Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Cruise Control Systems
- Model Identification
- Connector Identification
- Description
- Operation
- Self-Diagnostic System
- Self Diagnostics Tests
- Diagnostic Charts
- Speed Control Will Not Set Or Disengages By Itself
- Speed Control Accelerates Or Taps Up By Itself
- Speed Control Slows Down By Itself
- Speed Control Resumes By Itself
- Speed Control Set By Itself
- Speed Control Will Not Resume - Sets OK
- Speed Control Will Not Accelerate Or Tap - Sets OK
- Speed Control Will Not Slow Down Pressing Coast Button
- Trouble Shooting
- Notes
- No Speed Control When Set Button Is Pressed & Released
- Speed Control Engages Without Actuating Speed Set Button
- Speed Control Engages When Engine Is Started
- Erratic Speed Or Engine Shuts Off
- Excessive Sag On Hills Or In Trailer Towing
- Speed Control Disengages On Rough Road
- Engine Does Not Return To Normal Idle
- No Resume When Resume Button Is Pressed
- Speed Control Does Not Disengage With Brake Pedal Depressed
- Testing
- Removal & Installation
- Wiring Diagrams
- Gauges & Instrument Panels
- Description & Operation
- Testing
- FOGLIGHT Switch Test
- Fuel Level Sensor
- Low Fuel Warning Light Test
- Low Oil Pressure Warning Light Test
- Headlight Switch
- Individual Instrument Cluster Gauge Inoperative Tests
- Multiple Instrument Cluster Gauges Inoperative Test
- Rear Defogger Switch Test
- Speedometer Test
- Tachometer Test
- Vehicle Speed Sensor (VSS)
- Wiper/Washer Switch Test
- Removal & Installation
- Wiring Diagrams
- Heated Glass/Defoggers
- Power Mirrors
- Steering Column Switches
- Wiper/Washer Systems
- Description & Operation
- Adjustments
- Testing
- Notes
- Wiper Blades Do Not Park Properly
- Motor Stops In Any Position When Switch Is Turned Off.
- Motor Will Not Stop When Switch Is Turned Off
- Wiper Blades Slap Against Cowl Screen Or Window Moldings
- Blades Chatter
- Wiper Knock At Reversal
- Wiper Motor Will Not Run
- Wiper Motor Will Not Run In Some Or All Switch Positions
- Motor Runs Slowly At All Speeds
- Wipers Run At High Speed With Switch In Low Speed Position Or Wipers Run At Low Speed With Switch In High Speed Position
- Wipers Operate Continuously With Switch In Intermittent Position - When Wiper Is Turned Off, Wipers Stop Wherever They Are, Without Returning To Park Position.
- Wipers Do Not Run When Washer Motor Is Activated (Pulse Wipe) Or Wipers Do Operate In Intermittent Position
- Wiper Switch
- Washer Motor
- Removal & Installation
- Wiring Diagrams
- Body & Frame
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Connector Identification
- Component Testing
- Removal & Installation
- Adjustments
- Torque Specifications
- Self-Diagnostic Tests
- Visual Inspection
- Test 1A
- Test 2A
- Test 2B
- Test 2C
- Test 2D
- Test 2E
- Test 2F
- Test 3A
- Test 3B
- Test 4A
- Test 4B
- Test 4C
- Test 4D
- Test 5A
- Test 6A
- Test 7A
- Test 7B
- Test 8A
- Test 9A
- Test 9B
- Test 10A
- Test 10B
- Test 11A
- Test 11B
- Test 12A
- Test 12B
- Test 13A
- Test 14A
- Test 15A
- Test 16A
- Test 17A
- Test 18A
- Test 19A
- Test 20A
- Test 21A
- Test 22A
- Test 23A
- Test 24A
- Test 25A
- Test 26A
- Test 27A
- Test 27B
- Test 28A
- Test 28B
- Test 28C
- Test 29A
- Test 30A
- Test 31A
- Test VER-1A
- Test VER-2A
- Wiring Diagram
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Disc & Drum
- Identification
- Description & Operation
- Bleeding Brake System
- Adjustments
- Testing
- Removal & Installation
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Drum Brake Specifications
- Disc & Drum
- Traction Control
- Anti-Lock Brake System
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Connector Identification
- Component Testing
- Removal & Installation
- Adjustments
- Torque Specifications
- Self-Diagnostic Tests
- Visual Inspection
- Test 1A
- Test 2A
- Test 2B
- Test 2C
- Test 2D
- Test 2E
- Test 2F
- Test 3A
- Test 3B
- Test 4A
- Test 4B
- Test 4C
- Test 4D
- Test 5A
- Test 6A
- Test 7A
- Test 7B
- Test 8A
- Test 9A
- Test 9B
- Test 10A
- Test 10B
- Test 11A
- Test 11B
- Test 12A
- Test 12B
- Test 13A
- Test 14A
- Test 15A
- Test 16A
- Test 17A
- Test 18A
- Test 19A
- Test 20A
- Test 21A
- Test 22A
- Test 23A
- Test 24A
- Test 25A
- Test 26A
- Test 27A
- Test 27B
- Test 28A
- Test 28B
- Test 28C
- Test 29A
- Test 30A
- Test 31A
- Test VER-1A
- Test VER-2A
- Wiring Diagram
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Charging Systems
- Alternator & Regulator
- Description
- Operation
- Adjustments
- Trouble Shooting
- Self-Diagnostic System
- Self-Diagnostic Tests
- Notes
- Test TC-1A, Checking System For DTCS
- Test TC-2A, Alternator Field Not Switching Properly
- Test TC-3A, Battery Temp Sensor Volts Out Of Limit
- Test TC-3B, Battery Temp Sensor Volts Out Of Limit
- Test TC-4A, Charging System Voltage Low
- Test TC-5A, Charging System Voltage High
- Test TC-5B, Charging System Voltage High
- Test Ch-1A, Checking Charging System No DTCS
- Test Ch-VER, Charging Verification
- On-Vehicle Testing
- Bench Testing
- Removal & Installation
- Overhaul
- Torque Specifications
- Wiring Diagrams
- Alternator & Regulator
- Component Locations
- Fuses & Circuit Breakers
- Identification
- Fuse Panel Location
- Passenger Compartment Fuse Panel Identification
- Fuse & Circuit Breaker I.D. (Passenger Compartment)
- 1 - 15 Amp (Lt. Blue)
- 2 - 15 Amp (Lt. Blue)
- 3 - 15 Amp (Lt. Blue)
- 4 - 10 Amp (Red)
- 5 - 10 Amp (Red)
- 6 - 10 Amp (Red)
- 7 - 25 Amp (Natural)
- 8 - 10 Amp (Red)
- 9 - 10 Amp (Red)
- 10 - 15 Amp (Lt. Blue)
- 11 - 5 Amp (Tan)
- 12 - 4 Amp (Pink)
- 13 - Not Used
- 14 - Not Used
- 15 - 20 Amp (Yellow)
- 16 - 10 Amp (Red)
- 17 - 10 Amp (Red)
- 18 - 10 Amp (Red)
- 19 - Not Used
- 20 - Not Used
- Relay Identification (Passenger Compartment)
- UNDERHOOD Main Fuse & Relay Panel Identification
- Fuse & Circuit Breaker I.D. (UNDERHOOD)
- Relay Identification (Engine Compartment)
- Cautions & Warnings
- Identification
- Gauges
- Instrument Panel
- Description & Operation
- Testing
- FOGLIGHT Switch Test
- Fuel Level Sensor
- Low Fuel Warning Light Test
- Low Oil Pressure Warning Light Test
- Headlight Switch
- Individual Instrument Cluster Gauge Inoperative Tests
- Multiple Instrument Cluster Gauges Inoperative Test
- Rear Defogger Switch Test
- Speedometer Test
- Tachometer Test
- Vehicle Speed Sensor (VSS)
- Wiper/Washer Switch Test
- Removal & Installation
- Wiring Diagrams
- Instrument Panel
- Starter
- Description
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Overhaul
- Starter Specifications
- Torque Specifications
- Wiring Diagram
- Wiring Diagrams
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Charging Systems
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling Fan
- Cooling System (Mechanical)
- Mechanical
- 2.0L 4-CYL - VIN [C]
- Identification
- Adjustments
- Removal & Installation
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- 2.0L 4-CYL - VIN [C]
- Starter
- Description
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Overhaul
- Starter Specifications
- Torque Specifications
- Wiring Diagram
- Timing Belt Replacement - 2.0L - SOHC (VIN C)
- Engine Performance
- Engine Controls - Adjustments - 2.0L & 2.4L
- Application
- Emissions
- EGR Function Testing - CHRYSLER Cars
- Emission Applications - Domestic Cars
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Remove, Overhaul & Install
- Engine Controls - Remove/Install/Overhaul - 2.0L & 2.4L
- Sensor Range Charts
- Engine Controls - Specifications
- System
- Engine Controls - Basic Testing - 2.0L & 2.4L
- Engine Controls - System/Component Tests - 2.0L & 2.4L
- Introduction
- Air Induction Systems
- Engine Sensors & Switches
- Motors, Relays & Solenoids
- Idle Air Control (IAC) Motor
- Auto Shutdown (ASD) & Fuel Pump Relays
- Multi-Point Fuel Injection (MFI) & Fuel Pump Relays
- Solenoids
- EGR Solenoid (Talon Turbo)
- Electric EGR Transducer Solenoid (Avenger, Sebring & Talon Non-Turbo)
- Evaporative Emission Purge Solenoid (Avenger, Sebring & Talon)
- Fuel Pressure Solenoid (Talon Turbo)
- Pulsed Secondary Air Injection Solenoid (Avenger DOHC, Sebring DOHC & Talon Non-Turbo)
- Turbocharger Wastegate Solenoid
- Fuel System
- Ignition System
- Emission Systems & Sub-Systems
- EGR Diagnostic Chart
- Miscellaneous Controls
- Air Aspirator System
- Engine Controls - Tests W/Codes - 2.0L VINS [C,Y] & 2.4L VIN [X]
- Model Identification
- Introduction
- Self-Diagnostic System
- Inactive Trouble Code Condition
- Fuel Pressure Release
- Connector Identification
- Connector Identification Directory
- A/C Compressor Relay Connector Terminal Id
- Automatic Shutdown (ASD) Relay Connector Terminal Id
- Camshaft Position Sensor Connector Terminal Id
- Crankshaft Position Sensor Connector Terminal Id
- Downstream Oxygen Sensor (O2S) Connector Terminal Id
- Exhaust Gas RECIRCULATION (EGR) Solenoid Connector Terminal
- Engine Coolant Temperature (ECT) Sensor Connector Terminal Id
- Evaporative Solenoid Connector Terminal Id
- Fuel Pump Motor Connector Terminal Id
- Fuel Pump Relay Connector Terminal Id
- High Speed Radiator Fan Relay Connector Terminal Id
- Idle Air Control (IAC) Motor Connector Terminal Id
- Ignition Coil Connector Terminal Id
- Injectors No. 1-4 Connector Terminal Id
- Intake Air Temperature (IAT) Sensor Connector Terminal Id
- Knock Sensor Connector Terminal Id
- Low Speed Radiator Fan Relay Connector Terminal Id
- Manifold Absolute Pressure (Map) Sensor Connector Terminal Id
- Park/Neutral Position Switch Connector Terminal Id
- Power Steering Pressure Switch (PSPS) Connector Terminal Id
- Radiator Fan Relay Connector Terminal Id
- Starter Motor Relay Connector Terminal Id
- Throttle Position Sensor (TPS) Connector Terminal Id
- Torque Converter Clutch (TCC) Solenoid Connector Terminal Id
- Upstream Oxygen Sensor (O2S) Connector Terminal Id
- Vehicle Speed Sensor (VSS) Connector Terminal Id
- 12-Pin Data Link Connector Terminal Id
- 16-Pin Data Link Connector Terminal Id
- Model Id
- Self-Diagnostic Tests
- Diagnostic Trouble Code (TC) Tests
- Checking System For Diagnostic Trouble Codes
- Test TC-1A - No Cam Signal At Pcm
- Test TC-3A - O2S Stays Above Center (Rich)
- Test TC-4A - O2S Stays Below Center (Lean)
- Test TC-10A - Auto Shutdown Relay Control Circuit
- Test TC-12A - Torque Converter Clutch Solenoid CKT
- Test TC-14A - Rad Fan Control Relay Circuit
- Test TC-17A - EGR Solenoid Circuit
- Test TC-18A - EVAP Purge Solenoid Circuit
- Test TC-19A - Injector #3 Control Circuit
- Test TC-20A - Injector #2 Control Circuit
- Test TC-21A - Injector Control Circuit
- Test TC-21B - Injector #1 Control Circuit
- Test TC-25A - Idle Air Control Motor Circuits
- Test TC-25B - Idle Air Control Motor Circuits
- Test TC-25C - Idle Air Control Motor Circuits
- Test TC-25D - Idle Air Control Motor Circuits
- Test TC-25E - Idle Air Control Motor Circuits
- Test TC-26A - Throttle Position Sensor Voltage Low
- Test TC-27A - Throttle Position Sensor Voltage High
- Test TC-30A - ECT Sensor Voltage Too Low
- Test TC-31A - ECT Sensor Voltage Too High
- Test TC-32A - Upstream O2S Stays At Center
- Test TC-35A - No Vehicle Speed Sensor Signal
- Test TC-35B - No Vehicle Speed Sensor Signal
- Test TC-35C - No Vehicle Speed Sensor Signal
- Test TC-36A - Map Sensor Voltage Too Low
- Test TC-37A - Map Sensor Voltage Too High
- Test TC-39A - No Change In Map From Start To Run
- Test TC-40A - No Crank Reference Signal At Pcm
- Test TC-40B - No Crank Reference Signal At Pcm
- Test TC-42A - Ignition Coil #2 Primary Circuit
- Test TC-43A - Ignition Coil #1 Primary Circuit
- Test TC-44A - No ASD Relay Output Voltage At Pcm
- Test TC-46A - EGR Solenoid Circuit
- Test TC-48A - Pcm Failure Sri Mile Not Stored & Pcm Failure EEPROM Write Denied
- Test TC-51A - Air Switching Solenoid Circuit
- Test TC-57A - Intake Air Temp Sensor Voltage Low
- Test TC-58A - Intake Air Temp Sensor Voltage High
- Test TC-59A - Knock Sensor Circuit
- Test TC-61A - Injector #4 Control Circuit
- Test TC-62A - Upstream O2S Shorted To Voltage
- Test TC-71A - Battery Temp Sensor Volts Out Of Limit
- Test TC-71B - Battery Temp Sensor Volts Out Of Limit
- Test TC-71C - Battery Temp Sensor Volts Out Of Limit
- Test TC-92A - Low Speed Fan CTRL Relay Circuit
- Test TC-93A - High Speed Fan CTRL Relay Circuit
- Test TC-96A - No CCD Message From TCM
- Test TC-97A - No CCD Message From BCM
- Test TC-101A - Fuel Pump Relay Control Circuit
- Test TC-102A - Upstream O2S Slow Response
- Test TC-103A - Upstream O2S Heater Failure
- Test TC-104A - Downstream O2S Slow Response
- Test TC-105A - Downstream O2S Heater Failure
- Test TC-106A - Multiple Cylinder Misfire
- Test TC-107A - Cylinder #1, #2, #3, #4 Misfire
- Test TC-111A - Too Little Sec Air Or Too Much Sec Air
- Test TC-112A - Catalytic Converter Efficiency Failure
- Test TC-113A - EVAP Purge Flow Monitor Failure
- Test TC-113B - EVAP Purge Flow Monitor Failure
- Test TC-114A - Park/Neutral Switch Failure
- Test TC-115A - Power Steering Switch Failure
- Test TC-115B - Power Steering Switch Failure
- Test TC-118A - Fuel System Rich
- Test TC-119A - Fuel System Lean
- Test TC-126A - Downstream O2S Shorted To Voltage
- Test TC-128A - Closed Loop Temperature Not Reached
- Test TC-129A - Downstream O2S Stays At Center
- Test TC-132A - TPS Voltage Does Not Agree With Map
- Test TC-133A - Timing Belt Skipped 1 Tooth Or More
- Test TC-134A- No 5 Volts To A/C Pressure Sensor (Ja Body Only)
- Test TC-135A - No 5 Volts To Map Sensor
- Test TC-136A - No 5 Volts To TP Sensor
- Test TC-138A - Target Idle Not Reached
- Test TC-138B - Target Idle Not Reached
- Test TC-145A - Vacuum Leak Found (IAC Fully Seated)
- Test TC-146A - 5-Volt Supply Output Too Low
- Test TC-146B - 5-Volt Supply Output Too Low
- Test TC-148A - TCC - No Rpm Drop At Lockup
- Test TC-149A - Fuel Level Sending Unit Volts Too Low
- Test TC-149B - Fuel Level Sending Unit Volts Too Low
- Test TC-149C - Fuel Level Sending Unit Volts Too Low
- Test TC-150A - Fuel Level Sending Unit Volts Too High
- Test TC-150B - Fuel Level Sending Unit Volts Too High
- Test TC-150C - Fuel Level Sending Unit Volts Too High
- Test TC-151A - Fuel Level Unit No Change Over Miles
- Test TC-151B - Fuel Level Unit No Change Over Miles
- Test TC-151C - Fuel Level Unit No Change Over Miles
- Test TC-152A - Brake Switch Sense Circuit
- Test TC-155A - Upstream O2S Voltage Shorted To Ground
- Test TC-156A - Downstream O2S Voltage Shorted To Ground
- Test TC-157A - Intermittent Loss Of CMP Or CKP
- Test TC-157B - Intermittent Loss Of CMP Or CKP
- Test TC-157C - Intermittent Loss Of CMP Or CKP
- No Trouble Code (NTC) Tests
- Test NTC-1A - No Trouble Code Test Menu
- Test NTC-2A - Checking Secondary Ignition & Timing
- Test NTC-3A - Checking Fuel Pressure
- Test NTC-3B - Checking Fuel Pressure
- Test NTC-3C - Checking Fuel Pressure
- Test NTC-4A - Cts Calibration Check & Radiator Fan Operation
- Test NTC-5A - Checking TPS Calibration
- Test NTC-6A - Checking Map Sensor Calibration
- Test NTC-7A - Checking Oxygen Sensor (O2S) Switching
- Test NTC-7B - Checking Oxygen Sensor Switching
- Test NTC-8A - Checking Oxygen Sensor Heater
- Test NTC-9A - Checking Idle Air Control Motor
- Test NTC-10A - Checking Solenoid Operations
- Test NTC-11A - Checking Park/Neutral Position Switch
- Test NTC-12A - Checking Pcm Ground & Power Circuits
- Test NTC-13A - Checking Evaporative Emission System
- Test NTC-14A - Checking EGR System
- Test NTC-15A - Checking Engine Vacuum
- Test NTC-16A - Checking Intake Air Temperature Sensor
- Test NTC-17A - Checking Timing Belt Alignment
- Test NTC-18A - Checking Minimum Idle Airflow
- Test NTC-19A - Checking Engine Mechanical Systems
- No Start (NS) Tests
- Qualifying No Start Condition
- Test NS-2A - Checking Fuel System
- Test NS-3A - Checking Engine Mechanical System
- Test NS-4A - Repairing Low Fuel Pressure
- Test NS-4B - Repairing High Fuel Pressure
- Test NS-4C - Repairing Low Fuel Pressure
- Test NS-5A - Checking Fuel Pump
- Test NS-6A - Repairing No Response Condition
- Test NS-6B - Repairing No Response Condition
- Test NS-6C - Repairing No Response Condition
- Test NS-6D - Repairing No Response Condition
- Test NS-7A - Checking Idle Air Control Motor
- Test NS-8A - Repairing Start & Stall Condition
- Test NS-9A - Repairing No Crank Condition
- Test NS-9B - Repairing No Crank Condition
- Verification (VER) Tests
- Engine Controls - Tests W/Codes - Body Control Computer
- Introduction
- Description
- Operation
- Self-Diagnostic System
- Diagnostic Procedure
- Vehicle Communications Tests
- Test 1A - Trouble Codes
- Test 2A - Blank Scan Tool Message Screen
- Test 3A - Ram Test Failure
- Test 4A - Cartridge Error
- Test 5A - Key Pad Test Failure
- Test 6A - Low Or High Battery
- Test 7A - Bus Short To Battery
- Test 7B - Bus Short To Battery
- Test 7C - Bus Short To Battery
- Test 7D - Bus Short To Battery
- Test 7F - Bus Short To Battery
- Test 7H - Bus Short To Battery
- Test 8A - Bus Short To 5 Volts
- Test 8B - Bus Short To 5 Volts
- Test 8D - Bus Short To 5 Volts
- Test 8E - Bus Short To 5 Volts
- Test 8F - Bus Short To 5 Volts
- Test 8G - Bus Short To 5 Volts
- Test 8K - Bus Short To 5 Volts
- Test 9A - Bus Short To Ground
- Test 9B - Bus Short To Ground
- Test 9C - Bus Short To Ground
- Test 10A - Bus (+) & Bus (-) Shorted Together
- Test 11A - No Termination
- Test 11M - No Termination
- Test 12A - Bus Bias Level Or Bus (+/-) Open
- Test 12G - Bus Bias Level Or Bus (+/-) Open
- Test 12M - Bus Bias Level Or Bus (+/-) Open
- Test 13A - No Bus Bias
- Test 13K - No Bus Bias
- Test 13N - No Bus Bias
- Test 14A - Not Receiving Bus Messages Correctly
- Test VER-1 - Verification Procedure
- Engine Controls - Tests W/O Codes
- O2 Sensor Location & Identification
- Testing & Diagnosis
- Engine Controls - Basic Testing - 2.0L & 2.4L
- Engine Controls - System/Component Tests - 2.0L & 2.4L
- Introduction
- Air Induction Systems
- Engine Sensors & Switches
- Motors, Relays & Solenoids
- Idle Air Control (IAC) Motor
- Auto Shutdown (ASD) & Fuel Pump Relays
- Multi-Point Fuel Injection (MFI) & Fuel Pump Relays
- Solenoids
- EGR Solenoid (Talon Turbo)
- Electric EGR Transducer Solenoid (Avenger, Sebring & Talon Non-Turbo)
- Evaporative Emission Purge Solenoid (Avenger, Sebring & Talon)
- Fuel Pressure Solenoid (Talon Turbo)
- Pulsed Secondary Air Injection Solenoid (Avenger DOHC, Sebring DOHC & Talon Non-Turbo)
- Turbocharger Wastegate Solenoid
- Fuel System
- Ignition System
- Emission Systems & Sub-Systems
- EGR Diagnostic Chart
- Miscellaneous Controls
- Air Aspirator System
- Engine Controls - Tests W/Codes - 2.0L VINS [C,Y] & 2.4L VIN [X]
- Model Identification
- Introduction
- Self-Diagnostic System
- Inactive Trouble Code Condition
- Fuel Pressure Release
- Connector Identification
- Connector Identification Directory
- A/C Compressor Relay Connector Terminal Id
- Automatic Shutdown (ASD) Relay Connector Terminal Id
- Camshaft Position Sensor Connector Terminal Id
- Crankshaft Position Sensor Connector Terminal Id
- Downstream Oxygen Sensor (O2S) Connector Terminal Id
- Exhaust Gas RECIRCULATION (EGR) Solenoid Connector Terminal
- Engine Coolant Temperature (ECT) Sensor Connector Terminal Id
- Evaporative Solenoid Connector Terminal Id
- Fuel Pump Motor Connector Terminal Id
- Fuel Pump Relay Connector Terminal Id
- High Speed Radiator Fan Relay Connector Terminal Id
- Idle Air Control (IAC) Motor Connector Terminal Id
- Ignition Coil Connector Terminal Id
- Injectors No. 1-4 Connector Terminal Id
- Intake Air Temperature (IAT) Sensor Connector Terminal Id
- Knock Sensor Connector Terminal Id
- Low Speed Radiator Fan Relay Connector Terminal Id
- Manifold Absolute Pressure (Map) Sensor Connector Terminal Id
- Park/Neutral Position Switch Connector Terminal Id
- Power Steering Pressure Switch (PSPS) Connector Terminal Id
- Radiator Fan Relay Connector Terminal Id
- Starter Motor Relay Connector Terminal Id
- Throttle Position Sensor (TPS) Connector Terminal Id
- Torque Converter Clutch (TCC) Solenoid Connector Terminal Id
- Upstream Oxygen Sensor (O2S) Connector Terminal Id
- Vehicle Speed Sensor (VSS) Connector Terminal Id
- 12-Pin Data Link Connector Terminal Id
- 16-Pin Data Link Connector Terminal Id
- Model Id
- Self-Diagnostic Tests
- Diagnostic Trouble Code (TC) Tests
- Checking System For Diagnostic Trouble Codes
- Test TC-1A - No Cam Signal At Pcm
- Test TC-3A - O2S Stays Above Center (Rich)
- Test TC-4A - O2S Stays Below Center (Lean)
- Test TC-10A - Auto Shutdown Relay Control Circuit
- Test TC-12A - Torque Converter Clutch Solenoid CKT
- Test TC-14A - Rad Fan Control Relay Circuit
- Test TC-17A - EGR Solenoid Circuit
- Test TC-18A - EVAP Purge Solenoid Circuit
- Test TC-19A - Injector #3 Control Circuit
- Test TC-20A - Injector #2 Control Circuit
- Test TC-21A - Injector Control Circuit
- Test TC-21B - Injector #1 Control Circuit
- Test TC-25A - Idle Air Control Motor Circuits
- Test TC-25B - Idle Air Control Motor Circuits
- Test TC-25C - Idle Air Control Motor Circuits
- Test TC-25D - Idle Air Control Motor Circuits
- Test TC-25E - Idle Air Control Motor Circuits
- Test TC-26A - Throttle Position Sensor Voltage Low
- Test TC-27A - Throttle Position Sensor Voltage High
- Test TC-30A - ECT Sensor Voltage Too Low
- Test TC-31A - ECT Sensor Voltage Too High
- Test TC-32A - Upstream O2S Stays At Center
- Test TC-35A - No Vehicle Speed Sensor Signal
- Test TC-35B - No Vehicle Speed Sensor Signal
- Test TC-35C - No Vehicle Speed Sensor Signal
- Test TC-36A - Map Sensor Voltage Too Low
- Test TC-37A - Map Sensor Voltage Too High
- Test TC-39A - No Change In Map From Start To Run
- Test TC-40A - No Crank Reference Signal At Pcm
- Test TC-40B - No Crank Reference Signal At Pcm
- Test TC-42A - Ignition Coil #2 Primary Circuit
- Test TC-43A - Ignition Coil #1 Primary Circuit
- Test TC-44A - No ASD Relay Output Voltage At Pcm
- Test TC-46A - EGR Solenoid Circuit
- Test TC-48A - Pcm Failure Sri Mile Not Stored & Pcm Failure EEPROM Write Denied
- Test TC-51A - Air Switching Solenoid Circuit
- Test TC-57A - Intake Air Temp Sensor Voltage Low
- Test TC-58A - Intake Air Temp Sensor Voltage High
- Test TC-59A - Knock Sensor Circuit
- Test TC-61A - Injector #4 Control Circuit
- Test TC-62A - Upstream O2S Shorted To Voltage
- Test TC-71A - Battery Temp Sensor Volts Out Of Limit
- Test TC-71B - Battery Temp Sensor Volts Out Of Limit
- Test TC-71C - Battery Temp Sensor Volts Out Of Limit
- Test TC-92A - Low Speed Fan CTRL Relay Circuit
- Test TC-93A - High Speed Fan CTRL Relay Circuit
- Test TC-96A - No CCD Message From TCM
- Test TC-97A - No CCD Message From BCM
- Test TC-101A - Fuel Pump Relay Control Circuit
- Test TC-102A - Upstream O2S Slow Response
- Test TC-103A - Upstream O2S Heater Failure
- Test TC-104A - Downstream O2S Slow Response
- Test TC-105A - Downstream O2S Heater Failure
- Test TC-106A - Multiple Cylinder Misfire
- Test TC-107A - Cylinder #1, #2, #3, #4 Misfire
- Test TC-111A - Too Little Sec Air Or Too Much Sec Air
- Test TC-112A - Catalytic Converter Efficiency Failure
- Test TC-113A - EVAP Purge Flow Monitor Failure
- Test TC-113B - EVAP Purge Flow Monitor Failure
- Test TC-114A - Park/Neutral Switch Failure
- Test TC-115A - Power Steering Switch Failure
- Test TC-115B - Power Steering Switch Failure
- Test TC-118A - Fuel System Rich
- Test TC-119A - Fuel System Lean
- Test TC-126A - Downstream O2S Shorted To Voltage
- Test TC-128A - Closed Loop Temperature Not Reached
- Test TC-129A - Downstream O2S Stays At Center
- Test TC-132A - TPS Voltage Does Not Agree With Map
- Test TC-133A - Timing Belt Skipped 1 Tooth Or More
- Test TC-134A- No 5 Volts To A/C Pressure Sensor (Ja Body Only)
- Test TC-135A - No 5 Volts To Map Sensor
- Test TC-136A - No 5 Volts To TP Sensor
- Test TC-138A - Target Idle Not Reached
- Test TC-138B - Target Idle Not Reached
- Test TC-145A - Vacuum Leak Found (IAC Fully Seated)
- Test TC-146A - 5-Volt Supply Output Too Low
- Test TC-146B - 5-Volt Supply Output Too Low
- Test TC-148A - TCC - No Rpm Drop At Lockup
- Test TC-149A - Fuel Level Sending Unit Volts Too Low
- Test TC-149B - Fuel Level Sending Unit Volts Too Low
- Test TC-149C - Fuel Level Sending Unit Volts Too Low
- Test TC-150A - Fuel Level Sending Unit Volts Too High
- Test TC-150B - Fuel Level Sending Unit Volts Too High
- Test TC-150C - Fuel Level Sending Unit Volts Too High
- Test TC-151A - Fuel Level Unit No Change Over Miles
- Test TC-151B - Fuel Level Unit No Change Over Miles
- Test TC-151C - Fuel Level Unit No Change Over Miles
- Test TC-152A - Brake Switch Sense Circuit
- Test TC-155A - Upstream O2S Voltage Shorted To Ground
- Test TC-156A - Downstream O2S Voltage Shorted To Ground
- Test TC-157A - Intermittent Loss Of CMP Or CKP
- Test TC-157B - Intermittent Loss Of CMP Or CKP
- Test TC-157C - Intermittent Loss Of CMP Or CKP
- No Trouble Code (NTC) Tests
- Test NTC-1A - No Trouble Code Test Menu
- Test NTC-2A - Checking Secondary Ignition & Timing
- Test NTC-3A - Checking Fuel Pressure
- Test NTC-3B - Checking Fuel Pressure
- Test NTC-3C - Checking Fuel Pressure
- Test NTC-4A - Cts Calibration Check & Radiator Fan Operation
- Test NTC-5A - Checking TPS Calibration
- Test NTC-6A - Checking Map Sensor Calibration
- Test NTC-7A - Checking Oxygen Sensor (O2S) Switching
- Test NTC-7B - Checking Oxygen Sensor Switching
- Test NTC-8A - Checking Oxygen Sensor Heater
- Test NTC-9A - Checking Idle Air Control Motor
- Test NTC-10A - Checking Solenoid Operations
- Test NTC-11A - Checking Park/Neutral Position Switch
- Test NTC-12A - Checking Pcm Ground & Power Circuits
- Test NTC-13A - Checking Evaporative Emission System
- Test NTC-14A - Checking EGR System
- Test NTC-15A - Checking Engine Vacuum
- Test NTC-16A - Checking Intake Air Temperature Sensor
- Test NTC-17A - Checking Timing Belt Alignment
- Test NTC-18A - Checking Minimum Idle Airflow
- Test NTC-19A - Checking Engine Mechanical Systems
- No Start (NS) Tests
- Qualifying No Start Condition
- Test NS-2A - Checking Fuel System
- Test NS-3A - Checking Engine Mechanical System
- Test NS-4A - Repairing Low Fuel Pressure
- Test NS-4B - Repairing High Fuel Pressure
- Test NS-4C - Repairing Low Fuel Pressure
- Test NS-5A - Checking Fuel Pump
- Test NS-6A - Repairing No Response Condition
- Test NS-6B - Repairing No Response Condition
- Test NS-6C - Repairing No Response Condition
- Test NS-6D - Repairing No Response Condition
- Test NS-7A - Checking Idle Air Control Motor
- Test NS-8A - Repairing Start & Stall Condition
- Test NS-9A - Repairing No Crank Condition
- Test NS-9B - Repairing No Crank Condition
- Verification (VER) Tests
- Engine Controls - Tests W/Codes - Body Control Computer
- Introduction
- Description
- Operation
- Self-Diagnostic System
- Diagnostic Procedure
- Vehicle Communications Tests
- Test 1A - Trouble Codes
- Test 2A - Blank Scan Tool Message Screen
- Test 3A - Ram Test Failure
- Test 4A - Cartridge Error
- Test 5A - Key Pad Test Failure
- Test 6A - Low Or High Battery
- Test 7A - Bus Short To Battery
- Test 7B - Bus Short To Battery
- Test 7C - Bus Short To Battery
- Test 7D - Bus Short To Battery
- Test 7F - Bus Short To Battery
- Test 7H - Bus Short To Battery
- Test 8A - Bus Short To 5 Volts
- Test 8B - Bus Short To 5 Volts
- Test 8D - Bus Short To 5 Volts
- Test 8E - Bus Short To 5 Volts
- Test 8F - Bus Short To 5 Volts
- Test 8G - Bus Short To 5 Volts
- Test 8K - Bus Short To 5 Volts
- Test 9A - Bus Short To Ground
- Test 9B - Bus Short To Ground
- Test 9C - Bus Short To Ground
- Test 10A - Bus (+) & Bus (-) Shorted Together
- Test 11A - No Termination
- Test 11M - No Termination
- Test 12A - Bus Bias Level Or Bus (+/-) Open
- Test 12G - Bus Bias Level Or Bus (+/-) Open
- Test 12M - Bus Bias Level Or Bus (+/-) Open
- Test 13A - No Bus Bias
- Test 13K - No Bus Bias
- Test 13N - No Bus Bias
- Test 14A - Not Receiving Bus Messages Correctly
- Test VER-1 - Verification Procedure
- Engine Controls - Tests W/O Codes
- O2 Sensor Location & Identification
- Theory and Operation
- Engine Controls - Theory & Operation - 2.0L & 2.4L
- Introduction
- Computerized Engine Controls
- Control Unit
- Input Devices
- Notes
- A/C Control Module (ACCM)
- Brake Switch
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Hall Effect Switch
- Knock Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Optical Distributor
- Oxygen Sensor (O2S)
- Park/Neutral (P/N) Switch
- Throttle Body Temperature Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Output Signals
- Notes
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay
- Electric Exhaust Gas Recirculation Transducer (EET)
- EVAP Purge Solenoid
- Exhaust Gas Recirculation (EGR) Solenoid
- Fuel Injector(s)
- Idle Speed Control (ISC) Motor
- In-Tank Fuel Pump
- Malfunction Indicator Light
- Radiator Fan Relay
- Speed Control Servo
- Torque Converter Clutch (TCC) Solenoid
- Fuel System
- Ignition Systems
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation - 2.0L & 2.4L
- Vacuum Diagrams - 2.0L & 2.4L
- Wiring Diagrams - 2.0L & 2.4L
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Air Bag Restraints & SRS Components - Inspection & Replacement Tables
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- A/C Compressor Refrigerant Oil Checking
- A/C Compressor Servicing
- A/C System General Servicing
- A/C System Specifications
- Cabin Air Filter (Special Applications) - General Information
- HVAC Control Systems
- A/C-Heater System - Manual
- Description
- Operation
- Trouble Shooting
- Compressor Does Not Run
- Cool Air Only At High Engine Speed
- Cooling Blower Does Not Operate
- Insufficient Cooling
- No Cooling
- A/C-Heater System Fuses
- Vacuum Control One-Way Check Valve
- Vacuum Controls
- Blower Motor System Diagnosis
- GENERAL A/C COMPRESSOR & CLUTCH DIAGNOSIS (1 of 2)
- GENERAL A/C COMPRESSOR & CLUTCH DIAGNOSIS (2 of 2)
- A/C Diagnosis - Fixed Displacement Compressors (Tr105 & 10PA17)
- Testing
- Removal & Installation
- Wiring Diagram
- Heater System
- HVAC Systems - Basic Trouble Shooting - Manual
- Vacuum Control System Diagnosis
- Actuator Calibration/Diagnostics & Cooldown Test - Fwd Vans
- Notes
- Actuator Calibration
- Diagnostics
- Cooldown Test
- Calibration/Cooldown Led Display Codes
- Calibration/Diagnostics Test Entry
- Cooldown Test Entry
- Calibration/Diagnostics And Cooldown Abort
- EEPROM Data
- Actuator Calibration & Diagnostics
- Blend/Passenger Actuator Background
- Driver Actuator Background
- Manual A/C (HVAC) - Mode Door Operation
- Mode Actuator Background
- Fail Codes/Level Display
- Temperature And Mode Potentiometer Diagnostics
- Fin Sensor Temperature Diagnostics
- Trouble Shooting
- A/C-Heater System - Manual
- General Servicing
- Maintenance
- Procedures
- Interference Verification Check For OHC Engine
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Camshaft Timing Belt Replacement Information
- Engine Oil & Filter Change Interval Information
- Spark Plug Replacement Interval Information
- Service Point Locations
- Service Labor Times
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Restraint System (SRS) Air Bag System
- Anti-Lock Brake System (Abs)
- Battery Warning
- Replacing Blown Fuses
- Brake Pad Wear Indicator
- Catalytic Converter
- Coolant (Propylene-Glycol Formulations)
- Electrostatic Discharge Sensitive (ESD) Parts
- Engine Oil
- Fuel System Service
- Halogen Bulbs
- Radiator Cap
- Radiator Fan
- Tire Sealants
- Warranty Information
- Notes
- Customer One Care Warranty
- Basic New Car Limited Warranty
- Corrosion Coverage
- Emission System "Defect" & "Performance" Warranties (Except CALIFORNIA)
- Federal Emissions Warranty
- Emission "Performance" Warranty (CALIFORNIA)
- Emission "Defect" Warranty (CALIFORNIA)
- Roadside Assistance
- Towing
- Air Bag Warranty
- Fuses & Circuit Breakers
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Procedures
- Restraints
- Air Bag, SRS
- Air Bag Restraint System
- Description & Operation
- Service Precautions
- Disabling & Activating Air Bag System
- Post-Collision Inspection
- Adjustments
- Disposal Procedures
- Removal & Installation
- Testing - System Operation Check
- Wire Repair
- Diagnosis
- Testing - Diagnostic Charts
- Test 1A- Testing System Function
- Test 2A - Air Bag Codes
- Test 3A - No Ignition Run Only
- Test 4A - Two Front Sensors Open
- Test 5A - Driver-Side Squib Open
- Test 6A - Passenger-Side Squib Open
- Test 7A - Driver-Side Squib Short
- Test 8A - Passenger-Side Squib Short
- Test 9A - No BCM Bus Message
- Test 10A - Front Sensor Short
- Test 11A - One Front Sensor Open
- Test 11B - One Front Sensor Open
- Test 13A - No CCD Comm
- Test 14A - No Response Message
- Test 14B - No Response Message
- Test 15A - ACM Replacement Procedure
- Test 16A - Warning Lamp Circuit Open/Shorted
- Test 21A - Pressure Switch Circuit Open/Short
- Test VER-1 - Verification Test
- Torque Specifications
- Wiring Diagrams
- Post-Collision Air Bag Safety Inspection
- Air Bag Restraint System
- Restraints Control Systems
- Seat Belts
- Air Bag, SRS
- Steering
- Manual Steering
- Power Steering
- Steering Column
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Transmission
- Automatic Trans
- Diagnosis - Torque Converter Clutch
- Identification
- Description & Operation
- Preliminary Inspection
- Self-Diagnostic System
- TCC Diagnostic Tests
- Notes
- TC-12A - TCC Solenoid/Transmission Relay Circuit
- TC-12F - TCC Solenoid/Transmission Relay Circuit
- TC-20A - TCC Solenoid Circuit (Except 3.0L)
- TC-27A - TCC Solenoid Circuit (3.0L)
- TC-37A - TCC Solenoid Circuit
- TC-148A - TCC - No Rpm Drop Lockup
- Test VER-2A (Road Test Verification)
- Test VER-5A (Road Test For OBD-II Trouble Codes)
- Connector Identification
- Wiring Diagrams
- Overhaul - 30TH & 31TH Automatic Transmission
- Application
- Identification
- Description & Operation
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Symptom Diagnosis
- Buzzing Noise
- Delayed Engagement From Neutral To Drive
- Delayed Engagement From Neutral To Reverse
- Delayed Up-Shift
- Drags Or Locks Up
- Fluid Blows Out Filler Tube
- Growling, Grating Or Scraping Noise
- Harsh Engagement From Neutral To Drive Or Reverse
- No Drive Range In Any Position (Reverse Is Okay)
- No Kickdown Or Normal Downshift
- No Low Gear (Moves In 2nd & 3rd Gears Only)
- No Reverse
- Shifts Delayed Or Erratic
- Slips In All Forward Gears
- Slips In Low & Drive But Not In 1st Gear
- Slips In Reverse Only
- Sluggish Acceleration Or Excessive Throttle To Maintain Speed
- Torque Converter Locks Up In 2nd And/Or 3rd Gear
- Transmission Overheats
- Vehicle Moves In Neutral
- Vehicle Moves In 2nd Or 3rd Gear & Abruptly Downshifts To Low
- Vehicle Will Not Move In All Gears
- Will Not Upshift From Low Gear
- 3-2 Kickdown Run-Away
- Testing
- Hydraulic Pressure Adjustments
- Removal & Installation
- Torque Converter
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Bearing Adjustments
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Removal & Installation - A/T
- Servicing - A/T
- Transmission Oil Pan Gasket Id
- Diagnosis - Torque Converter Clutch
- Clutches
- A-413/30TH & A-670/31TH Automatic Transmission - Hydraulic Diagrams
- Automatic Trans
- External Pages