Technical Service Bulletins
- A/C Compressor
- Squeal or Whine Type Noise Coming from Engine Compartment (Replace Drive Belt Idler Pulley) (09-06-01-011)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- Accessories & Equipment
- Accessories Control Systems
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Key Code Information (99-00-89-011E)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- EI06038 - Left Front Door Will Not Lock/Unlock with Key, Lock Cylinder, Rod (Re-Engage Lock Rod to Clip) (06-08-52-003B)
- Rear Liftgate Glass May Not Lock When Using Remote Keyless Entry (RKE), Key Fob Transmitter or Door Lock Switch, And/Or Liftgate Hatch Or Liftgate Glass May Lock Then Unlock When Rear Liftgate Glass Button is Depressed (Reposition Lock Cylinder Wave Washer and Adjust Lock Rod) (07-08-52-003)
- Automatic Trans
- Vibration Analysis Worksheet (03-00-91-001I)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036H)
- No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008B)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- 4L60-E/4L65-E/4L70-E Automatic Transmission Fluid Leak from Oil Pump or Bell Housing Area (Replace Torque Converter Hub-to-Oil Pump Seal Assembly) (08-07-30-023)
- Engagement Time of Electronically Controlled Transmissions in General Motors Vehicles (Garage Shifts, Park to Reverse, Neutral to Drive, Neutral to Reverse, Park to Drive, Delayed Engagement) (03-07-30-007E)
- 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC® Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
- Information on 4L60-E M30 Rear Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0756, P0894, Harsh 1-2 Shift (07-07-30-024)
- 4L60-E/4L65-E/4L70-E Automatic Transmission Product Update (07-07-30-008)
- 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L65-E, 4L70-E, 4L80-E, 4L85-E, 5L40-E, 5L50-E, 6L50, 6L80, 6L90 or Allison(R) Transmissions (05-07-30-018A)
- New Labor Operation K5244 Shift Cable Adjustment (06-07-30-029)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Auxiliary Emission Control Systems
- Body Electrical
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Service 4WD Light Illuminated, DTC C0374 Set (Inspect Wiring Harness to Transfer Case Speed Sensors, Replace Wiring Harness) (05-04-21-003C)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- ABS Light On, DTC C0040 Stored (Inspect/Repair Wheel Speed Sensor Harness) (07-05-25-006)
- Erratic Speedometer Operation Or Speedometer Needle Shakes Above 60 mph (96 km/h) (Repair Poor Connection At Ground G108) (07-08-49-027)
- Information for Diagnosis and Repair of Rear Air Suspension (RPO G67) (06-03-99-001)
- Updated Transfer Case Connector Service Kit Now Available For Transfer Case Speed Sensor Wire Harness Connector that Comes Loose Or Connector Retainer Clip Breaks (06-04-21-001)
- Body Interior
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Squeal or Whine Type Noise Coming from Engine Compartment (Replace Drive Belt Idler Pulley) (09-06-01-011)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Communication Devices
- Language Change For ONSTAR® System (U.S. And CANADA Only) (05-08-46-009D)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- Availability of OnStar® for Hearing Impaired (06-08-46-005B)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Information on Verifying OnStar® System Function During Pre-Delivery Inspection (PDI) (06-08-46-006B)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- Saab 9-7X Electronics Ordering Process (05-08-44-020B)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Cooling System (Mechanical)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Entertainment Systems
- Radio Theft Light Inoperative After Radio Replacement And Programming (PIT3528D)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- DVD Will Not Eject or Play - GM Accessory Headrest DVD System (PIT4768A)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Buzz, Rattle or Vibration Noise from Front Door Bose® Speakers with Radio Set on High Volume (Isolate Rattle with Flocking Tape) (07-08-44-019A)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Saab 9-7X Electronics Ordering Process (05-08-44-020B)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- GM Accessories Headrest DVD System Display Monitor Inoperative (Install Cable Connector Clamps) (07-08-44-016A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Rear License Plate Pocket Perimeter Gasket Loose/Out of Position Or Excessive Amount Of Adhesive (Install New Gasket Using Updated Retainer Tightening Sequence) (04-08-66-001E)
- License Plate Pocket Applique Loose or Comes Off (Replace Applique) (06-08-111-003A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- Front Suspension
- Fuel System
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- General Motors' Position Regarding Use of E 15 in Model Year 2007 and Newer Vehicles (10-06-04-015)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Diagnostic Information for Finding a Restriction or Leak at Secondary Air Injection (SAI) System Inlet or Outlet Hoses - LL8 MIL/SES Light On, Repeat DTC P0411 (06-06-04-016A)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Gauges & Instrument Panels
- Information on Instrument Panel Cluster (IPC) Odometer and Engine Hour Meter Set Up at Dealership After IPC Replacement (07-08-49-015D)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Saab 9-7X Electronics Ordering Process (05-08-44-020B)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Erratic Speedometer Operation Or Speedometer Needle Shakes Above 60 mph (96 km/h) (Repair Poor Connection At Ground G108) (07-08-49-027)
- Right Side Instrument Panel Rattle Noise at Start-up or When Shifted into Gear (Tighten Screw) (07-08-49-024)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- New Labor Operation K5244 Shift Cable Adjustment (06-07-30-029)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- General Servicing
- Headlights
- HVAC Control Systems
- EI07213 - No Cold Air from Vents, A/C Inoperative, Blows Warm Air (07-01-39-007B)
- Inspecting Radiator and Heater Hose Clamps and Seals for Leaks During Pre-Delivery Inspection (PDI) (06-06-02-014B)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Air Conditioning Not Cold, Malfunction Indicator Lamp On, DTC P0116 (Reprogram PCM) (06-01-39-012)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Difficult To Install Fixed Radio Antenna Mast (07-08-44-010D)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- CD Error Message After Installing a Navigation Disc, After a Key Cycle or Concern May Be Intermittent (Update Navigation Radio Software) (07-08-44-014)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Interior/Exterior Trim
- Wind Noise From Drivers Side Windshield Or A-Pillar Area (PIT4555A)
- Wind Whistle Noise From Front Of The Vehicle At Speeds Above 55 Mph (PIT4601A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Front Floor Carpet Wet (Seal Top of "A" Pillar) (03-08-57-004D)
- Front Fascia Grille Insert(s) Missing or Loose (Apply Adhesive) (08-08-111-010)
- Headliner Sag at Center Dome Lamp (Reattach With Adhesive Sticks) (07-08-110-005A)
- Headliner Sag at Rear of Sunroof Opening (Apply Adhesive) (06-08-110-003B)
- Rubbing, Popping or Itch Type Noise at Right Rear Upper Corner of Vehicle (Adjust Sheet Metal) (08-08-67-003)
- Front Floor Carpet Poor Fit, Loose or Gaps Around Left Sill Plate or Foot Rest and/or Exposed Ground Bolt at Front Floor Console (Install Floor Deadener) (07-08-110-008)
- Center High-Mount Stop Lamp (CHMSL) Applique Loose (Re-Tape Applique) (01-08-66-007C)
- Cupholder Broken, Inoperative, Will Not Deploy, Rubs on Instrument Panel (IP) Trim Plate, Fails to Latch When Stored and Information on Avoiding IP Cover Damage (Replace or Align Cupholder) (05-08-49-024A)
- Manual Steering
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Squeal or Whine Type Noise Coming from Engine Compartment (Replace Drive Belt Idler Pulley) (09-06-01-011)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Manual Trans
- Mechanical
- Active Fuel Management (AFM) Engine, Valve Lifter Tick Noise At Start Up When Engine Has Been Off For 2 Hours Or More (Evaluate Noise And/Or Replace AFM Valve Lifters) (10-06-01-007E)
- Engine Stalls When Air Conditioning Is Turned On At Idle (PIT3116B)
- Supplement To Bulletin 06-06-01-017 - User Tips For En48464 (PIP3940C)
- Engine Rattle Noise After R And R Of The Crankshaft Balancer - Inspect Bolt Torque (PIP4581B)
- Vibration Analysis Worksheet (03-00-91-001I)
- 5.3L, 5.7L, 6.0L, 6.2L, 7.0L - Engine Oil Leak at Rear Cover Assembly Area (Engine Block Porosity RTV Repair Procedure) (05-06-01-034L)
- Squeal or Whine Type Noise Coming from Engine Compartment (Replace Drive Belt Idler Pulley) (09-06-01-011)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On Torque to Yield Bolt Breakage and Use of Bolt Extractor Tool Kit Part Number EN-47702 for Removing Broken Cylinder Head or Main Bearing Cap Bolts on Inline Truck Engines (05-06-01-026B)
- Information On New In-Vehicle Service Procedure for Removal/Installation of LL8 Cylinder Head (07-06-01-018A)
- LL8 Cylinder Head - Information on Service Replacement Cylinder Head Changes that Apply to 2006 and 2007 Model Years (08-06-01-001)
- Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
- Diagnostic Information on LL8 Engine Oil Leak from Rear of Crankshaft Due to Porosity (Follow Special Crankshaft Porosity Service Repair Procedure) (05-06-01-022B)
- Information on Revised Connecting Rod Bolt Torque for Small Block GEN III and GEN IV Vortec(tm) V8 Engines (07-06-01-002)
- Mechanical - Hydraulic
- Mirrors
- Paint & Coatings
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Paint Chipping Behind Front Wheels/Front of Rear Wheels, Damaged Lower Door/Cladding and Rocker Panels (Repaint Damaged Area, Install Assist Step) (03-08-111-002G)
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002C)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Vehicle Battery Maintenance While in Dealer Stock (05-06-03-007A)
- Automatic Dual Zone HVAC Battery Draw (02-01-39-007B)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Proper Connection Information to Avoid Blown 125 Amp Fuse and Various Interior Electrical System Conditions When Jump Starting Vehicle (04-06-03-005A)
- Intermittent No Crank, No Start (03-06-03-006A)
- Steering Column
- Steering Gear
- Sun Roof/T-Top/Convertible Top
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- New Part Availability and Service Procedure for Roof Panel (07-09-41-011)
- Suspension Control Systems
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- System
- Diagnostic Tips For SES Light With DTCS P1516 P2101 P2119 And/Or P2176 When Colder Than - 10F (-23C) (PIP4573B)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Diagnostic Trouble Codes (DTCs) Required On Repair Orders (06-00-89-050B)
- Diagnostic Information for Finding a Restriction or Leak at Secondary Air Injection (SAI) System Inlet or Outlet Hoses - LL8 MIL/SES Light On, Repeat DTC P0411 (06-06-04-016A)
- 4.2L LL8 Engine - Flashing and/or MIL/SES Light, Rough Idle, Misfire(s) DTC(s) P0300, P0301, P0302, P0303, P0304, P0305, P0306 (Install AIP Seal) (06-06-04-048B)
- Service Engine Soon Lamp Illuminated with Engine Cooling Fan System Performance DTC P0483 Currently Set or Stored in History (Reprogram PCM) (06-06-02-010B)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Towing
- Transfer Case
- NVG 126/226 Transfer Case Grating/Grinding Noise When 4WD Is Engaged, Service 4WD Lamp On, DTC C0327 Set (08-04-21-001B)
- Service 4WD Light Illuminated, DTC C0374 Set (Inspect Wiring Harness to Transfer Case Speed Sensors, Replace Wiring Harness) (05-04-21-003C)
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Updated Transfer Case Connector Service Kit Now Available For Transfer Case Speed Sensor Wire Harness Connector that Comes Loose Or Connector Retainer Clip Breaks (06-04-21-001)
- Transmission Control Systems
- NVG 126/226 Transfer Case Grating/Grinding Noise When 4WD Is Engaged, Service 4WD Lamp On, DTC C0327 Set (08-04-21-001B)
- Service 4WD Light Illuminated, DTC C0374 Set (Inspect Wiring Harness to Transfer Case Speed Sensors, Replace Wiring Harness) (05-04-21-003C)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008A)
- Automatic Transmission Shift Lock Control Actuator Available for Service Use (05-07-129-001B)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Wheels & Tire System
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004C)
- Information on Replacement Wheel Weights (09-03-10-017)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- EI07266 - Vehicle/Tire Vibration, P275/55R20, LT245/75R16, P265/70R17, P245/70R17, P285/45R22, LT265/75R17- Diagnostic Information to Reduce Vibration Concerns (07-03-10-013D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- ABS Light On, DTC C0040 Stored (Inspect/Repair Wheel Speed Sensor Harness) (07-05-25-006)
- Accessory Package - Installation of Cargo Capacity Reduction Label (U.S. Only) (07-00-89-027)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass) (09-08-48-006)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Warranty Admin - Guidelines for Claiming C0034 - Windshield Replacement (72-05-04)
- Rear Liftgate Glass May Not Lock When Using Remote Keyless Entry (RKE), Key Fob Transmitter or Door Lock Switch, And/Or Liftgate Hatch Or Liftgate Glass May Lock Then Unlock When Rear Liftgate Glass Button is Depressed (Reposition Lock Cylinder Wave Washer and Adjust Lock Rod) (07-08-52-003)
- Liftgate Glass Squeak Noise When Opening (Lubricate Hinge) (06-08-59-002B)
- Availability and Use of Acoustic Windshield and Front Door Glass (04-08-48-002C)
- Wiper/Washer Systems