Technical Service Bulletins
- A/C Compressor
- Squeal or Whine Type Noise Coming from Engine Compartment (Replace Drive Belt Idler Pulley) (09-06-01-011)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- Accessories & Equipment
- Accessories Control Systems
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Vehicle Will Not Start, Dead Battery (Inspect for Parasitic Draw) (09-06-03-003D)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Key Code Information (99-00-89-011E)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Rear Liftgate Glass May Not Lock When Using Remote Keyless Entry (RKE), Key Fob Transmitter or Door Lock Switch, And/Or Liftgate Hatch Or Liftgate Glass May Lock Then Unlock When Rear Liftgate Glass Button is Depressed (Reposition Lock Cylinder Wave Washer and Adjust Lock Rod) (07-08-52-003)
- Automatic Trans
- Vibration Analysis Worksheet (03-00-91-001I)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036H)
- No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- 4L60-E/4L65-E/4L70-E Automatic Transmission Fluid Leak from Oil Pump or Bell Housing Area (Replace Torque Converter Hub-to-Oil Pump Seal Assembly) (08-07-30-023)
- Engagement Time of Electronically Controlled Transmissions in General Motors Vehicles (Garage Shifts, Park to Reverse, Neutral to Drive, Neutral to Reverse, Park to Drive, Delayed Engagement) (03-07-30-007E)
- 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC® Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
- 4L60-E/4L65-E/4L70-E Automatic Transmission Product Update (07-07-30-008)
- Body Electrical
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- ABS Light On, DTC C0040 Stored (Inspect/Repair Wheel Speed Sensor Harness) (07-05-25-006)
- Erratic Speedometer Operation Or Speedometer Needle Shakes Above 60 mph (96 km/h) (Repair Poor Connection At Ground G108) (07-08-49-027)
- Body Interior
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Vehicle Will Not Start, Dead Battery (Inspect for Parasitic Draw) (09-06-03-003D)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Squeal or Whine Type Noise Coming from Engine Compartment (Replace Drive Belt Idler Pulley) (09-06-01-011)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Communication Devices
- Language Change For ONSTAR® System (U.S. And CANADA Only) (05-08-46-009D)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- Availability of OnStar® for Hearing Impaired (06-08-46-005B)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Information on Verifying OnStar® System Function During Pre-Delivery Inspection (PDI) (06-08-46-006B)
- Saab 9-7X Electronics Ordering Process (05-08-44-020B)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Cooling System (Mechanical)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Diagnostic Tips For SES Light With DTCS P1516 P2101 P2119 And/Or P2176 When Colder Than - 10F (-23C) (PIP4573B)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Malfunction Indicator Lamp (MIL) Illuminated, DTCs P0300-P0306 Set, Engine Runs Rough (Inspect for Water Intrusion in Spark Plug Recess Area, Replace Spark Plug and Ignition Coil, Seal Ignition Coil Bolt Hole Vents and Seal Hood Air Grille) (09-06-04-025A)
- Entertainment Systems
- Radio Theft Light Inoperative After Radio Replacement And Programming (PIT3528D)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- EI08176 - DVD, CD Display/Touch Screen, Navigation Map, Audio, Radio Inoperative, Replacement (Engineering Information Closed) (08-08-44-017A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- DVD Will Not Eject or Play - GM Accessory Headrest DVD System (PIT4768A)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Buzz, Rattle or Vibration Noise from Front Door Bose® Speakers with Radio Set on High Volume (Isolate Rattle with Flocking Tape) (07-08-44-019A)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Saab 9-7X Electronics Ordering Process (05-08-44-020B)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- GM Accessories Headrest DVD System Display Monitor Inoperative (Install Cable Connector Clamps) (07-08-44-016A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Rear License Plate Pocket Perimeter Gasket Loose/Out of Position Or Excessive Amount Of Adhesive (Install New Gasket Using Updated Retainer Tightening Sequence) (04-08-66-001E)
- License Plate Pocket Applique Loose or Comes Off (Replace Applique) (06-08-111-003A)
- Front Suspension
- Fuel System
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- General Motors' Position Regarding Use of E 15 in Model Year 2007 and Newer Vehicles (10-06-04-015)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Gauges & Instrument Panels
- Information on Instrument Panel Cluster (IPC) Odometer and Engine Hour Meter Set Up at Dealership After IPC Replacement (07-08-49-015D)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Saab 9-7X Electronics Ordering Process (05-08-44-020B)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Erratic Speedometer Operation Or Speedometer Needle Shakes Above 60 mph (96 km/h) (Repair Poor Connection At Ground G108) (07-08-49-027)
- Right Side Instrument Panel Rattle Noise at Start-up or When Shifted into Gear (Tighten Screw) (07-08-49-024)
- General Servicing
- Headlights
- HVAC Control Systems
- EI07213 - No Cold Air from Vents, A/C Inoperative, Blows Warm Air (07-01-39-007B)
- Inspecting Radiator and Heater Hose Clamps and Seals for Leaks During Pre-Delivery Inspection (PDI) (06-06-02-014B)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Difficult To Install Fixed Radio Antenna Mast (07-08-44-010D)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Interior/Exterior Trim
- Wind Noise From Drivers Side Windshield Or A-Pillar Area (PIT4555A)
- Wind Whistle Noise From Front Of The Vehicle At Speeds Above 55 Mph (PIT4601A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Front Floor Carpet Wet (Seal Top of "A" Pillar) (03-08-57-004D)
- Front Fascia Grille Insert(s) Missing or Loose (Apply Adhesive) (08-08-111-010)
- Headliner Sag at Center Dome Lamp (Reattach With Adhesive Sticks) (07-08-110-005A)
- Headliner Sag at Rear of Sunroof Opening (Apply Adhesive) (06-08-110-003B)
- Rubbing, Popping or Itch Type Noise at Right Rear Upper Corner of Vehicle (Adjust Sheet Metal) (08-08-67-003)
- Front Floor Carpet Poor Fit, Loose or Gaps Around Left Sill Plate or Foot Rest and/or Exposed Ground Bolt at Front Floor Console (Install Floor Deadener) (07-08-110-008)
- Center High-Mount Stop Lamp (CHMSL) Applique Loose (Re-Tape Applique) (01-08-66-007C)
- Manual Steering
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Squeal or Whine Type Noise Coming from Engine Compartment (Replace Drive Belt Idler Pulley) (09-06-01-011)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Manual Trans
- Mechanical
- Active Fuel Management (AFM) Engine, Valve Lifter Tick Noise At Start Up When Engine Has Been Off For 2 Hours Or More (Evaluate Noise And/Or Replace AFM Valve Lifters) (10-06-01-007E)
- Engine Stalls When Air Conditioning Is Turned On At Idle (PIT3116B)
- Engine Rattle Noise After R And R Of The Crankshaft Balancer - Inspect Bolt Torque (PIP4581B)
- Vibration Analysis Worksheet (03-00-91-001I)
- 5.3L, 5.7L, 6.0L, 6.2L, 7.0L - Engine Oil Leak at Rear Cover Assembly Area (Engine Block Porosity RTV Repair Procedure) (05-06-01-034L)
- Squeal or Whine Type Noise Coming from Engine Compartment (Replace Drive Belt Idler Pulley) (09-06-01-011)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On Torque to Yield Bolt Breakage and Use of Bolt Extractor Tool Kit Part Number EN-47702 for Removing Broken Cylinder Head or Main Bearing Cap Bolts on Inline Truck Engines (05-06-01-026B)
- Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
- Information on Revised Connecting Rod Bolt Torque for Small Block GEN III and GEN IV Vortec(tm) V8 Engines (07-06-01-002)
- Mechanical - Hydraulic
- Mirrors
- Paint & Coatings
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Paint Chipping Behind Front Wheels/Front of Rear Wheels, Damaged Lower Door/Cladding and Rocker Panels (Repaint Damaged Area, Install Assist Step) (03-08-111-002G)
- Rear Suspension
- Seats
- Starter
- Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002C)
- Vehicle Will Not Start, Dead Battery (Inspect for Parasitic Draw) (09-06-03-003D)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Vehicle Battery Maintenance While in Dealer Stock (05-06-03-007A)
- Automatic Dual Zone HVAC Battery Draw (02-01-39-007B)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Steering Column
- Steering Gear
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- System
- Diagnostic Tips For SES Light With DTCS P1516 P2101 P2119 And/Or P2176 When Colder Than - 10F (-23C) (PIP4573B)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Transfer Case
- Transmission Control Systems
- Wheels & Tire System
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004C)
- Information on Replacement Wheel Weights (09-03-10-017)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- EI07266 - Vehicle/Tire Vibration, P275/55R20, LT245/75R16, P265/70R17, P245/70R17, P285/45R22, LT265/75R17- Diagnostic Information to Reduce Vibration Concerns (07-03-10-013D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Driveline Characteristics For All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- ABS Light On, DTC C0040 Stored (Inspect/Repair Wheel Speed Sensor Harness) (07-05-25-006)
- Accessory Package - Installation of Cargo Capacity Reduction Label (U.S. Only) (07-00-89-027)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass) (09-08-48-006)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Warranty Admin - Guidelines for Claiming C0034 - Windshield Replacement (72-05-04)
- Rear Liftgate Glass May Not Lock When Using Remote Keyless Entry (RKE), Key Fob Transmitter or Door Lock Switch, And/Or Liftgate Hatch Or Liftgate Glass May Lock Then Unlock When Rear Liftgate Glass Button is Depressed (Reposition Lock Cylinder Wave Washer and Adjust Lock Rod) (07-08-52-003)
- Wiper/Washer Systems