Section 5 (General -- Lancer Evolution)
WARNING: This page is about a different variant/trim than selected.
- How To Use This Manual
- Troubleshooting Guidelines
- How To Use Troubleshooting/Inspection Service Points
- Vehicle Identification
- Precautions Before Service
- Cautions For Working In Engine Compartment
- Supplemental Restraint System (SRS)
- How To Perform Vehicle Identification Number (VIN) Writing
- Initialization Procedure For Learning Value In MFI Engine
- Engine Idling Learning Procedure
- Timing Chain Maintenance
- Servicing Electrical System
- Vehicle Washing
- Application Of Anti-Corrosion Agents And Undercoats
- Scan Tool (Multi Use Tester { M.U.T.-III } Sub Assembly)
- Coding List
- Bolts And Nuts With Stabilizer For Coefficient Of Friction
- Towing And Hoisting
- General Data And Specifications
- Tightening Torque
- Lubrication And Maintenance
- Recommended Lubricants And Lubricant Capacities Table
- Scheduled Maintenance Table
- Maintenance Service
- 1. Fuel System (Tank, Pipe Line And Connection, And Fuel Tank Filler Tube Cap) (Check For Leaks)
- 2. Fuel Hoses (Check Condition)
- 3. Air Cleaner Element (Replace)
- 4. Evaporative Emission Control System (Except Evaporative Emission Canister) (Check For Leaks And Clogging)
- 5. Spark Plugs (Replace)
- 6. Intake And Exhaust Valve Clearance (Inspect And Adjust)
- 7. Drive Belt (For The Generator And Power Steering Oil Pump) (Replace)
- 8. Exhaust System (Connections Portion Of Muffler, Muffler Pipes And Converter Heat Shields) (Check And Service)
- 9. Engine Oil (Change)
- 10. Engine Oil Filter (Replace)
- 11. Manual Transaxle Oil (Check Oil Level And Condition/RCHANGE)
- 12. Twin Clutch SPORTRONIC Shift Transmission [Check Oil Leaks (If Necessary, Check The Oil Level) /Change]
- 13. Transfer Oil (Check Oil Level/Change)
- 14. Reserve Tank Fluid (For Active Center Differential And Active Yaw Control System) (Check Fluid Level)
- 15. Engine Coolant (Change)
- 16. Coolant Hoses (Radiator Hose, Heater Hose) (Inspect)
- 17. Disk Brake Pads And Rotors (Inspect For Wear)
- 18. Brake Hoses (Check For Deterioration Or Leaks)
- 19. Ball Joint And Steering Linkage Seals (Inspect For Grease Leaks And Damage)
- 20. Drive Shaft Boots (Inspect For Grease Leaks And Damage)
- 21. Suspension System (Inspect For Looseness And Damage)
- 22. Rear Axle Oil (For Differential Part) (Change)
- 23. Rear Axle Oil (For Torque Transfer Mechanism Part) (Change)
- 24. Tires (Rotate)
- 25. Air Purifier Filter (Replace)
- Main Sealant And Adhesive Table