FixVault
Home › Pontiac › 2002 › Aztek AWD › Repair and Diagnosis › External Pages › Different car › Section 1617 (Engine Controls And Fuel - 3.5L - Introduction) › Repair Instructions › Spark Plug Wire Replacement › Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2009 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: Twist the spark plug boot one-half turn in order to release the boot. Pull on the spark plug boot only. Do not pull on the spark plug wire or the wire could be damaged.
  1. Remove the air cleaner outlet duct, if required. Refer to Air Cleaner Outlet Duct Replacement .
    2. Fig 1: View Of Left Side Spark Plug Wires
    GM1608802Courtesy of GENERAL MOTORS CORP.
  2. Disconnect the left side spark plug wires from the spark plugs.
  3. Disconnect the left side spark plug wires from the ignition coil.
  4. If replacing only one plug wire, open the retaining clips and remove the spark plug wire.
  5. Remove the left side spark plug wire clips from the intake manifold bracket and heater inlet and outlet pipe.
  6. Remove the spark plug wire assembly.
    7. Fig 2: Locating Right Side Spark Plug Wires & Ignition Coil
    GM1608803Courtesy of GENERAL MOTORS CORP.
  7. Disconnect the right side spark plug wires from the right side spark plugs.
  8. Disconnect the left side spark plug wires from the ignition coil.
  9. If replacing only one plug wire, open the retaining clips and remove the spark plug wire.
  10. Remove the right side spark plug wire clip from the ignition coil bracket.
  11. Remove the spark plug wire assembly.
About FixVault