basic Function - GF83.55-P-2000A
- Mechanical Refrigerant Compressor, Basic Function - GF83.55-P-2001A
- Stationary Heater Unit, Basic Function - GF83.70-P-2013A
- (High-Voltage PTC Heater, Basic Function - GF83.70-P-2014A)
- Stationary Heater Switchover Valve, Component Description - GF83.70-P-4068L
- Stationary Heater Fuel Pump, Component Description - GF83.70-P-4209L
- Stationary Heater, Basic Function - GF83.70-P-9900A
- Fragrance System, Basic Function - GF83.80-P-9900A
- Ionization, Basic Function - GF83.80-P-9901A
- Safety Precautions
- Risk Of Explosion Caused By Welding Or Soldering Work On Closed Air Conditioning System. Risk Of Poisoning Caused By Inhaling Overheated Refrigerant Vapors Risk Of Injury To Skin And Eyes Caused By Contact With Liquid Refrigerant. - AS83.00-Z-0001-01A
- Risk Of Explosion When Using A Forming Gas With Incorrect Mixing Ratio. Risk Of Suffocation Due To Inhalation Of Forming Gas. Risk Of Injury Due To Bursting Of High-Pressure Hoses. - AS83.00-Z-0001-02A
- Risk Of Poisoning Caused By Inhaling Overheated Refrigerant Vapors From An Air Conditioning System Containing R134A. Risk Of Injury To Skin And Eyes Caused By Contact With Liquid R134A Refrigerant And When Working On Pressurized Parts - AS83.00-Z-0006-01A
- Risk Of Fire Due To Ignition Of R1234Yf Refrigerant On Hot Components. Risk Of Poisoning Caused By Inhaling Overheated Refrigerant Vapors. Risk Of Injury To Skin And Eyes Caused By Contact With Escaped R1234Yf Refrigerant And When Working - AS83.00-Z-0007-01A
- Safety Information: Climate Control - AS83.00-Z-9999ZZ
- Risk Of Explosion Caused By Fuel Vapors Igniting, Risk Of Poisoning Caused By Inhaling Combustible Gases And Risk Of Injury Caused By Burns During And After Operation Of Heater Unit - AS83.70-Z-0002-01A
- Testing & Repair
- Remove/Install Cover For Air/Water Duct - AR83.10-P-1411MFA
- Remove/Install Defroster/Footwell/Center Air Vent Flap Actuator Motor - AR83.10-P-2037MFA
- Remove/Install Fresh Air/Ram Air/Recirculated Air Flap Actuator Motor - AR83.10-P-2038MFA
- Remove/Install Center Air Vent - AR83.10-P-4509MFA
- Remove/Install Front Side Air Vent - AR83.10-P-4741MFA
- Remove/Install Climate Control Heat Exchanger - AR83.25-P-1100MFA
- Remove/Install Blower Motor - AR83.25-P-1200MFA
- Remove/Install Electronic Blower Regulator/Control Unit - AR83.25-P-1220MFA
- Drain, Evacuate And Recharge Air Conditioning, Check For Proper Operation And Check For Leaks - AR83.30-P-1760MFA
- Check Air Conditioning System For Leakage - AR83.30-P-1761MFA
- Flush Air Conditioning - AR83.30-P-1785MFA
- Flush Air Conditioning - AR83.30-P-1785MFG
- Check Condensation Drain Hose Mount - AR83.30-P-5200-03A
- Remove/Install Air Conditioner Housing - AR83.30-P-5200MFA
- Correct Oil Level In Air Conditioning System In The Event Of Repair Or Slow Refrigerant Loss - AR83.30-P-5251MFD
- Correct Oil Level In Air Conditioning System If System Is Suddenly Drained - AR83.30-P-5253MFD
- Remove/Install Front Evaporator Shutoff Valve - AR83.30-P-5510MFG
- Remove/Install Expansion Valve - AR83.30-P-5520MFA
- Remove/Install Evaporator - AR83.30-P-5540MFA
- Perform Cleaning Of Evaporator - AR83.30-P-5555-02MA
- Cleaning The Evaporator - AR83.30-P-5555MFA
- Remove/Install Desiccant Cartridge
- Remove/Install AC Condenser
- Remove/Install Condenser In Wheel Arch - AR83.30-P-6542MFG
- Remove/Install Front A/C Operating Unit - AR83.30-P-6631MFA
- Remove/Install Mechanical Refrigerant Compressor
- Check Condensation Water Drainage Hoses For Blockages - AR83.65-P-2370A
- Remove/Install Stationary Heater Telestart Receiver - AR83.70-P-0014MFA
- Teach In Stationary Heater Telestart Transmitter - AR83.70-P-0018-01MFA
- Remove/Install Stationary Heater Unit - AR83.70-P-5302MFA
- Remove/Install Stationary Heater Fuel Metering Pump - AR83.70-P-5654MFA
- Test & Adjustment Values
- Maintenance
- Capacities & Specifications
- Torque Specifications
- Forms
- Criteria Catalog W 000 588 15 82 00 Air Conditioning Service Unit R134A, Form - OF83.00-P-0001-01B
- Analysis Sheet For Fogged Windows, Form - OF83.00-P-3000-01A
- Forms: Passenger Cars: Climate Control - OF83.00-Z-3999AZ
- Analysis Sheet For Complaints About Blower Motor Noise, Form - OF83.10-P-3001-01A
- Automatic Air Conditioning, Form - OF83.40-P-3000-02A
- Wiring Diagrams
- Special Tools
- 000 589 71 03 00 Box Wrench Bit - WS83.00-P-0001K
- 000 588 10 21 00 Leak Tester - WS83.00-P-0008B
- 000 588 04 82 00 Air Conditioning Service Unit R134A - WS83.00-P-0031B
- 000 588 10 82 00 R1234yf Air Conditioning Service Unit - WS83.00-P-0034B
- 000 588 19 21 00 Leak Tester - WS83.00-P-0035B
- 222 589 01 91 00 Adapter Set - WS83.00-P-0036B
- 213 589 01 63 00 Adapter - WS83.00-P-0038A
- 177 589 01 91 00 Adapter - WS83.00-P-0049B
- 221 589 00 91 12 Hose - WS83.00-P-0061-12B
- 221 589 00 91 00 Adapter Set - WS83.00-P-0061B
- 000 588 15 82 00 Air Conditioning Service Unit R134A - WS83.00-P-0064B
- 000 588 35 21 00 Leak Tester - WS83.00-P-0065B
- 000 588 18 82 00 R1234yf Air Conditioning Service Unit - WS83.00-P-0066B
- 000 588 37 21 00 Leak Tester - WS83.00-P-0067B