Technical Service Bulletins

• A/C Compressor
  • A/C End Cover/Valve Plate Leak - Revised Rebuild Kit (24-01-89)
• Anti-Theft Systems
  • Test Procedure For Front Seat Belt Lock Function (23-10-87)
  • Water Leaks Through/Around Door - Weatherstrip (23-02-87)
• Automatic Trans
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • A/T Failure - ATF Cooler Flushing Procedure (21-10-89)
  • A413/A470 Harsh/Abrupt Engagement Inti Drive (21-04-88)
  • A/T Delayed D Or R Engagement - Separator Plate (21-03-88)
  • AURO Trans High Pullout Effort From Park (21-14-87)
  • A/T DECEL Whine At 45-35 Mph - New Gearshift Cable (21-02-87)
• Auxiliary Emission Control Systems
  • Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
  • 2.2L Eng Sag On Acceleration - Reroute VCOTVV (18-09-89)
  • 2.2/2.5/2.6/3.0L Eng EGR Valve Diagnostic (25-01-89)
  • Erratic Low Idle ANR/Or No Fast Idle With Code 25 (18-18-88)
  • 2.2L Carb Eng A413 Trans Warm Surge/Bucking (18-15-87)
  • 2.2L M/T Warm Surge/Buck - Revised ESA Module (18-12-87)
  • 2.2L Carb Cold ACCEL Sag - Purge Vacuum Line Filter (18-50-86)
  • 2.2L Carb A/T Off Idle Hesitate - ACCEL Pump Nozzle (18-30-86)
• Axle Shafts
  • 2.2L Eng A413 Trans Right DRIVESHFT Substitution (02-06-87)
• Charging Systems
  • 2.2L Short Trips Discharge Battery - After-Run Fan (08-13-86)
• Clutch
  • Clutch Growl At Medium/High Speed - Release Lever (06-02-89 REV. A)
  • Manual Trans Chatter In Rev - Short/MISROUTED Cable (06-01-87)
  • Reverse Clash/Clutch Won't Release - Pressure Plate (06-01-86 REV. A)
• Cooling System (Mechanical)
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
• Differentials & Drive Axles
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • 2.2L Eng A413 Trans Right DRIVESHFT Substitution (02-06-87)
• Driveshaft & Universal Joints
  • 2.2L Eng A413 Trans Right DRIVESHFT Substitution (02-06-87)
• Engine Control Systems
  • Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
  • Erratic Low Idle ANR/Or No Fast Idle With Code 25 (18-18-88)
  • 2.2L Carb Eng A413 Trans Warm Surge/Bucking (18-15-87)
  • 2.2L M/T Warm Surge/Buck - Revised ESA Module (18-12-87)
  • 2.2L Carb A/T Off Idle Hesitate - ACCEL Pump Nozzle (18-30-86)
• Exhaust
  • 2.2/2.5L Eng Exhaust Chirp/Clunk Noise Or Leak (11-01-88)
• Front Suspension
  • Front Shock Towers Sheet Metal Screws Installation (02-08-92)
• Fuel System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • 2.2L Carb Cold ACCEL Sag - Purge Vacuum Line Filter (18-50-86)
  • 2.2L Eng (Carb) - Vapor Lock/Fuel Foaming - Fuel Kit (18-24-86 SUPP. A)
• Ignition System
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
• Interior/Exterior Trim
  • Water Leaks Through/Around Door - Weatherstrip (23-02-87)
• Lubrication System
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
  • 2.2/2.5L Eng Oil Pan Buzz - Relief Valve Plunger (09-04-89)
  • New "SG" Quality Engine Oil (10-51-89)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
• Manual Trans
  • Clutch Splines/Pilot Bushing Lubricant Info (06-01-89)
  • A520/A525/A555 Trans No 2ND/3RD Gear Engagement (21-01-88)
  • A520/A525/A555 Trans Spongy 1-2/2-1 Shift (21-02-88)
• Mechanical
  • New "SG" Quality Engine Oil (10-51-89)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • 2.2/2.5L Timing Belt Skips/No Cold Start - Sealing (09-07-86)
• Mechanical - Hydraulic
  • Coolant Recycling: Information On Recycled Coolant (07-03-90)
• Mirrors
  • Water Leaks Through/Around Door - Weatherstrip (23-02-87)
• Paint & Coatings
  • Off Color Paint - Color Variance Chart Program (23-02-91)
• Rear Suspension
  • Front Shock Towers Sheet Metal Screws Installation (02-08-92)
• Seats
  • Test Procedure For Front Seat Belt Lock Function (23-10-87)
• Starter
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • 2.2L Short Trips Discharge Battery - After-Run Fan (08-13-86)
• System
  • Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
  • Flooded Engine - Check And Replace Oil And Filter (18-11-90)
  • 2.2L Eng Sag On Acceleration - Reroute VCOTVV (18-09-89)
  • 2.2/2.5/2.6/3.0L Eng EGR Valve Diagnostic (25-01-89)
  • Erratic Low Idle ANR/Or No Fast Idle With Code 25 (18-18-88)
  • All Fuel Injected Eng AIS Screw Hard To Remove (14-07-88)
  • No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
  • 2.2L Carb Eng A413 Trans Warm Surge/Bucking (18-15-87)
  • 2.2L M/T Warm Surge/Buck - Revised ESA Module (18-12-87)
  • 2.2L Carb Cold ACCEL Sag - Purge Vacuum Line Filter (18-50-86)
  • 2.2L Eng (Carb) - Vapor Lock/Fuel Foaming - Fuel Kit (18-24-86 SUPP. A)
  • 2.2L Carb A/T Off Idle Hesitate - ACCEL Pump Nozzle (18-30-86)
• Wheels & Tire System
  • Tire Thump/Vibration - Flat-Spotting Diagnosis (22-52-89)
  • Vibration/Shake At 45-65 Mph - Tire RUNOUT/Balance (22-01-87)
  • Tires Rub During Severe Turns/Braking - Normal (22-02-86)
• Window Motors & Regulators
  • Water Leaks Through/Around Door - Weatherstrip (23-02-87)