Section 1 (Basic Engine, 2.0L)
WARNING: This page is about a different variant/trim than selected.
- Technical data
- Fastener Tightening Specifications (LDK, LHU)
- Engine Mechanical Specifications (LDK, LHU)
- Adhesives, Fluids, Lubricants, and Sealers (LDK, LHU)
- Thread Repair Specifications (LDK, LHU)
- Engine Block - Front View
- Engine Block - Back View
- Engine Block - Right Side View
- Engine Block - Bottom View
- Engine Block - Left Side View
- Engine Block - Top View
- Lower Crankcase - Front View
- Lower Crankcase - Back View
- Lower Crankcase - Bottom View
- Lower Crankcase - Right View
- Lower Crankcase - Left View
- Cylinder Head - Top View
- Cylinder Head - Intake Manifold Deck View
- Cylinder Head - Exhaust Manifold Deck View
- Cylinder Head - Front View
- Cylinder Head - Back View
- Special tools
- Technical description
- Disassembled Views (LDK, LHU)
- Engine Identification (LDK, LHU)
- Crankcase Ventilation System Description
- Engine Component Description
- Lubrication Description
- Evaporative Emission Control System Description
- Cleanliness and Care
- Separating Parts
- Replacing Engine Gaskets
- Use of Room Temperature Vulcanizing (RTV) and Anaerobic Sealant
- Tools and Equipment
- Fault Diagnosis General
- Fault diagnosis, symptoms
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises (LDK, LHU)
- Base Engine Misfire with Abnormal Internal Lower Engine Noises (LDK, LHU)
- Base Engine Misfire with Abnormal Valve Train Noise (LDK, LHU)
- Base Engine Misfire with Coolant Consumption (LDK, LHU)
- Base Engine Misfire with Excessive Oil Consumption (LDK, LHU)
- Engine Noise on Start-Up, but Only Lasting a Few Seconds (LDK, LHU)
- Upper Engine Noise, Regardless of Engine Speed (LDK, LHU)
- Lower Engine Noise, Regardless of Engine Speed (LDK, LHU)
- Engine Noise Under Load (LDK, LHU)
- Engine Will Not Crank - Crankshaft Will Not Rotate (LDK, LHU)
- Coolant in Combustion Chamber (LDK, LHU)
- Coolant in Engine Oil (LDK, LHU)
- Turbocharger Whine Noise (LDK, LHU)
- Turbocharger Hissing Noise (LDK, LHU)
- Turbocharger Oil Leak From Compressor Seal (LDK. LHU)
- Turbocharger Oil Leak From Turbine Seal (LDK, LHU)
- Turbocharger Lack of Oil Supply (LDK. LHU)
- Engine Compression Test
- Crankcase Ventilation System Inspection/Diagnosis (With Turbocharger)
- Drive Belt Tensioner Diagnosis
- Timing Chain Check
- Adjustment Replacement
- Time studies - Engine, mechanical
- Time studies - Turbocharger system
- Belt Idler Pulley Replacement
- Drive Belt Replacement
- Drive Belt Tensioner Replacement
- Engine Oil Pressure Switch Replacement
- Oil Pressure Relief Valve Replacement
- Engine Mount Bracket Replacement
- Engine Support Fixture (Rear Side)
- Engine Support Fixture (Front Side)
- Engine Support Fixture (Mounting Engine/Transmission)
- Engine Support Fixture (Centering Adapter)
- Engine Support Fixture (Engine Bridge, Retainer Frame)
- Engine Mounting - Right Side, Replacement
- Catalytic Converter Brace Bracket Replacement
- Catalytic Converter Brace Replacement
- Oil Level Indicator Tube Replacement
- Positive Crankcase Ventilation Hose/Pipe/Tube Replacement
- Turbocharger Heat Shield, Replacement
- Turbocharger Stay, Replacement
- Turbocharger replacement
- Turbocharger Oil Feed Pipe Replacement
- Turbocharger Oil Return Pipe Replacement
- Charge Air Cooler Inlet Air Tube Replacement
- Charge Air Cooler Outlet Air Hose Replacement
- Charge Air Cooler Inlet Air Hose Replacement
- Engine Sight Shield Replacement
- Engine Cover and Fuel Pipe Bracket, Replacement
- Engine Sight Bracket Replacement
- Fuel Pump Cover Replacement
- Exhaust Front Pipe Replacement
- Intake Manifold Replacement
- Intake Manifold Brace Replacement
- Timing Chain Crankshaft Sprocket Replacement
- Water Pump and Balance Shaft Chain Crankshaft Sprocket Replacement
- Crankshaft Balancer Replacement
- Crankshaft Front Oil Seal Replacement
- Oil Pump Housing Replacement
- Oil Pump Gear Replacement
- Balancer Chain Adjust Guide Replacement
- Balancer Chain Guide Replacement - Lower
- Balancer Shaft Chain Guide Replacement - Upper
- Water Pump and Balance Shaft Chain Replacement
- Water Pump and Balance Shaft Chain Tensioner Replacement
- Water Pump Cover Replacement
- Balancer Shaft Chain Sprocket Replacement - Exhaust Side
- Balancer Shaft Chain Sprocket Replacement - Intake Side
- Camshaft Cover Replacement
- Camshaft Timing Chain Adjustment
- Camshaft Chain Tensioner (LHU/A20NFT) Replacement
- Timing Chain Replacement
- Adjustable Timing Chain Guide Replacement
- Timing Chain Guide Replacement
- Timing Chain Guide Replacement - Upper
- Timing Chain Oil Nozzle Replacement
- Hydraulic Valve Lash Adjuster Replacement - Exhaust
- Hydraulic Valve Lash Adjuster Replacement - Intake
- Intake Camshaft and Valve Lifter Replacement
- Exhaust Camshaft and Valve Lifter Replacement
- Camshaft Position Intake Actuator Replacement
- Camshaft Position Exhaust Actuator Replacement
- Valve Stem Oil Seal and Valve Spring Replacement
- Cylinder Head Opening Plate Replacement
- Cylinder Head Replacement
- Engine Oil Cooler Replacement
- Oil Pan Replacement
- Piston, Connecting Rod, and Bearing Replacement
- Crankshaft Rear Oil Seal Replacement
- Flywheel Motor Replacement (Automatic Transmission)
- Engine (FWD) Replacement
- Engine (AWD) Replacement
- Engine Oil and Oil Filter Replacement (Engine Oil)
- Engine Oil Change and Filter Replacement (Filter with Cover and Seal)
- Engine Mounting to Stand
- Engine Oil Cooler (LDK, LHU) Removal
- Draining Fluids and Oil Filter Removal
- Crankshaft Balance Weight Removal
- Engine Flywheel (Automatic Transmission) Removal
- Oil Dipstick and Tube (LDK, LHU) Removal
- Starter Motor (LDK, LHU) Removal
- Intake Manifold (LDK, LHU) Removal
- Fuel Rail and Injector (LDK, LHU) Removal
- Turbocharger (LDK, LHU) Removal
- Exhaust Manifold (LDK, LHU) Removal
- Camshaft Cover (LDK, LHU) Removal
- Engine Front Cover and Oil Pump Removal
- Timing Chain and Tensioner (LDK, LHU) Removal
- Intake and Exhaust Camshaft, Bearing Cap and Valve Clearance Adjuster (LDK, LHU) Removal
- Water Pump and Balance Shaft Chain and Tensioner Removal
- Balancer Shaft Removal
- Water Pump (LDK, LHU) Removal
- Cylinder Head (LDK, LHU) Removal
- Oil Pan (LDK, LHU) Removal
- Piston, Connecting Rod and Bearing (LDK, LHU) Removal
- Lower Crankcase Removal
- Crankshaft and Bearing Removal
- Cylinder Block (LDK, LHU) Dismantling
- Engine Block Cleaning and Inspection
- Cylinder Honing
- Cylinder Liner Removal
- Cylinder Liner Installation
- Crankshaft Balancer Cleaning and Inspection
- Engine Flywheel Cleaning and Inspection
- Crankshaft and Bearing Cleaning and Check
- Piston and Connecting Rod (LDK, LHU) Removal
- Piston, Connecting Rod, and Bearing (LDK, LHU) Cleaning and Check
- Piston and Connecting Rod Installation (LDK, LHU)
- Camshaft Cleaning and Inspection (LDK, LHU)
- Camshaft Timing Chain and Sprocket Cleaning and Inspection (LDK, LHU)
- Balance Shaft Cleaning and Inspection
- Water Pump and Balancer Shaft Chain and Sprocket Cleaning and Check (LDK, LHU)
- Cylinder Head Dismantling (LDK, LHU)
- Cylinder Head Cleaning and Check (LDK, LHU)
- Valve and Seat Grinding
- Valve Measurement and Reconditioning Overview
- Valve Seat Width Measurement Procedure
- Valve Seat Roundness Measurement Procedure
- Valve Head O.D. and Chamfer Measurement Procedure
- Valve-to-Seat Concentricity Measurement Procedure
- Valve and Seat Reconditioning Procedure
- Valve Stem Height Measurement Procedure
- Cylinder Head Assembly (LDK, LHU)
- Oil Pump Dismantling
- Oil Pump Assemble
- Turbocharger Cleaning and Inspection (LDK, LHU)
- Fuel Rail and Injector Cleaning and Inspection (LDK, LHU)
- Intake Manifold Cleaning and Inspection (LDK, LHU)
- Exhaust Manifold Cleaning and Inspection (LDK, LHU)
- Oil Pan Cleaning and Check (LDK, LHU)
- Thread Repair
- Service Prior to Assembly
- Cylinder Block Cleaning and Check (LDK, LHU)
- Crankshaft and Bearing Installation
- Lower Crankcase Installation (LDK, LHU)
- Crankshaft Rear Oil Seal Installation
- Piston, Connecting Rod and Bearing Installation (LDK, LHU)
- Cylinder Head Installation (LDK, LHU)
- Intake and Exhaust Camshaft, Bearing Cap and Valve Clearance Adjuster (LDK, LHU) Installation
- Balance Shaft Installation
- Water Pump Installation (LDK, LHU)
- Balance Shaft to Engine Timing (LDK, LHU)
- Water Pump and Balance Shaft Chain and Tensioner Installation
- Camshaft Timing Gear, Sprocket and Tensioner Installation (LDK, LHU)
- Crankshaft Front Oil Seal Installation (LDK, LHU)
- Engine Front Cover and Oil Pump Installation
- Oil Pan Installation (LDK, LHU)
- Oil Level Indicator and Pipe Installation (LDK, LHU)
- Engine Oil Cooler Installation (LDK, LHU)
- Engine Flywheel Installation (Automatic Transmission)
- Crankshaft Balancer Installation (LDK, LHU)
- Camshaft Cover Installation (LDK, LHU)
- Oil Filter with Cap and Seal Installation
- Fuel Rail and Injector Installation (LDK, LHU)
- Intake Manifold Installation (LDK, LHU)
- Exhaust Manifold Installation (LDK, LHU)
- Turbocharger Installation (LDK, LHU)
- Starter Motor Installation (LDK, LHU)
- Engine Prelubing
- Removing Engine in Stand
- Engine Cleaning and Inspection
- Installing Engine in Stand
- Wiring diagram