Technical Service Bulletins

• A/C Compressor
  • Identification Of Non-Ford Approved Refrigerants (99-19-6)
  • Use Of R-12 Refrigerant Substitutes (96-17-10)
  • Ford Approved Flushing Procedures For A/C System (95-8-1)
  • R-12 Refrigerant Substitutes - Service Tip (94-14-3)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
  • A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
  • New Refrigerant Fitting "O" Rings (91-22-5)
  • Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
  • A/C "O" Ring Usage Table (90-14-8)
  • Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
  • A/C Drier - Replace When Major Component Serviced (88-25-5)
  • A/C Clutch Slips/Overheats - New Clutch Assembly (88-2-4)
  • A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
  • A/C Clutch Damage From OVERTIGHTEN - Torque Wrench (86-22-7)
  • A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
  • A/C Compressor Clutch Assembly I.D. (85-23-3)
• Accessories Control Systems
  • Latches - Door - Replacement Required (91-8-4)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
• Anti-Lock Brakes
  • Brakes - Roughness Concern During Brake Application (95-6-2)
• Anti-Theft Systems
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Latches - Door - Replacement Required (91-8-4)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
• Automatic Trans
  • Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
  • New Rotunda Fluid Changer - Service Tip (95-16-10)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • A/T Cooler Line Connections Leak - Modify Connectors (87-18-13)
  • New ATF Applications Chart (87-18-14)
  • Intermediate Clutch Return Spring Retaining Ring Tab (87-15-6)
  • ATX Transaxle - Revised Planetary Gears (87-2-14)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
  • New Synthetic Trans Fluid Information/Application (86-11-17)
  • ATX Trans New Converter Hub Seal Design/Service (86-2-17)
  • ATX Revised In-Chassis Differential R & R (86-1-6)
  • Speedometer Gear Applications (85-21-4)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • One-Way Clutch Holding Tool Modification (85-22-13)
• Auxiliary Emission Control Systems
  • 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
  • EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
  • TPS Service Replacement Chart (89-16-4)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • ECM Spout Line Connector Locations (86-4-17)
  • 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
  • 1.6/1.9/2.0 L Eng Poor Drivability - PCV Vacuum Tree (86-22-14)
  • 1.6/1.9L Eng Idle Speed Varies - Throttle Plate Adj (86-7-13)
  • 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
  • 1.9L Eng PCV Valve "Hoot" Noise - Replace Valve/Hose (86-4-18)
  • 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
  • EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
  • Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
  • Low Spark/Poor Performance - Spout Connector Sleeve (86-20-7)
  • Low Spark/Poor Performance - Spout Connector Sleeve (86-17-10)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
  • Wire Terminal Testing - Test Equipment Modification (86-22-11)
• Blowers, Superchargers & Turbochargers
  • 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
  • 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
  • V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
• Body Interior
  • Electrical Diode Identification And Replacements (96-24-6)
  • A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
  • Latches - Door - Replacement Required (91-8-4)
  • Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
  • Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
  • A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
• Brakes Control Systems
  • Brakes - Roughness Concern During Brake Application (95-6-2)
• Charging Systems
  • Generator Harness Connector Damage - Loose Contact (96-21-4)
  • Low Charge - New Alternator Regulator Connector (87-16-5)
  • 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
  • V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
  • Low/No Battery Charge A/C On - New Alternator (86-24-6)
• Clutch
  • Asbestos Brake & Clutch Warnings (83-22-1)
• Cooling Fan
  • Cooling System - Use Of Recycled Engine Coolant (90-4-10)
• Cooling System (Mechanical)
  • Use Of Recycled Engine Coolant - Service Tip (95-18-2)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • Cooling System - Use Of Recycled Engine Coolant (90-4-10)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Low Coolant Warning System Kit (88-1-12)
  • 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
  • Diagnostic Tips For Heater Core Leaks (85-5-2)
  • 1.6/1.9/2.0/2.3L Non Ac Eng No Rad Fan - Cir Breaker (86-5-2)
  • 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
  • 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
  • High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
• Cruise Control Systems
  • Cruise Control Abnormal - Grease Electrical Contacts (89-3-4)
  • Dealer Installed Cruise Control Surge - Repair Kit (86-17-7)
• Differentials & Drive Axles
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
• Engine Control Systems
  • 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
  • TPS Service Replacement Chart (89-16-4)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • Fuel Line Spring Lock Coupling R & R (87-3-8)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • ECM Spout Line Connector Locations (86-4-17)
  • 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
  • 1.6/1.9/2.0 L Eng Poor Drivability - PCV Vacuum Tree (86-22-14)
  • 1.6/1.9L Eng Idle Speed Varies - Throttle Plate Adj (86-7-13)
  • 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
  • 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
  • EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
  • Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
  • Low Spark/Poor Performance - Spout Connector Sleeve (86-20-7)
  • Low Spark/Poor Performance - Spout Connector Sleeve (86-17-10)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
  • Wire Terminal Testing - Test Equipment Modification (86-22-11)
• Entertainment Systems
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • Approved Radio Servicing Procedures (85-22-5)
  • Door Speaker Water Damage - New Speaker Cover (86-17-5)
  • Engine Miss/Surge Radio Noise - IGNITON Rotor Grease (85-21-8)
  • Mechanically Tuned Radio/Cassette Unstable Reception (85-19-4)
  • Radio IGN Noise - Confirm Distributor Rotor Lube (86-17-6)
• Exhaust
  • 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
• Exterior Body Panels
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • High Mount BRAKELAMP Moisture: Resealing Procedure (87-24-1)
  • Sealer Drips Onto Interior/Trunk: Cleaning Products (86-21-3)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • "B" Pillar Crack - Quarter Panel Reinforcement (86-6-6)
• Exterior Lights
  • Latches - Door - Replacement Required (91-8-4)
  • False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
  • Moisture Inside Headlight Lens - Diagnosis/Repair (87-13-4)
  • Towing - New Fog Lamp Bracket (86-11-2)
  • Headlamps Flash With FOGLIGHT On - New Wiring/Switch (89-9T-14)
• Frames, Subframes & Crossmembers
  • Bumper ISOLATER And Bracket Replacement Guidelines (94-8-1)
  • Bumper Cover - Improved Repair Materials (93-24-1)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • "B" Pillar Crack - Quarter Panel Reinforcement (86-6-6)
• Front Suspension
  • Suspension Stabilizer Bar Noise - New Bushings (88-4-10)
  • SUSP Grunt - P/S Tie Rod Joint/Stabilizer Bar Mount (87-7-8)
  • Suspension Spring Identification/Applications (86-6B-1)
  • Front Alignment Revised Specifications (86-2-11)
• Fuel System
  • 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
  • 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • CFI Fuel Injector Contamination - Replace Injector (87-17-5)
  • Fuel Line Spring Lock Coupling R & R (87-3-8)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • Fuel Pressure Tool (86-11-21)
  • New O-Ring Part # For Fuel Supply/Return Spring Lock (86-12-7)
• Fuses & Circuit Breakers
  • Electrical Diode Identification And Replacements (96-24-6)
  • Generator Harness Connector Damage - Loose Contact (96-21-4)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Wire Harness Terminal & Connector Service Kit (89-19-5)
  • New Micro-Pin Terminal Connectors Locking/Unlocking (87-7-7)
  • Wiring System Diagnosis Cautions (87-4-8)
  • New Waterproof Butt Splice Wire Connector (86-3-11)
  • Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
  • Wiring Diagram Symbols Explanation (85-11-5)
  • 1.6/1.9/2.0/2.3L Non Ac Eng No Rad Fan - Cir Breaker (86-5-2)
• Gauges & Instrument Panels
  • Fuel Tank Sending Unit Wiring Damaged - New Wiring (89-14-6)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
  • Low Coolant Warning System Kit (88-1-12)
  • Revised Electronic Clock Diagnostic Process (86-13-9)
  • A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • Speedometer Gear Applications (85-21-4)
  • Damaged Fuel Tank Sending Unit Connector Repair (89-7T-14)
  • Erratic Fuel Gauge Prevention Info (86-16-3)
  • New In Car Fuel Sender Test Procedure (86-15-5)
  • Wiring Schematic Correction For Digital Clock (86-4-4)
• Hazardous Waste Material
  • Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Asbestos Brake & Clutch Warnings (83-22-1)
• Headlights
  • False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
  • Moisture Inside Headlight Lens - Diagnosis/Repair (87-13-4)
  • Towing - New Fog Lamp Bracket (86-11-2)
  • Headlamps Flash With FOGLIGHT On - New Wiring/Switch (89-9T-14)
• Heated Glass/Defoggers
  • New Rear Defogger Service Kit (93-26-1)
• HVAC Control Systems
  • Identification Of Non-Ford Approved Refrigerants (99-19-6)
  • Use Of R-12 Refrigerant Substitutes (96-17-10)
  • Ford Approved Flushing Procedures For A/C System (95-8-1)
  • A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
  • R-12 Refrigerant Substitutes - Service Tip (94-14-3)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
  • A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
  • New Refrigerant Fitting "O" Rings (91-22-5)
  • A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
  • Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
  • A/C "O" Ring Usage Table (90-14-8)
  • Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
  • Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
  • A/C Drier - Replace When Major Component Serviced (88-25-5)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • Diagnostic Tips For Heater Core Leaks (85-5-2)
  • 1.9/2.0/2.3L Eng Poor Performance A/C Diagnostic (86-20-2)
  • 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
  • A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
• Identification
  • Corporate Standard Circuit Nos. & Wire Color Codes (87-15-3)
  • 1.9/3.0/3.8L Engine Serial Number Location (87-1-9)
• Ignition Switch/Steering Lock
  • Instrument Cluster Warning Lights Dimly Lit (93-24-10)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Latches - Door - Replacement Required (91-8-4)
• Ignition System
  • 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
  • Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
  • Distributor Gear Matched To Distributor At Assembly (89-6-11)
  • 1.9L CARBURETED Eng Misfire - New Distributor Spring (89-1-11)
  • TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
  • 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
  • TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
  • New Distributor Drive Gear Removal Tool (87-2-18)
  • 1.6/1.9L Eng Spark Plug Applications (86-23-8)
  • 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
  • ECM Spout Line Connector Locations (86-4-17)
  • 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
  • TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
  • DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
  • 1.6L Eng Hot Soak Stall When Braking - H.I.C. Valve (85-5-18)
  • 1.6L Eng Distributor Stator Removal (83-18-12)
  • 1.6/1.9/2.0L Eng Hot Engine Stalls - New Vacuum Tree (86-25-12)
  • 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
  • 1.9L Carb Eng Miss - New Distributor CRNTRIFUGAL Adv (89-1T-18)
  • 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
  • 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
  • Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
  • Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
  • High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
  • Low Spark/Poor Performance - Spout Connector Sleeve (86-20-7)
  • Low Spark/Poor Performance - Spout Connector Sleeve (86-17-10)
• Interior/Exterior Trim
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
  • Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
  • Interior Trim: Recommended Clean-Up Tips (87-2-3)
  • Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
  • Sealer Drips Onto Interior/Trunk: Cleaning Products (86-21-3)
  • Adhesive-Backed Name Plate/Emblem Loose: Replacement (86-20-1)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
• Interior/Illumination Lights
  • False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
  • Moisture Inside Headlight Lens - Diagnosis/Repair (87-13-4)
  • Towing - New Fog Lamp Bracket (86-11-2)
  • Headlamps Flash With FOGLIGHT On - New Wiring/Switch (89-9T-14)
• Lubrication System
  • 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Oil Consumption Information (89-9-10)
  • 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
  • 1.6/1.9/2.3/2.5/3.0L Engine Oil Applications (86-23-7)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
  • 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
  • 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
  • High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
  • Normal Oil Consumption Information (89-5T-13)
• Manual Steering
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
• Manual Trans
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • MTX Trans Jumps Out Of 2ND/4TH Gears (85-24-9)
  • Speedometer Gear Applications (85-21-4)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • MTX/MTXII/MTXIII Trans Pops Out Of 2ND/4TH - List (86-4-13)
• Mechanical
  • 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
  • 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
  • Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Oil Consumption Information (89-9-10)
  • Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
  • 1.9L Eng Revised Cylinder Bore Diameter Specs (87-12-10)
  • 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
  • 1.9/3.0/3.8L Engine Serial Number Location (87-1-9)
  • 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
  • 1.6L Eng Hot Soak Stall When Braking - H.I.C. Valve (85-5-18)
  • 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
  • 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
  • 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
  • 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
  • Aluminum Oil Pan Drain Plug HELI-Coil Repair Info (86-24-15)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • Fuel Pressure Tool (86-11-21)
  • Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
  • High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
  • Normal Oil Consumption Information (89-5T-13)
• Mechanical - Hydraulic
  • Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
  • Brakes - Roughness Concern During Brake Application (95-6-2)
  • On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
  • Occasional Or Intermittent Brake Squeal - Normal (90-22-6)
  • Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
  • Engine Oil Health Warning: Skin Contact (86-15-7)
  • Riveted Rear Brake Shoe Squeal - New Bonded Shoe (86-12-5)
  • Asbestos Brake & Clutch Warnings (83-22-1)
  • 1.9L Carb Eng No Power Assist Cold Temp - Vac Tree (86-16-9)
  • Clicking Noise At Front Disc Area During Application (88-20-6)
  • Occasional\Intermittent Brake Squeal - Normal (86-6-9)
• Mirrors
  • Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Loose Outside Mirror - New Nut And Washers (86-22-5)
• Overdrive Unit
  • ATX Revised In-Chassis Differential R & R (86-1-6)
• Paint & Coatings
  • Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
  • Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
  • Exterior Paint Comprehensive Repair Procedures (91-18-1)
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Difficulty Matching Production Paint Colors (87-15-1)
  • High Mount BRAKELAMP Moisture: Resealing Procedure (87-24-1)
  • DECKLID Mounted Spoiler: Repainting Procedures (87-22-2)
  • Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
  • Sealer Drips Onto Interior/Trunk: Cleaning Products (86-21-3)
  • Adhesive-Backed Name Plate/Emblem Loose: Replacement (86-20-1)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Surface Rust On Chassis Cosmetics Repair Info (85-23-5)
  • Water Leak At Cow/Dash - Body Sealing Tips (86-25-3)
• Passive Restraints
  • Latches - Door - Replacement Required (91-8-4)
  • Safety Belt Tongue Cover Parts Availability (88-25-2)
  • Safety Belt - Replacement Procedure After Accident (88-15-3)
• Rear Suspension
  • Suspension Stabilizer Bar Noise - New Bushings (88-4-10)
  • SUSP Grunt - P/S Tie Rod Joint/Stabilizer Bar Mount (87-7-8)
  • Suspension Spring Identification/Applications (86-6B-1)
  • Front Alignment Revised Specifications (86-2-11)
• Schedule
  • 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
• Seats
  • Safety Belt Tongue Cover Parts Availability (88-25-2)
  • Safety Belt - Replacement Procedure After Accident (88-15-3)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
• Sleeper
  • Latches - Door - Replacement Required (91-8-4)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
• Solar Ventilation
  • A/C Drier - Replace When Major Component Serviced (88-25-5)
• Starter
  • New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Low Charge - New Alternator Regulator Connector (87-16-5)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
  • Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
  • High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
• Steering Column
  • Steering Wheel With Foam Insert Removal Information (85-24-4)
• Steering Control Systems
  • Electronic Modules - Damage From Static Electricity (88-13-3)
• Steering Gear
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
  • Steering Gear Mounting Hardware (87-4-11)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Steering Linkage
  • Inner Tie Rod In Vehicle Replacement Procedure (91-2-5)
  • New Power Steering Inner Tie Rod R & R (90-14-6)
  • 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
  • Steering Gear Mounting Hardware (87-4-11)
  • Aluminum Rivet Pin REPL For Steering Gear Tie Rod (86-8-10)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
• Sun Roof/T-Top/Convertible Top
  • Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
  • Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
  • High Mount BRAKELAMP Moisture: Resealing Procedure (87-24-1)
  • Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
  • Adhesive-Backed Name Plate/Emblem Loose: Replacement (86-20-1)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
• Suspension Control Systems
  • Electronic Modules - Damage From Static Electricity (88-13-3)
• System
  • 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
  • 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
  • Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
  • EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
  • New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
  • No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
  • Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
  • TPS Service Replacement Chart (89-16-4)
  • Throttle Position Sensor Screw Removal (89-14-7)
  • Adhesives & Sealants - Availability & Usage (89-12-2)
  • Distributor Gear Matched To Distributor At Assembly (89-6-11)
  • 1.9L CARBURETED Eng Misfire - New Distributor Spring (89-1-11)
  • EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
  • Electronic Modules - Damage From Static Electricity (88-13-3)
  • TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
  • 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
  • CFI Fuel Injector Contamination - Replace Injector (87-17-5)
  • 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
  • TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
  • Fuel Line Spring Lock Coupling R & R (87-3-8)
  • New Distributor Drive Gear Removal Tool (87-2-18)
  • Wiring System Testing Caution - Modify Probe Tips (87-2-5)
  • Aftermarket Theft Device - EEC Warnings (86-3-9)
  • 1.6/1.9L Eng Spark Plug Applications (86-23-8)
  • 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
  • Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
  • Gas Check - Gasoline Testing Kit (86-13-21)
  • TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
  • Poor Performance - Vacuum System Diagnosis (86-9-11)
  • ECM Spout Line Connector Locations (86-4-17)
  • 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
  • Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
  • Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
  • TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
  • TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
  • DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
  • 1.6L Eng Hot Soak Stall When Braking - H.I.C. Valve (85-5-18)
  • 1.6L Eng Distributor Stator Removal (83-18-12)
  • 1.6/1.9/2.0 L Eng Poor Drivability - PCV Vacuum Tree (86-22-14)
  • 1.6/1.9/2.0L Eng Hot Engine Stalls - New Vacuum Tree (86-25-12)
  • 1.6/1.9L Eng Idle Speed Varies - Throttle Plate Adj (86-7-13)
  • 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
  • 1.9L Carb Eng Miss - New Distributor CRNTRIFUGAL Adv (89-1T-18)
  • 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
  • 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
  • 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
  • 1.9L Eng PCV Valve "Hoot" Noise - Replace Valve/Hose (86-4-18)
  • 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
  • 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
  • Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
  • EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
  • Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
  • Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
  • High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
  • Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
  • Low Spark/Poor Performance - Spout Connector Sleeve (86-20-7)
  • Low Spark/Poor Performance - Spout Connector Sleeve (86-17-10)
  • Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
  • Wire Terminal Testing - Test Equipment Modification (86-22-11)
• Towing
  • Towing - New Fog Lamp Bracket (86-11-2)
• Transfer Case
  • Adhesives & Sealants - Availability & Usage (89-12-2)
• Transmission Control Systems
  • No Crank - Low State Of Battery Charge (91-10-8)
• Wheels & Tire System
  • Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
  • Tire Company Phone Numbers For Customer Assistance (98-5-2)
  • Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
  • Wheel Weights/Aluminum Rims (90-13-2)
  • Aluminum Rims Leak Air - Inspection/Hot Melt Sealant (89-17-3)
  • Aluminum Wheels W/Coating Service Wear Information (86-9-9)
  • Alum Wheel Leaks Air - Hot Melt Wheel Repair Info (89-9T-6)
  • Aluminum Wheel Air Leak - Use Hot Melt-Stick On Leak (89-9T-6)
  • Steering Drift To The Left - Check Tires/Alignment (85-23-6)
• Window Motors & Regulators
  • Windshield And Interior Glass - Fog/Film (96-22-1)
  • "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
  • Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
  • Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
  • Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
  • Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
  • High Mount BRAKELAMP Moisture: Resealing Procedure (87-24-1)
  • Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
  • Adhesive-Backed Name Plate/Emblem Loose: Replacement (86-20-1)
• Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
  • Electrical Diode Identification And Replacements (96-24-6)
  • Generator Harness Connector Damage - Loose Contact (96-21-4)
  • No Crank - Low State Of Battery Charge (91-10-8)
  • Wire Harness Terminal & Connector Service Kit (89-19-5)
  • Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
  • New Micro-Pin Terminal Connectors Locking/Unlocking (87-7-7)
  • Wiring System Diagnosis Cautions (87-4-8)
  • New Waterproof Butt Splice Wire Connector (86-3-11)
  • Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
  • Wiring Diagram Symbols Explanation (85-11-5)